CASE IH Magnum 310 Tractor
CASE IH Magnum 310 Tractor — parts list, part 3 of 5
Assemblies on this page: 06-12 RANGE TRANSMISSION – HOUSING … 08-01 HYDRAULIC SYSTEM – OIL COOLER STANDARD PERFORMANCE.
06-12 RANGE TRANSMISSION – HOUSING
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87435223 | 1 | HOUSING ASSY., Inc. 2 – 8 |
| 2 | 837-16035 | 4 | DOWEL, M16 x 35 |
| 3 | 837-12025 | 2 | DOWEL, M12 x 25 |
| 4 | 192792A1 | 1 | PLUG, 3/4″ |
| 5 | 327080A1 | 1 | PLUG, 1-1/4 |
| 6 | 41-1018 | 1 | PLUG, Cup, 1 1/8″ |
| 7 | 41-1038 | 1 | PLUG, Cup, 2 3/8″ |
| 8 | 238-6112 | 1 | O-RING, -112, 90 Duro, .487″ ID x .103″ Thk |
| 9 | 828-16085 | 2 | BOLT, Hex, M16 x 85, 10.9 |
| 10 | 828-16060 | 6 | BOLT, Hex, M16 x 60, 10.9, Full Thd |
| 11 | 828-16060 | 9 | BOLT, Hex, M16 x 60, 10.9, Full Thd |
| 12 | 828-16120 | 1 | BOLT, Hex, M16 x 120, 10.9 |
| 13 | 896-12016 | 24 | WASHER, M17.5 x 30 x 4, HT |
| 14 | 829-1316 | 1 | NUT, M16, Cl 10 |
| 15 | 828-16070 | 3 | BOLT, Hex, M16 x 70, 10.9 |
| 20 | 93364C1 | 1 | COVER |
| 21 | 628-10025 | 12 | BOLT, Hex, M10 x 25, 10.9, Full Thd |
| 22 | 225209A1 | 1 | COVER |
| 23 | 628-10025 | 7 | BOLT, Hex, M10 x 25, 10.9, Full Thd, , Transmission BSN AJB0366737 |
| 23 | 87015732 | 7 | BOLT, M10 x 20 mm, 10.9, Full Thread, Transmission ASN AJB0366737 |
| 24 | 301533R1 | 1 | BEARING |
| 25 | 275531A1 | 1 | HEATER, 240 Volt |
| 30 | 235976A2 | 1 | TUBE |
| 31 | 256544A1 | 3 | TUBE |
| 32 | 238-5014 | 8 | O-RING, -014, 70 Duro, .489″ ID x .070″ Thk |
| 33 | 300828A1 | 1 | TUBE |
| 34 | 238-5019 | 2 | O-RING, -019, 70 Duro, .801″ ID x .070″ Thk |
| 35 | 253385A2 | 1 | GASKET |
| 36 | 445537A2 | 1 | VALVE, Inching, See Figure 06-13 |
| 37 | 861-10045 | 4 | SCREW, Hex Soc Hd, M10 x 45, 12.9 |
| 38 | 87390949 | 1 | GASKET |
| 39 | 92821C2 | 1 | GASKET |
| 40 | 828-16090 | 2 | BOLT, Hex, M16 x 90, 10.9 |
| 41 | 87308873 | 1 | SCREW, 12 Pt Hd, M16 x 90, 12.9 |
| 43 | 87422106 | 1 | SENSOR, Speed, Transmission BSN AJB0372635 |
| 43 | 87548198 | 1 | SENSOR, Speed, Transmission ASN AJB0372635 |
| 44 | 238-5115 | 1 | O-RING, -115, 70 Duro, .674″ ID x .103″ Thk |
| 45 | 87631267 | 1 | HARNESS, WIRE, Speed Sensor, Transmission ASN AJB0372635 |
| 46 | 436282A1 | 1 | HARNESS, WIRE, Power Supply Cord (Shown) |
| 46 | 436281A1 | 1 | HARNESS, WIRE, Power Supply Cord, U.K. Only |
06-13 VALVE ASSY – INCHING
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | 221578A1 | 1 | PLUG, Hex Soc, M18 x 1.5, ORB, Inc. 3 |
| 3 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 4 | 221580A1 | 1 | PLUG, Hex Soc, M27 x 2, ORB, Inc. 5 |
| 5 | 637-64236 | 1 | O-RING, Cl 6, 23.6MM ID x 2.9 Thk |
| 9 | 238-7016 | 1 | O-RING, -016, Cl 7, .614″ ID x .070″ Thk |
| 10 | 238-7018 | 1 | O-RING, -018, Cl 7, .739″ ID x .070″ Thk |
| 11 | 237-6008 | 1 | O-RING, 8-1, 90 Duro, .644″ ID x .087″ Thk |
| 12 | 238-5014 | 1 | O-RING, -014, 70 Duro, .489″ ID x .070″ Thk |
| 13 | 238-5013 | 1 | O-RING, -013, 70 Duro, .426″ ID x .070″ Thk |
| 20 | 221576A1 | 1 | PLUG, Hex Soc, M14 x 1.5, ORB, Inc. 21 |
| 21 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 28 | 221576A1 | 1 | PLUG, Hex Soc, M14 x 1.5, ORB, Inc. 29 |
| 29 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 31 | 445494A1 | 1 | SPRING, VALVE |
| 32 | 238-5012 | 1 | O-RING, -012, 70 Duro, .364″ ID x .070″ Thk |
| 33 | 211-1009 | 1 | BALL, 9/32; 24,CRS |
| 34 | 100-2131 | 1 | RING, SNAP, 0.312″, Int, #31 |
| 35 | 86988656 | 1 | WASHER, SPRING |
| 36 | 253385A2 | 1 | GASKET |
| 37 | 861-10045 | 4 | SCREW, Hex Soc Hd, M10 x 45, 12.9 |
06-14 RANGE TRANSMISSION – INPUT SHAFT
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87434653 | 1 | SHAFT ASSY., Inc. 2 |
| 2 | 187516A1 | 4 | PLUG |
| 8 | 1286040C2 | 1 | RING |
| 9 | 1997888C1 | 1 | WASHER, THRUST |
| 10 | 80909C1 | 2 | BEARING, NEEDLE |
| 11 | 86987610 | 1 | GEAR, 37T |
| 12 | 86987612 | 1 | PINION, 59T |
| 13 | 1286052C1 | 2 | RING |
| 14 | 1286043C1 | 4 | WASHER, THRUST |
| 17 | 87434656 | 2 | RING, Lube |
| 18 | 572182R1 | 2 | BEARING, THRUST |
| 19 | 101-11250 | 6 | RING, SNAP, #250, 2.356, Ext |
| 20 | 87425389 | 18 | SPRING, BELLEVILLE |
| 21 | 86987596 | 2 | CARRIER |
| 22 | 1286081C1 | 2 | O-RING |
| 23 | 1286076C1 | 2 | RING |
| 24 | 86987597 | 2 | PISTON |
| 25 | 1286083C1 | 2 | O-RING |
| 26 | 1286079C1 | 2 | RING |
| 31 | 86990276 | 22 | DISC, Friction |
| 32 | 92934C2 | 22 | DISC, Separator |
| 33 | 1342645C3 | 2 | DISC, CLUTCH |
| 34 | 1285996C1 | 2 | RING, SNAP |
| 35 | 1285971C1 | 1 | GEAR, DRIVING |
| 36 | A75211 | 1 | BEARING, CONE |
| 37 | A75210 | 1 | BEARING, CUP |
| 39 | ST2063 | 1 | BEARING, CONE |
| 40 | 54404R1 | 1 | BEARING, CUP |
| 44 | 281696A1 | 1 | SUPPORT |
| 45 | 814-12050 | 6 | BOLT, Hex, M12 x 50, 8.8 |
| 46 | 1286025C1 | 4 | RING |
| 47 | 254337A2 | 1 | CAGE |
| 48 | 1286061C1 | 2 | SHIM, 0.08 mm |
| 48 | 1286062C1 | 2 | SHIM, 0.10 mm |
| 48 | 1286063C1 | 2 | SHIM, 0.13 mm |
| 48 | 1286064C1 | 2 | SHIM, 0.30 mm |
| 48 | 1286065C1 | 2 | SHIM, 0.76 mm |
| 49 | 613-10030 | 3 | BOLT, Hex, M10 x 30, 8.8, Full Thd |
06-15 RANGE TRANSMISSION – MASTER CLUTCH
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87434653 | 1 | SHAFT ASSY., , See Figure 06-14 |
| 2 | 254337A2 | 1 | CAGE |
| 3 | 101-11225 | 1 | RING, SNAP, #225, Ext |
| 4 | 1286027C2 | 1 | RING |
| 10 | 87311451 | 1 | CARRIER |
| 11 | 93138C1 | 1 | O-RING |
| 12 | 92562C1 | 1 | RING |
| 13 | 93137C1 | 1 | O-RING |
| 14 | 92561C1 | 1 | RING |
| 15 | 112299A2 | 1 | PISTON ASSY |
| 18 | 93136C2 | 16 | SPRING |
| 19 | 112329A3 | 1 | RETAINER |
| 21 | 100-11306 | 1 | RING, SNAP, #306, Ext |
| 22 | 92555C1 | 1 | RING |
| 23 | 235913A3 | 1 | HUB |
| 24 | 235987A1 | 1 | RING |
| 27 | 100-11200 | 1 | RING, SNAP, #200, Ext |
| 31 | 1285974C1 | 9 | PLATE, BRAKE, Separator |
| 32 | 1285975C2 | 9 | DISC, CLUTCH, Friction |
| 33 | 235851A2 | 1 | DISC, Backing |
| 34 | 1963876C1 | 1 | RING, SNAP |
| 43 | 218-5105 | 1 | ELBOW, 90є, 9/16″-18, 37є x 9/16″-18, O-Ring, Inc. 44 |
| 45 | 1963935C2 | 1 | TUBE |
| 44 | 237-6006 | 1 | O-RING, 6-1, 90 Duro, .468″ ID x .078″ Thk |
06-16 RANGE TRANSMISSION – COUNTERSHAFT
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87434362 | 1 | SHAFT ASSY. |
| 2 | 38-3605 | 3 | PIN, 3/32″ x 5/16″, Coiled |
| 3 | D63322 | 1 | BEARING, NEEDLE |
| 4 | 144348C1 | 1 | RING, SNAP |
| 5 | 87425389 | 11 | SPRING, BELLEVILLE |
| 6 | 87434656 | 1 | RING, Lube |
| 8 | 1286043C1 | 2 | WASHER, THRUST |
| 9 | 572182R1 | 1 | BEARING, THRUST |
| 10 | 101-11250 | 1 | RING, SNAP, #250, 2.356, Ext |
| 11 | 1285978C1 | 1 | PINION, 39T |
| 12 | 1286052C1 | 1 | RING |
| 13 | 220057A1 | 1 | GEAR, 25T |
| 14 | 1286041C2 | 1 | SPACER |
| 15 | 1285990C2 | 1 | PINION, 23T |
| 18 | 84986C1 | 1 | BEARING, CONE, , With 10 Bolt Hub |
| 18 | 253485A1 | 1 | BEARING, CONE, , With 12 Bolt Hub |
| 19 | 40435 | 1 | BEARING, CUP, , With 10 Bolt Hub |
| 19 | 253486A1 | 1 | BEARING, CUP, , With 12 Bolt Hub |
| 20 | 1286042C1 | 4 | WASHER, THRUST |
| 21 | 87012543 | 2 | BEARING, THRUST |
| 22 | 87439841 | 1 | GEAR, 54T |
| 23 | 1286077C1 | 1 | RING |
| 24 | 1286081C1 | 1 | O-RING |
| 25 | 242491A5 | 1 | PISTON |
| 26 | 1286079C1 | 1 | RING |
| 27 | 1286083C1 | 1 | O-RING |
| 31 | 128114A1 | 1 | DISC, Separator |
| 32 | 86990276 | 15 | DISC, Friction |
| 33 | 92934C2 | 14 | DISC, Separator |
| 34 | 1342645C3 | 1 | DISC, CLUTCH |
| 35 | 1285996C1 | 1 | RING, SNAP |
| 36 | 1286028C2 | 2 | RING |
| 37 | 297418A2 | 2 | SEAL |
| 39 | 80907C1 | 2 | BEARING, NEEDLE |
| 40 | 93269C1 | 1 | SPACER |
| 41 | 1286038C2 | 1 | SPACER |
| 42 | 287679C1 | 1 | BEARING, ROLLER |
| 43 | 1968297C1 | 1 | BEARING, CUP |
| 44 | 87435631 | 1 | CAGE, Inc. 45 |
| 45 | 1345888C1 | 1 | PLUG |
| 47 | 613-10030 | 4 | BOLT, Hex, M10 x 30, 8.8, Full Thd |
| 50 | 1286066C1 | 2 | SHIM, 0.08 mm |
| 50 | 1286067C1 | 2 | SHIM, 0.10 mm |
| 50 | 1286068C1 | 2 | SHIM, 0.13 mm |
| 50 | 1286069C1 | 2 | SHIM, 0.30 mm |
| 50 | 1286070C1 | 2 | SHIM, 0.76 mm |
06-17 TRANSMISSION – PINION SHAFT AND GEARS
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 94616C2 | 1 | GEAR SET, Inc. 2, 25, 26 |
| 2 | 92825C1 | 1 | PLUG |
| 3 | 87618938 | 1 | GEAR, DRIVEN, 46T |
| 4 | 1286039C1 | 1 | SPACER |
| 5 | 143906C1 | 1 | RING, SNAP |
| 6 | 921684C1 | 1 | BEARING, CONE |
| 7 | 1068264C1 | 1 | CAGE, Inc. 8 |
| 8 | 921683C1 | 1 | BEARING, CUP |
| 10 | 120965C1 | 1 | RING, SNAP |
| 11 | 108326H | 1 | BEARING, CUP |
| 12 | 94666C1 | 1 | BEARING, CONE |
| 13 | 131432A1 | 1 | RING, 3.62 mm |
| 13 | 94661C1 | 1 | RING, 3.70 mm |
| 13 | 94662C1 | 1 | RING, 3.78 mm |
| 13 | 94663C1 | 1 | RING, 3.86 mm |
| 13 | 110042C1 | 1 | RING, 3.93 mm |
| 13 | 94664C1 | 1 | RING, 4.02 mm |
| 13 | 131433A1 | 1 | RING, 4.10 mm |
| 13 | 131434A1 | 1 | RING, 4.18 mm |
| 17 | 120977C1 | 2 | SHIM, 0.08 mm |
| 17 | 120978C1 | 2 | SHIM, 0.10 mm |
| 17 | 120979C1 | 2 | SHIM, 0.13 mm |
| 17 | 120980C1 | 2 | SHIM, 0.30 mm |
| 18 | 566-12035 | 6 | SCREW, 12 Pt Hd, M10 x 35, 12.9 |
| 19 | 1251958C1 | 6 | WASHER |
06-18 TRANSMISSION – DIFFERENTIAL
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | 229594A1 | 1 | CAGE, , Transmission Number BSN AJB368081 |
| 2 | 87366283 | 1 | CASE, , Transmission Number ASN AJB368081 |
| 3 | 137023A1 | 6 | DOWEL, , Transmission Number BSN AJB368081 |
| 4 | 148939C1 | 2 | SEAL |
| 7 | 1259633C3 | 1 | GEAR |
| 8 | 92905C1 | 4 | PINION, 10T |
| 9 | 1259634C3 | 1 | PINION |
| 10 | 227116A2 | 1 | WASHER, THRUST |
| 11 | 227117A2 | 1 | WASHER, THRUST |
| 12 | 92718C2 | 4 | WASHER |
| 13 | 92906C1 | 2 | SHAFT, SHORT |
| 14 | 92907C1 | 1 | SHAFT |
| 15 | 1997421C1 | 2 | BOLT |
| 19 | 1289349C1 | 1 | SPACER |
| 20 | 1289350C1 | 2 | SPACER |
| 21 | 1270697C1 | 112 | NEEDLE, 28 Per Gear |
| 22 | 1289348C1 | 4 | RING |
| 23 | 622336C1 | 1 | BEARING, CONE |
| 25 | A63171 | 1 | BEARING, CUP |
| 29 | 229593A1 | 1 | COVER, , Transmission Number BSN AJB368081 |
| 29 | 87536471 | 1 | COVER, , Transmission Number ASN AJB368081 |
| 30 | 896-11016 | 12 | WASHER, M17.5 x 30 x 4, HT |
| 31 | 828-16055 | 12 | BOLT, Hex, M16 x 55, 10.9, Full Thd |
| 32 | 67250C1 | 1 | BEARING, BALL |
| 33 | 67251C1 | 1 | BEARING, CUP |
| 34 | 120503C2 | 1 | RETAINER |
| 35 | 136433A1 | 5 | DOWEL, 12 x 65 mm |
| 36 | 139059C1 | 1 | SEAL |
| 40 | 139060C2 | 1 | RING |
| 41 | 1997369C2 | 1 | RETAINER |
| 43 | 136433A1 | 5 | DOWEL, 12 x 65 mm |
| 44 | 139059C1 | 1 | SEAL |
| 45 | 139060C2 | 1 | RING |
| 46 | 613-16040 | 3 | BOLT, Hex, M16 x 40, 8.8, Full Thd |
| 46 | 613-16045 | 3 | BOLT, Hex, M16 x 45, 8.8, Full Thd |
| 50 | 1997422C1 | 1 | PISTON |
| 55 | 120679C1 | 3 | PLATE, Friction, Differential lock, Transmission Number BSN AJB368081 |
| 55 | 120679C1 | 3 | PLATE, Friction, Differential lock, Transmission Number ASN AJB368081 |
| 56 | 92915C1 | 4 | PLATE, Separator, Differential Lock, Transmission Number BSN AJB368081 |
| 56 | 87452270 | 4 | PLATE, Separator, Differential Lock, Transmission Number ASN AJB368081 |
| 57 | 409738A1 | 1 | TUBE |
| 58 | 238-5115 | 1 | O-RING, -115, 70 Duro, .674″ ID x .103″ Thk |
| 59 | 94668C1 | 1 | PLATE, Plates, Differential lock, Includes 55 (3) and 56 (4), Transmission Number BSN AJB368081 |
| 59 | 87326162 | 1 | KIT, Plates, Differential lock, Includes 55 (3) and 56 (4), Transmission Number ASN AJB368081 |
06-19 RANGE TRANSMISSION – MFD CLUTCH , PARK AND EMERGENCY BRAKE
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 630694C1 | 2 | BEARING, CONE |
| 2 | 630695C1 | 2 | BEARING, CUP |
| 3 | 101-21412 | 2 | RING, SNAP, #412, 4.430″, Int |
| 4 | 87455297 | 1 | GEAR |
| 6 | 1277309C1 | 1 | WASHER |
| 7 | 1997891C1 | 1 | RING, SNAP |
| 8 | 87347811 | 1 | CIRCLIP |
| 9 | 87329141 | 1 | PLATE, BACKING |
| 10 | 87449793 | 6 | SEPARATOR, Plate |
| 11 | 87348160 | 6 | PLATE, Friction, Magnum 225, Magnum 250, Magnum 280 and Magnum 310 |
| 11 | 87378802 | 6 | PLATE, BRAKE, Friction, Magnum 335 |
| 12 | 101-11225 | 1 | RING, SNAP, #225, Ext |
| 13 | 87552528 | 1 | HUB |
| 14 | 87433971 | 1 | SEAL |
| 15 | 87037455 | 1 | O-RING, -160, Cl 7, 5.237″ ID x .103″ Thk |
| 16 | 87433970 | 1 | SEAL |
| 17 | 238-7151 | 1 | O-RING, -151, Cl 7, 2.987″ ID x .103″ Thk |
| 18 | 87337887 | 1 | PISTON |
| 19 | 87305967 | 5 | SPRING, BELLEVILLE |
| 21 | 87434027 | 1 | CIRCLIP |
| 22 | 87347811 | 1 | CIRCLIP |
| 23 | 87329141 | 1 | PLATE, BACKING |
| 24 | 87347832 | 1 | HUB, , Magnum 225, Magnum 250, Magnum 280 and Magnum 310 |
| 24 | 87575817 | 1 | HUB, , Magnum 335 |
| 25 | 87433971 | 1 | SEAL |
| 26 | 87037455 | 1 | O-RING, -160, Cl 7, 5.237″ ID x .103″ Thk |
| 27 | 87378802 | 8 | PLATE, BRAKE, Friction, Magnum 335 |
| 28 | 87449793 | 8 | SEPARATOR, Plate, Magnum 335 |
| 29 | 87433970 | 1 | SEAL |
| 30 | 238-7151 | 1 | O-RING, -151, Cl 7, 2.987″ ID x .103″ Thk |
| 31 | 87337887 | 1 | PISTON |
| 32 | 87305967 | 5 | SPRING, BELLEVILLE |
| 34 | 87310984 | 2 | RING, SNAP |
| 35 | 87434027 | 1 | CIRCLIP |
| 36 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 37 | 700-332 | 1 | ELBOW, 90є, 13/16″-18 ORFS x M14 x 1.5 ORB, Inc. 36, 38 |
| 38 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 39 | 87307978 | 1 | TUBE |
| 40 | 515-23127 | 1 | CLAMP, 1/2″, Insul, 3/8″ Bolt |
| 41 | 614-10020 | 1 | BOLT, Hex, M10 x 20, 8.8, Full Thd |
| 42 | 87331111 | 4 | SCREW, M8 x 16; 8.8 |
| 43 | 87337873 | 1 | SHIELD, Upper Half |
| 44 | 87332637 | 6 | CLIP |
| 45 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 46 | 201-102 | 2 | CONNECTOR, HYD., 13/16″-16 ORFS x 3/4″-16 ORB, Inc. 45, 47 |
| 47 | 237-6008 | 1 | O-RING, 8-1, 90 Duro, .644″ ID x .087″ Thk |
| 48 | 238-5013 | 4 | O-RING, -013, 70 Duro, .426″ ID x .070″ Thk |
| 49 | 87425392 | 1 | TUBE |
| 50 | 445336A1 | 3 | SEALRING |
| 51 | 87536356 | 1 | BRAKE ASSY., Inc. 58 |
| 52 | 87337875 | 1 | SHIELD, Lower Half |
| 53 | 87343231 | 1 | SHIELD, Constant Mesh Gear |
| 54 | 87348536 | 1 | SCREW |
| 55 | 120514C2 | 1 | TUBE |
| 56 | 124306A1 | 1 | PIPE |
| 57 | 828-12050 | 6 | BOLT, Hex, M12 x 50, 10.9 |
| 58 | 837-10025 | 1 | DOWEL, M10 x 25 |
| 59 | 628-10030 | 4 | BOLT, Hex, M10 x 30, 10.9, Full Thd |
| 60 | 87327182 | 1 | COVER, , See Figure 07-08 |
06-20 MFD AXLE – DRIVE SHAFT
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 258853A2 | 1 | SHAFT, DRIVE, Inc. 2, 3, Magnum 225, Magnum 250, Magnum 280 and Magnum 310 |
| 1 | 87643648 | 1 | Inc. 2, 3, Magnum 335 |
| 2 | 258854A2 | 2 | JOINT, UNIVERSAL, , Magnum 225, Magnum 250, Magnum 280 and Magnum 310 |
| 2 | 259076A2 | 2 | SPIDER, U-JOINT, , Magnum 335 |
| 3 | 828-10045 | 8 | BOLT, Hex, M10 x 45, 10.9 |
| 4 | 258855A1 | 1 | YOKE, , Magnum 225, Magnum 250, Magnum 280 and Magnum 310 |
| 4 | 87663540 | 1 | YOKE, , Magnum 335 |
| 5 | 828-10045 | 8 | BOLT, Hex, M10 x 45, 10.9 |
| 8 | 441554A2 | 1 | SHIELD, Standard Axle, Inc. 9, 10, Magnum 225, Magnum 250, Magnum 280 and Magnum 310 |
| 8 | 87720204 | 1 | SHIELD, Standard Axle, Inc. 9, 10, Magnum 335 |
| 11 | 93199C1 | 2 | FASTENER |
| 13 | 199922A2 | 1 | CAGE |
| 17 | 199923A1 | 1 | SPACER |
| 18 | 235519A1 | 2 | BEARING, CONE |
| 19 | 235521A1 | 2 | BEARING SET, 2-57/64 OD |
| 20 | 199981A1 | 1 | RING, SNAP |
| 23 | 222732A1 | 1 | RING, SNAP |
| 24 | 226851A1 | 1 | SEAL, OIL |
| 25 | 628-20060 | 2 | BOLT, Hex, M20 x 60, 10.9, Full Thd |
| 26 | 828-20150 | 2 | BOLT, Hex, M20 x 150, 10.9 |
| 27 | 896-12020 | 4 | WASHER, M20 x 37.5 x 4, HT |
| 28 | 87425393 | 1 | SHAFT |
| 30 | 205369R91 | 1 | BEARING, NEEDLE |
| 32 | 238-5043 | 1 | O-RING, -043, 70 Duro, 3.489″ ID x .070″ Thk |
| 35 | 238-5220 | 1 | O-RING, -220, 70 Duro, 1.359″ ID x .139″ Thk |
| 37 | 221943A1 | 1 | WASHER |
| 38 | 628-16050 | 1 | BOLT, Hex, M16 x 50, 10.9, Full Thd |
06-21 TRANSMISSION CONTROL VALVE LOCATION
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 450729A2 | 1 | VALVE, Speed, See Figure 06-22 |
| 2 | 450721A2 | 1 | VALVE, Odd/Even, Without Creep or 19 Speed/Without 50 KPH, See Figure 06-25 |
| 2 | 450726A2 | 1 | VALVE, Odd/Even, With Creep or 19 Speed/With 50 KPH, See Figure 06-26 |
| 3 | 87323842 | 1 | VALVE, MFD, PWM, Range, See Figure 06-27 |
06-22 VALVE ASSEMBLY – TRANSMISSION CONTROL (450729A2)
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | 221576A1 | 4 | PLUG, Hex Soc, M14 x 1.5, ORB, Inc. 3 |
| 3 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 4 | 87440439 | 4 | SOLENOID, Inc. 5 – 7 |
| 5 | 87014033 | 1 | O-RING, -019, Cl 7, .801″ ID x .070″ Thk |
| 6 | 238-7016 | 1 | O-RING, -016, Cl 7, .614″ ID x .070″ Thk |
| 7 | 238-7015 | 1 | O-RING, -015, Cl 7, .551″ ID x .070″ Thk |
| 8 | 86985026 | 1 | COVER |
| 9 | 864-5010 | 6 | SCREW, Hex Soc Hd, M5 x 10, 8.8 |
| 10 | 87399290 | 1 | GASKET |
| 11 | 864-10055 | 4 | SCREW, Hex Soc Hd, M10 x 55, 8.8 |
| 12 | 86987513 | 1 | SENSOR, Inc. 13 |
| 13 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
06-23 VALVE ASSEMBLY – TRANSMISSION CONTROL (450721A2)
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | 221576A1 | 4 | PLUG, Hex Soc, M14 x 1.5, ORB, Inc. 3 |
| 3 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 4 | 86989388 | 2 | SOLENOID, Inc. 5 – 7 |
| 5 | 87014033 | 1 | O-RING, -019, Cl 7, .801″ ID x .070″ Thk |
| 6 | 238-7016 | 1 | O-RING, -016, Cl 7, .614″ ID x .070″ Thk |
| 7 | 238-7015 | 1 | O-RING, -015, Cl 7, .551″ ID x .070″ Thk |
| 8 | 86984122 | 1 | PLUG, Inc. 9 – 11 |
| 9 | 87014033 | 1 | O-RING, -019, Cl 7, .801″ ID x .070″ Thk |
| 10 | 238-7016 | 1 | O-RING, -016, Cl 7, .614″ ID x .070″ Thk |
| 11 | 238-7015 | 1 | O-RING, -015, Cl 7, .551″ ID x .070″ Thk |
| 15 | 237-6010 | 1 | O-RING, 10-1, 90 Duro, .755″ ID x .097″ Thk |
| 16 | 238-5015 | 1 | O-RING, -015, 70 Duro, .551″ ID x .070″ Thk |
| 17 | 238-5014 | 1 | O-RING, -014, 70 Duro, .489″ ID x .070″ Thk |
| 19 | 86985027 | 1 | COVER |
| 20 | 864-5010 | 4 | SCREW, Hex Soc Hd, M5 x 10, 8.8 |
| 21 | 87399290 | 1 | GASKET |
| 22 | 864-10055 | 4 | SCREW, Hex Soc Hd, M10 x 55, 8.8 |
06-24 VALVE ASSEMBLY – TRANSMISSION CONTROL (450726A2)
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | 221576A1 | 4 | PLUG, Hex Soc, M14 x 1.5, ORB, Inc. 3 |
| 3 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 4 | 86989388 | 3 | SOLENOID, Inc. 5 – 7 |
| 5 | 87014033 | 1 | O-RING, -019, Cl 7, .801″ ID x .070″ Thk |
| 6 | 238-7016 | 1 | O-RING, -016, Cl 7, .614″ ID x .070″ Thk |
| 7 | 238-7015 | 1 | O-RING, -015, Cl 7, .551″ ID x .070″ Thk |
| 11 | 237-6010 | 1 | O-RING, 10-1, 90 Duro, .755″ ID x .097″ Thk |
| 12 | 238-5015 | 1 | O-RING, -015, 70 Duro, .551″ ID x .070″ Thk |
| 13 | 238-5014 | 1 | O-RING, -014, 70 Duro, .489″ ID x .070″ Thk |
| 15 | 86985027 | 1 | COVER |
| 16 | 864-5010 | 4 | SCREW, Hex Soc Hd, M5 x 10, 8.8 |
| 17 | 87399290 | 1 | GASKET |
| 18 | 864-10055 | 4 | SCREW, Hex Soc Hd, M10 x 55, 8.8 |
06-25 VALVE ASSEMBLY – TRANSMISSION CONTROL (87323842)
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 3 | 221576A1 | 5 | PLUG, Hex Soc, M14 x 1.5, ORB, Inc. 4 |
| 4 | 14437785 | 1 | O-RING, 11.3MM ID x 2.4 Thk |
| 5 | 315168A1 | 1 | PLUG |
| 7 | 221578A1 | 1 | PLUG, Hex Soc, M18 x 1.5, ORB, Inc. 8 |
| 8 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 10 | 87440439 | 4 | SOLENOID, Inc. 11 – 13 |
| 11 | 87014033 | 1 | O-RING, -019, Cl 7, .801″ ID x .070″ Thk |
| 12 | 238-7016 | 1 | O-RING, -016, Cl 7, .614″ ID x .070″ Thk |
| 13 | 238-7015 | 1 | O-RING, -015, Cl 7, .551″ ID x .070″ Thk |
| 14 | 86985026 | 1 | COVER |
| 15 | 864-5010 | 6 | SCREW, Hex Soc Hd, M5 x 10, 8.8 |
| 16 | 87399290 | 1 | GASKET |
| 17 | 864-10055 | 4 | SCREW, Hex Soc Hd, M10 x 55, 8.8 |
06-26 PEDAL – INCHING
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 416255A3 | 1 | PEDAL ASSY., Inc. 2 – 4 |
| 2 | 1999382C1 | 1 | PAD, RUBBER |
| 4 | 1990753C1 | 2 | PLASTIC RING |
| 5 | 800-3120 | 1 | CIRCLIP, M20 |
| 6 | 895-11018 | 1 | WASHER, M18 x 34 x 3 |
| 7 | 87567150 | 1 | ROD, Clutch Pot Link |
| 9 | 303754A1 | 1 | SPRING |
| 10 | 302275A2 | 1 | LEVER |
| 11 | 840-1550 | 4 | SCREW, Cross Pan Hd, M5 x 50 |
| 12 | 800-4311 | 1 | CIRCLIP, M11 |
| 13 | 295013A2 | 1 | PIN |
| 14 | 301271A1 | 1 | SENSOR, Position |
| 15 | 414144A1 | 1 | SWITCH, Bottom Of Clutch |
| 16 | 832-10405 | 4 | NUT, LOCK, M5 x .8, Cl 8 |
| 17 | 495-21044 | 1 | WASHER, 3/8″ |
| 18 | 295012A2 | 1 | BUSHING |
| 19 | 3226538R1 | 1 | CLIP |
| 20 | 258242A1 | 1 | WASHER |
06-27 LEVER ASSEMBLY – TRANSMISSION CONTROL
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 325064A1 | 1 | HOUSING, Upper |
| 2 | 325065A1 | 1 | HOUSING, Lower |
| 3 | 325362A1 | 1 | CHASSIS |
| 4 | 325363A1 | 1 | LEVER, Transmission Control |
| 5 | 250939A1 | 1 | SPRING |
| 6 | 284777A1 | 1 | SWITCH, Turn Signal, Horn, High Beam |
| 7 | 447256A2 | 1 | SWITCH, Transmission Control |
| 8 | 375681A1 | 1 | HARNESS, Transmission Control And Turn Signal Self-Cancelling Sensor (Sensor Not Serviced |
| 9 | 303465A2 | 1 | LAMP |
| 10 | 325533A1 | 1 | HANDLE |
| 11 | 325066A2 | 1 | GUARD |
| 12 | 303466A1 | 1 | SYMBOLS, Right-Hand |
| 13 | 303467A1 | 1 | SYMBOLS, Left-Hand |
| 14 | 325068A1 | 1 | BELLOWS |
| 15 | 358353A1 | 1 | SYMBOLS |
| 16 | 840-1410 | 7 | SCREW, Cross Pan Hd, M4 x 10 |
| 17 | 892-11004 | 7 | WASHER, LOCK, M4 |
| 18 | 905974R1 | 2 | SCREW, SELF TAP, Pan Hd, M2.9 x 13 |
| 19 | 253679A1 | 1 | RING, Magnet |
| 20 | 86993721 | 1 | CONTROL, Inc. 1 -18 |
06-28 REAR AXLE – HOUSING
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87713053 | 1 | HOUSING ASSY., Inc. 2 – 12 |
| 2 | 837-16035 | 1 | DOWEL, M16 x 35 |
| 3 | 837-10020 | 2 | DOWEL, M10 x 20 |
| 4 | 837-16040 | 4 | DOWEL, M16 x 40 |
| 5 | 37-11232 | 2 | DOWEL, 3/4″ x 2″ |
| 8 | 192791A1 | 2 | PLUG, 1/2″ |
| 9 | 192792A1 | 1 | PLUG, 3/4″ |
| 10 | 411075A1 | 1 | FITTING |
| 11 | 238-6111 | 1 | O-RING, -111, 90 Duro, .424″ ID x .103″ Thk |
| 12 | 238-6112 | 1 | O-RING, -112, 90 Duro, .487″ ID x .103″ Thk |
| 13 | 409741A1 | 1 | TUBE ASSY. |
| 20 | 87371409 | 1 | COVER, Rear Frame |
| 21 | 413900A1 | 1 | GASKET |
| 22 | 828-12050 | 15 | BOLT, Hex, M12 x 50, 10.9 |
| 23 | 863-12150 | 4 | SCREW, Hex Soc Hd, M12 x 150, 12.9 |
| 24 | 414320A1 | 1 | FITTING |
| 25 | 87696450 | 1 | PLATE |
| 26 | 238-6139 | 2 | O-RING, -139, 90 Duro, 2.175″ ID x .103″ Thk |
| 27 | 628-10035 | 4 | BOLT, Hex, M10 x 35, 10.9, Full Thd |
| 28 | 221576A1 | 1 | PLUG, Hex Soc, M14 x 1.5, ORB, Inc. 29 |
| 29 | 14437785 | 1 | O-RING, 11.3MM ID x 2.4 Thk |
| 30 | 220066A1 | 1 | PLUG, M18 x 1.5, ORB, Inc. 31 |
| 31 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 35 | 236602A1 | 1 | COVER, , Without Hitch |
| 36 | 379145A1 | 1 | GASKET |
| 37 | 628-20045 | 6 | BOLT, Hex, M20 x 45, 10.9, Full Thd |
| 38 | 628-12025 | 4 | BOLT, Hex, M12 x 25, 10.9, Full Thd |
| 39 | 352787A2 | 1 | SENSOR, Axle Speed, Transmission BSN AJB0372635 |
| 39 | 87548200 | 1 | SENSOR, PTO and Transmission Speed, Transmission ASN AJB0372635 |
| 40 | 238-5115 | 1 | O-RING, -115, 70 Duro, .674″ ID x .103″ Thk |
| 41 | 238-5111 | 1 | O-RING, -111, 70 Duro, .424″ ID x .103″ Thk |
| 42 | 239-5112 | 1 | O-RING, Rect, .5″ ID x .688″ OD, Cl 5 |
| 43 | 613-12025 | 2 | BOLT, Hex, M12 x 25, 8.8, Full Thd |
| 44 | 892-11012 | 2 | WASHER, LOCK, M12 |
| 46 | 87631267 | 1 | HARNESS, WIRE, PTO Sensor, Transmission ASN AJB0372635 |
06-31 REAR AXLE – PLANETARY, MAGNUM 310
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 360761A1 | 2 | GEAR, RING |
| 2 | 388370A1 | 2 | CARRIER, GEARS |
| 3 | 310694A2 | 8 | GEAR, PLANETARY |
| 4 | 310697A3 | 8 | SHAFT |
| 5 | 1349347C1 | 528 | BEARING, NEEDLE |
| 6 | 86985634 | 8 | SPACER, RING, Nylon |
| 7 | 87435907 | 16 | WASHER |
| 8 | 838-3826 | 8 | PIN, M8 x 26, Coiled |
| 9 | 101-11350 | 2 | RING, SNAP, #350, Ext |
| 10 | 395481A1 | 1 | SHAFT, GEAR, 16T, Left Hand |
| 11 | 395481A1 | 1 | SHAFT, GEAR, 16T, Right Hand |
| 12 | 1981327C1 | 1 | PLUG, Sun Shaft Locator, Right Hand Only |
| 13 | 1259732C1 | 2 | HUB |
| 14 | 101-11275 | 2 | RING, SNAP, #275, 2.594, Ext |
| 15 | 1259753C1 | 2 | WASHER |
06-33 REAR AXLE – 4 X 98 INCH, MAGNUM 280, 310, AND 335
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87456257 | 2 | CARRIER, Inc. 2 – 4 |
| 2 | 837-16040 | 2 | DOWEL, M16 x 40 |
| 3 | 1975500C1 | 1 | BEARING, CUP |
| 4 | 619697C1 | 1 | BEARING, CUP |
| 5 | 828-16150 | 36 | BOLT, Hex, M16 x 150, 10.9 |
| 7 | 118654A3 | 2 | AXLE, Inc. 8, 9 |
| 8 | 1963837C1 | 1 | BUSHING |
| 9 | 1981270C1 | 1 | INSERT |
| 10 | 238-5155 | 2 | O-RING, -155, 70 Duro, 3.987″ ID x .103″ Thk |
| 11 | 1975499C1 | 2 | BEARING, CONE |
| 12 | 1963841C1 | 2 | BEARING, CONE |
| 14 | 124744C1 | 2 | RING |
| 15 | 1277020C2 | 2 | RING |
| 16 | 1963839C1 | 2 | SEAL |
| 20 | 1349182C1 | 2 | KIT, GASKET, Inc. 21, 22 |
| 21 | 1349183C1 | 1 | SEAL, OIL, Oversize |
| 22 | 1349184C1 | 1 | SLEEVE |
| 23 | 896-12016 | 36 | WASHER, M17.5 x 30 x 4, HT |
06-34 TRANSMISSION – PUMP DRIVE
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 389550A1 | 1 | HOUSING |
| 3 | 613-10035 | 8 | BOLT, Hex, M10 x 35, 8.8, Full Thd |
| 5 | 220199A1 | 1 | GEAR |
| 8 | 472163R1 | 2 | RING |
| 9 | 394326A1 | 2 | BEARING, BALL |
| 10 | 93316C1 | 1 | SPACER |
| 11 | 1286151C1 | 1 | SHAFT |
| 12 | 813-10130 | 1 | BOLT, Hex, M10 x 130, 8.8 |
| 13 | 896-12010 | 1 | WASHER, M10 x 21.5 x 2.5, HT |
| 14 | 404173A2 | 1 | GEAR, DRIVEN |
| 18 | 399933C91 | 2 | BEARING, CONE |
| 19 | 399934C1 | 2 | BEARING, CUP |
| 20 | 405664A2 | 1 | CAGE |
| 21 | 238-5257 | 1 | O-RING, -257, 70 Duro, 5.859″ ID x .139″ Thk |
| 23 | 613-10035 | 4 | BOLT, Hex, M10 x 35, 8.8, Full Thd |
| 30 | 220560A1 | 1 | PINION |
| 31 | 238-5223 | 1 | O-RING, -223, 70 Duro, 1.609″ ID x .139″ Thk |
| 32 | 1286023C1 | 1 | RING |
| 33 | 100-11237 | 1 | RING, SNAP, #237, Ext |
| 34 | ST269A | 1 | BEARING, BALL |
| 35 | 101-21433 | 1 | RING, SNAP, #433, 4.641″, Int |
06-35 POWER TAKE OFF ASSEMBLY – INPUT SHAFT
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 198496A1 | 1 | COUNTERSHAFT |
| 4 | 87696447 | 1 | SHAFT, Inc. 5, 6, 52 |
| 6 | 877-31212 | 1 | SET SCREW, Hex Soc, M12 x 12, Flat Pt |
| 7 | 1286026C1 | 3 | RING, Seal |
| 8 | 93350C1 | 5 | RING, Retaining |
| 9 | 1286012C2 | 7 | WASHER, Belleville, Transmission BSN AJB0365565 |
| 9 | 87425389 | 7 | SPRING, BELLEVILLE, , Transmission ASN AJB0365565 |
| 10 | 446596A4 | 1 | CARRIER |
| 11 | 572182R1 | 2 | BEARING, THRUST |
| 12 | 435716A1 | 2 | BEARING, NEEDLE |
| 13 | 1286043C1 | 4 | WASHER, THRUST |
| 14 | 86989332 | 1 | RING, Needle Bearing Support |
| 15 | 435636A1 | 1 | SPRING, Brake Apply Disc, Transmission BSN AJB0365565 |
| 15 | 435636A1 | 2 | SPRING, Brake Apply Disc, Transmission ASN AJB0365565 |
| 16 | 445794A2 | 1 | GEAR, DRIVING, 61T, Transmission BSN AJB0365565 |
| 16 | 87696444 | 1 | GEAR, 61T, Transmission ASN AJB0365565 |
| 17 | 101-11400 | 1 | RING, SNAP, #400, 3.771, Ext, No. 400 |
| 21 | 1286083C1 | 1 | O-RING |
| 22 | 1286079C1 | 1 | RING |
| 23 | 446597A2 | 1 | PISTON |
| 24 | 1286081C1 | 1 | O-RING |
| 25 | 1286076C1 | 1 | RING |
| 28 | 1277309C1 | 1 | WASHER |
| 29 | 87696449 | 1 | CAGE |
| 30 | 628-10030 | 4 | BOLT, Hex, M10 x 30, 10.9, Full Thd |
| 31 | 413665A1 | 2 | TUBE |
| 32 | 238-5013 | 4 | O-RING, -013, 70 Duro, .426″ ID x .070″ Thk |
| 33 | 630694C1 | 1 | BEARING, CONE |
| 34 | 630695C1 | 1 | BEARING, CUP |
| 35 | 659458R1 | 1 | BEARING, CONE |
| 36 | 105497H | 1 | BEARING, CUP |
| 37 | 435718A3 | 3 | ADJUSTER, Pin, Brake, Transmission BSN AJB0365565 |
| 37 | 87367860 | 3 | ADJUSTER, Pin, Brake, Transmission ASN AJB0365565 |
| 38 | 87427330 | 3 | SCREW, M6 x 50, with Loctite, Transmission BSN AJB0365565 |
| 40 | 446943A1 | 1 | SHIM, Kit, Inc. 40 |
| 40 | 249776A1 | 2 | SHIM, 0.203 mm |
| 40 | 249777A1 | 2 | SHIM, 0.356 mm |
| 40 | 249778A1 | 2 | SHIM, 0.508 mm |
| 40 | 249779A1 | 2 | SHIM, 0.559 mm |
| 40 | 249780A1 | 2 | SHIM, 0.635 mm |
| 41 | 87427329 | 1 | SPACER |
| 42 | 375374R1 | 1 | RING |
| 43 | 435892A2 | 1 | BRAKE DISC |
| 44 | 435393A2 | 2 | PLATE |
| 45 | 128114A1 | 7 | DISC, , Transmission BSN AJB0365565 |
| 45 | 128114A1 | 8 | DISC, , Transmission ASN AJB0365565 |
| 46 | 1997907C1 | 8 | PLATE, Friction |
| 47 | 435389A1 | 1 | DISC, , Transmission BSN AJB0365565 |
| 48 | 1285996C1 | 1 | RING, SNAP |
| 49 | 1342645C3 | 1 | DISC, CLUTCH |
| 50 | 86989330 | 1 | TUBE, Brake Pusher, Transmission BSN AJB0365565 |
| 51 | 86989331 | 1 | BRAKE DISC, Pusher, Transmission BSN AJB0365565 |
| 51 | 87366290 | 1 | BRAKE DISC, Pusher, Transmission ASN AJB0365565, Use Either 87366284 or 87366290 |
| 51 | 87366284 | 1 | BRAKE DISC, , Use Either 87366284 or 87366290 |
| 53 | 87690675 | 1 | RING |
06-36 POWER TAKE OFF ASSEMBLY – REDUCTION GEAR, DUAL SPEED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 225806A1 | 1 | CAGE |
| 2 | 628-10030 | 6 | BOLT, Hex, M10 x 30, 10.9, Full Thd |
| 3 | 277389A2 | 1 | HUB ASSY., Inc. 4 |
| 4 | 359950R91 | 1 | BEARING, NEEDLE |
| 5 | 25695HO | 1 | BEARING, CONE |
| 6 | 22396V | 2 | BEARING SET |
| 7 | 235545A1 | 1 | BEARING, CONE |
| 8 | 253456A1 | 1 | SHIM, Inc. 8 |
| 9 | 231772A1 | 1 | SPACER |
| 10 | 231760A1 | 1 | RING, SNAP |
| 13 | 408252A1 | 1 | GEAR, RING |
| 14 | 628-10030 | 6 | BOLT, Hex, M10 x 30, 10.9, Full Thd |
| 15 | 198709A1 | 1 | PROTECTION PLATE |
| 16 | 225810A1 | 1 | COVER |
| 17 | 139327C1 | 4 | CLIP |
| 20 | 226037A4 | 1 | COVER |
| 21 | 828-12045 | 4 | BOLT, Hex, M12 x 45, 10.9, Full Thd, , BSN Z7RW05000 |
| 21 | 87015540 | 4 | BOLT, Hex, M12 x 50, 10.9, , ASN Z7RW05000 |
| 22 | 226035A1 | 2 | WASHER |
| 23 | 226033A3 | 1 | PINION |
| 24 | 300084A1 | 1 | SPACER |
| 25 | 138763C91 | 2 | BEARING, NEEDLE |
| 26 | 226034A2 | 1 | SHAFT |
| 27 | 38-21240 | 1 | PIN, 3/16″ x 2 1/2″, Coiled |
| 30 | 324000A1 | 1 | SHAFT, GEAR |
| 31 | A67328 | 1 | BEARING, CONE |
| 32 | A67327 | 1 | BEARING, CUP |
| 33 | 226024A3 | 1 | WASHER, THRUST |
| 34 | 326733A1 | 1 | PINION |
| 35 | 318641A1 | 1 | BEARING, NEEDLE |
| 36 | 226028A2 | 1 | PISTON |
| 37 | 226029A1 | 1 | RING |
| 38 | 38-32044 | 1 | PIN, 5/16″ x 2 3/4″, Coiled |
| 39 | 226031A2 | 1 | COLLAR |
| 40 | 330162A1 | 2 | BEARING, NEEDLE |
| 41 | 326731A1 | 1 | GEAR |
| 45 | 323066A1 | 1 | SPRING |
| 46 | 295066A1 | 1 | WASHER |
| 47 | 100-21112 | 1 | RING, SNAP, 1.125″, Int, #112 |
| 48 | 327172A1 | 1 | SPACER |
| 49 | 243544A1 | 1 | BEARING, NEEDLE |
| 50 | 327372A1 | 2 | WASHER |
| 55 | 87656553 | 1 | HOUSING, BEARING |
| 56 | 828-12080 | 2 | BOLT, Hex, M12 x 80, 10.9, , BSN Z7RW05000 |
| 56 | 86979023 | 6 | BOLT, Hex, M12 x 85, 10.9, , ASN Z7RW05000 |
| 57 | 828-12045 | 2 | BOLT, Hex, M12 x 45, 10.9, Full Thd, , BSN Z7RW05000 |
| 57 | 87015540 | 2 | BOLT, Hex, M12 x 50, 10.9, , ASN Z7RW05000 |
| 58 | 253460A1 | 1 | SHIM, Inc. 58 |
| 59 | 638-54145 | 1 | O-RING, Cl 5, 145MM ID x 3.55 Thk |
| 60 | 293053A1 | 1 | SEAL, OIL |
| 61 | 87548197 | 1 | SENSOR, Dual Speed PTO, Replaces A186004, Also Order 87651813 For Initial Replacement |
| 62 | 238-5115 | 1 | O-RING, -115, 70 Duro, .674″ ID x .103″ Thk |
| 63 | 102-22318 | 1 | RING, SNAP, #318, 3.311, Int, Spiral, No. 318 |
| 64 | 614-10040 | 4 | BOLT, Hex, M10 x 40, 8.8, Full Thd |
06-38 POWER TAKE OFF ASSEMBLY – OUTPUT SHAFT, DUAL SPEED, MAGNUM 280, 310, AND 335
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 226045A2 | 1 | SHAFT, DRIVE, RPM 540, 35 mm (1-3/8″), BSN Z7RW05000 |
| 1 | 87567419 | 1 | SHAFT, DRIVE, RPM 540, 35 mm (1-3/8″), ASN Z7RW05000 |
| 2 | 226042A2 | 1 | SHAFT, DRIVE, RPM 1000, 35 mm (1-3/8″), BSN Z7RW05000 |
| 2 | 87567418 | 1 | SHAFT, DRIVE, RPM 1000, 35 mm (1-3/8″), ASN Z7RW05000 |
| 3 | 341418A2 | 1 | SEAL |
| 4 | 241387A5 | 1 | HOUSING |
| 5 | 614-10040 | 4 | BOLT, Hex, M10 x 40, 8.8, Full Thd |
| 6 | 258531A2 | 1 | BOX |
| 10 | 226040A2 | 1 | SHAFT, DRIVE, RPM 1000, 45 mm (1-3/4″) |
| 11 | 341418A2 | 1 | SEAL |
| 12 | 241385A3 | 1 | PLATE, Inner |
| 13 | 241386A2 | 1 | PLATE, Outer, BSN Z7RW05000 |
| 13 | 87566168 | 1 | Outer, ASN Z7RW05000 |
| 14 | 628-10020 | 3 | BOLT, Hex, M10 x 20, 10.9, Full Thd |
| 20 | A151928 | 1 | SHAFT, DRIVE, RPM 1000 |
| 21 | 413-844 | 2 | BOLT, Hex, 1/2″-13 x 2 3/4″, G5 |
| 22 | 131-510 | 2 | NUT, LOCK, 1/2″-13 |
| 23 | A30061 | 2 | WASHER |
06-39 POWER TAKE OFF ASSEMBLY – OUTPUT SHAFT, SINGLE SPEED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 444803A2 | 1 | CAGE |
| 2 | 628-10030 | 6 | BOLT, Hex, M10 x 30, 10.9, Full Thd |
| 3 | 444800A2 | 1 | GEAR, DRIVEN, 121T |
| 6 | 895-11010 | 6 | WASHER, M10 x 20 x 2 |
| 10 | 445991A1 | 1 | KIT, SHIM, Inc. 10 |
| 15 | 446759A1 | 1 | SHIELD |
| 16 | 225810A1 | 1 | COVER |
| 17 | 139327C1 | 4 | CLIP |
| 20 | 444798A2 | 1 | SHAFT, 45 mm (1-3/4″) |
| 21 | 444801A1 | 1 | COVER |
| 22 | 446268A1 | 2 | BEARING, CONE |
| 23 | 446269A1 | 2 | BEARING, CUP |
| 30 | 225820A1 | 1 | SEAL, OIL |
| 32 | 828-12045 | 8 | BOLT, Hex, M12 x 45, 10.9, Full Thd, , BSN Z7RW05000 |
| 32 | 87015540 | 8 | BOLT, Hex, M12 x 50, 10.9, , ASN Z7RW05000 |
| 33 | 128209A1 | 2 | PLUG, (Not Shown) |
06-40 POWER TAKE OFF ASSEMBLY – SHIELDS
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 11 | 275108A5 | 1 | PROTECTION PLATE |
| 12 | 275257A4 | 1 | PLATE ASSY., Left Hand |
| 13 | 275258A4 | 1 | PLATE ASSY., Right Hand |
| 14 | 377751A2 | 1 | PROTECTION PLATE |
| 15 | 179657A2 | 1 | SPRING |
| 16 | 225672A2 | 1 | ROD |
| 17 | 495-21069 | 4 | WASHER, 5/8″ |
| 18 | 733-5040 | 2 | PIN, SPLIT (COTTER), M5 x 40 |
| 19 | 814-12050 | 4 | BOLT, Hex, M12 x 50, 8.8 |
| 21 | 614-6016 | 4 | BOLT, Hex, M6 x 16, 8.8 |
| 24 | 311112A4 | 1 | GUARD, Single Speed, Inc. 25 – 27 |
| 26 | 1968039C3 | 2 | FASTENER |
| 27 | 280-5348 | 4 | SCREW, SELF TAP, Hex Wash Hd, #8 x 1/2″ |
| 29 | 311113A4 | 1 | GUARD, Dual Speed, Inc. 30 – 32 |
| 31 | 1968039C3 | 2 | FASTENER |
| 32 | 280-5348 | 4 | SCREW, SELF TAP, Hex Wash Hd, #8 x 1/2″ |
| 35 | 308308A1 | 2 | SUPPORT |
| 36 | 1977929C1 | 2 | STUD |
| 37 | 828-12050 | 4 | BOLT, Hex, M12 x 50, 10.9 |
| 38 | 828-12085 | 4 | BOLT, Hex, M12 x 85, 10.9 |
| 39 | 896-12012 | 4 | WASHER, M12 x 24.5 x 3, HT |
| 42 | 101588A2 | 2 | BRACKET |
| 43 | 614-6016 | 4 | BOLT, Hex, M6 x 16, 8.8 |
| 44 | 895-11006 | 4 | WASHER, M6 |
| 45 | 107484C1 | 2 | REFLECTOR |
06-41 SOLID STEEL REAR WHEELS
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 336726A1 | 2 | RIM, MW23Ax38, For Tires 650/85R38, 710/70R38 |
| 1 | 336725A1 | 2 | RIM, MW20Ax42, For Tires 620/70R42 |
| 1 | 336728A1 | 2 | RIM, MW23Ax42, For Tires 710/70R42 |
| 1 | 87439427 | 2 | WHEEL, MW25Ax38, For Tires 800/70R38 |
| 1 | 87439429 | 2 | WHEEL, MW28Ax42, For Tires 900/50R42 |
| 2 | 827-22080 | 20 | BOLT, Hex, M22 x 80, 10.9, Full Thd |
| 3 | 496-31094 | 20 | WASHER, 15/16″ x 1 3/4″ x .219″, HDN |
| 4 | 86507333 | 2 | VALVE STEM |
06-42 HUB ASSEMBLY – REAR WHEEL
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 800-11115 | 2 | RING, SNAP, M115, Ext |
| 1 | 800-51100 | 2 | RING, SNAP, M100, Ext, Hvy |
| 6 | 405812A1 | 2 | HUB |
| 7 | 405815A1 | 2 | BUSHING, 102 mm (4″) |
| 8 | 228273A1 | 12 | BOLT, M20 x 110; 10,9 |
| 9 | 396-31081 | 12 | WASHER, 13/16″ x 1 1/2″ x .219″, HDN |
| 10 | A63219 | 2 | KEY, 3/4 x 6 |
| 11 | 38-11608 | 2 | PIN, LOCK, 1/4″ x 1/2″, Slotted |
| 12 | 303401A1 | 6 | PLUG |
| 15 | 827-22080 | 20 | BOLT, Hex, M22 x 80, 10.9, Full Thd |
| 16 | 896-11022 | 20 | WASHER, M22 x 44 x 4, HT |
| 17 | 405812A1 | 2 | HUB |
| 18 | 405816A1 | 2 | BUSHING, 115 mm (4-1/2″) |
| 19 | 228273A1 | 12 | BOLT, M20 x 110; 10,9 |
| 20 | 396-31081 | 12 | WASHER, 13/16″ x 1 1/2″ x .219″, HDN |
| 21 | A63219 | 2 | KEY, 3/4 x 6 |
| 22 | 38-11608 | 2 | PIN, LOCK, 1/4″ x 1/2″, Slotted |
| 23 | 303401A1 | 6 | PLUG |
06-43 SPACER – DUAL REAR WHEELS
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 405822A1 | 2 | SPACER, 127 mm (5″) |
| 2 | 827-22160 | 20 | BOLT, Hex, M22 x 150, 10.9 |
| 3 | 896-11022 | 20 | WASHER, M22 x 44 x 4, HT |
| 5 | 405823A1 | 2 | SPACER, 254 mm (10″) |
| 6 | 827-22130 | 20 | BOLT, Hex, M22 x 130, 10.9 |
| 7 | 896-11022 | 20 | WASHER, M22 x 44 x 4, HT |
| 9 | 405824A1 | 2 | SPACER, 330 mm (13″) |
| 10 | 827-22130 | 20 | BOLT, Hex, M22 x 130, 10.9 |
| 11 | 896-11022 | 20 | WASHER, M22 x 44 x 4, HT |
| 13 | 405825A1 | 2 | SPACER, 381 mm (15″) |
| 14 | 827-22130 | 20 | BOLT, Hex, M22 x 130, 10.9 |
| 15 | 896-11022 | 20 | WASHER, M22 x 44 x 4, HT |
06-44 REAR WHEEL WEIGHTS
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 405828A1 | 2 | WEIGHT, Wheel, 200 lb |
| 2 | 87393412 | 6 | BOLT, M16 x 130; 10.9 |
| 3 | 832-10416 | 6 | NUT, LOCK, M16 x 2, Cl 8 |
| 4 | 896-15016 | 12 | WASHER, M17.5 x 34 x 5, HT |
| 6 | 87310406 | 2 | WEIGHT, WHEEL, 500 lb, Magnum225, Magnum250, Magnum280, and Magnum310 |
| 6 | 87310406 | 4 | WEIGHT, WHEEL, , Magnum 335 |
| 7 | 87393412 | 6 | BOLT, M16 x 130; 10.9, Magnum225, Magnum250, Magnum280, and Magnum310 |
| 7 | 87393412 | 12 | BOLT, , Magnum 335 |
| 8 | 412066 | 6 | NUT, LOCK, M16 x 2, Cl 8, , Magnum225, Magnum250, Magnum280, and Magnum310 |
| 8 | 412066 | 12 | NUT, LOCK, M16 x 2, Cl 8, , Magnum 335 |
| 9 | 896-15016 | 12 | WASHER, M17.5 x 34 x 5, HT, , Magnum225, Magnum250, Magnum280, and Magnum310 |
| 9 | 896-11016 | 24 | WASHER, M17.5 x 30 x 4, HT, , Magnum 335 |
| 11 | 405830A1 | 2 | WEIGHT, Wheel, 1000 lb, Magnum225, Magnum250, Magnum280, and Magnum310 |
| 11 | 405830A1 | 4 | WEIGHT, , Magnum 335 |
| 12 | 87393412 | 6 | BOLT, M16 x 130; 10.9, Magnum225, Magnum250, Magnum280, and Magnum310 |
| 12 | 87393412 | 12 | BOLT, , Magnum 335 |
| 13 | 412066 | 6 | NUT, LOCK, M16 x 2, Cl 8, , Magnum225, Magnum250, Magnum280, and Magnum310 |
| 13 | 412066 | 12 | NUT, LOCK, M16 x 2, Cl 8, , Magnum 335 |
| 14 | 896-15016 | 12 | WASHER, M17.5 x 34 x 5, HT, , Magnum225, Magnum250, Magnum280, and Magnum310 |
| 14 | 896-11016 | 24 | WASHER, M17.5 x 30 x 4, HT, , Magnum 335 |
| 16 | 87361584 | 6 | BOLT, M16 x 140; 10.9 |
| 17 | 412066 | 12 | NUT, LOCK, M16 x 2, Cl 8 |
| 18 | 896-15016 | 12 | WASHER, M17.5 x 34 x 5, HT |
07-01 BRAKES – PEDAL BRAKE
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 400859A3 | 1 | PEDAL ASSY., Left Hand, Inc. 2 – 7 |
| 2 | 1990753C1 | 2 | PLASTIC RING |
| 3 | 188419A1 | 1 | ARM |
| 4 | 906045R1 | 2 | WASHER, SPRING, M10.2 ID x 20.5 OD x .8 Thk |
| 6 | 1999381C1 | 1 | PAD, RUBBER |
| 7 | 298715A1 | 1 | BUSHING |
| 10 | 400862A3 | 1 | PEDAL ASSY., Right Hand, Inc. 11 – 13 |
| 11 | 1990753C1 | 2 | PLASTIC RING |
| 12 | 1999382C1 | 1 | PAD, RUBBER |
| 13 | 298715A1 | 1 | BUSHING |
| 15 | 800-3120 | 1 | CIRCLIP, M20 |
| 17 | 614-8025 | 2 | BOLT, Hex, M8 x 25, 8.8 |
| 18 | 829-1408 | 2 | NUT, M8, Cl 10 |
| 19 | 236504A2 | 2 | SPRING |
| 20 | 279265A2 | 2 | SWITCH |
| 22 | 400865A1 | 2 | ROD |
| 24 | 236323A1 | 2 | CLEVIS |
| 25 | 192869A1 | 2 | PIN, CLEVIS |
| 26 | 193182A1 | 2 | CLIP |
| 28 | 829-1410 | 2 | NUT, M10, Cl 10 |
| 30 | 258242A1 | 1 | WASHER |
| 33 | 87731065 | 1 | VALVE, Brake, See Figure 07-05 |
| 34 | 407142A1 | 1 | GASKET |
| 35 | 806-10030 | 3 | BOLT, Hex, Lock, M10 x 30, Cl 10.9 |
| 36 | 895-18010 | 3 | WASHER, M10 x 18 x 1.6 |
07-02 BRAKES – HYDRAULIC SYSTEM, WITHOUT TRAILER BRAKES
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87731065 | 1 | VALVE, Brake, See Figure 07-05 |
| 2 | 700-106 | 2 | CONNECTOR, HYD., 11/16″-16 ORFS x M18 x 1.5 ORB |
| 4 | 87443446 | 1 | CONDUIT |
| 5 | 87731873 | 1 | Supply |
| 6 | 238-6012 | 3 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 7 | 87577426 | 1 | HOSE |
| 8 | 87454069 | 1 | ELBOW, 13/16 fc sl x 18 Or |
| 11 | 1546024C1 | 5 | CLAMP |
| 12 | 829-1408 | 5 | NUT, M8, Cl 10 |
| 13 | 384870A1 | 5 | PLATE |
| 14 | 436382A1 | 1 | TUBE ASSY., Right Hand Brake |
| 15 | 87363336 | 1 | TUBE ASSY., Left Hand Brake |
| 16 | 433588A1 | 1 | TUBE ASSY., Supply |
| 18 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 19 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 20 | 326965A1 | 1 | SCREEN |
| 21 | 87440347 | 1 | TUBE, Return |
| 23 | 9992298 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 24 | 86598101 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 25 | 87582257 | 2 | HOSE, Brake Pressure, Right Hand and Left Hand, 45 Degree End |
| 27 | 14437985 | 1 | O-RING, 15.3MM ID x 2.4 Thk |
| 28 | 70923841 | 1 | O-RING, 1/2 ID x 1/16 |
| 29 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 30 | 384834A1 | 1 | LINE, Conduit, With Fuel Separator Filter |
| 31 | 316443A2 | 1 | FITTING, 13/16 fc sl x 18 Or, Inc. 17 – 20 |
| 32 | 86579691 | 1 | ELBOW, 90є, 13/16″-18 ORFS x M18 x 1.5 ORB, Inc. 22 – 24 |
| 33 | 700-102 | 2 | CONNECTOR, HYD., 13/16″-16 ORFS x M18 x 1.5 ORB, Inc. 26 – 28 |
| 34 | 214-1408 | 1 | CLAMP, HOSE, #08, 0.50/0.91 Type F Worm |
| 35 | 87331123 | 1 | FITTING, (Not Shown) |
07-03 BRAKES – HYDRAULIC SYSTEM, WITH HYDRAULIC TRAILER BRAKES
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87731065 | 1 | VALVE, Brake, See Figure 07-05 |
| 3 | 14437985 | 1 | O-RING, 15.3MM ID x 2.4 Thk |
| 4 | 70923841 | 2 | O-RING, 1/2 ID x 1/16 |
| 5 | 87549263 | 1 | HOSE, Supply |
| 6 | 238-6012 | 3 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 7 | 87577426 | 1 | HOSE |
| 8 | 87454069 | 1 | ELBOW, 13/16 fc sl x 18 Or |
| 9 | 87443446 | 1 | CONDUIT |
| 11 | 1546024C1 | 5 | CLAMP |
| 12 | 829-1408 | 5 | NUT, M8, Cl 10 |
| 13 | 384870A1 | 5 | PLATE |
| 14 | 87348665 | 1 | TUBE ASSY., Right Hand Brake |
| 15 | 87363337 | 1 | TUBE ASSY., Left Hand Brake |
| 16 | 433588A1 | 1 | TUBE ASSY., Supply |
| 18 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 19 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 20 | 326965A1 | 1 | SCREEN |
| 21 | 87440347 | 1 | TUBE, Return |
| 23 | 9992298 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 24 | 86598101 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 25 | 87582257 | 2 | HOSE, Brake Pressure, Right Hand and Left Hand, 45 Degree End |
| 27 | 14437985 | 1 | O-RING, 15.3MM ID x 2.4 Thk |
| 28 | 70923841 | 1 | O-RING, 1/2 ID x 1/16 |
| 29 | 87363345 | 1 | TUBE ASSY. |
| 31 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 33 | 238-6012 | 3 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 34 | 87348656 | 1 | TUBE ASSY., Right Hand |
| 35 | 87348655 | 1 | TUBE ASSY., Left Hand |
| 36 | 515-2295 | 3 | CLAMP, 3/8″, Insul, 5/16″ Bolt, 3/8 ID |
| 37 | 86985589 | 1 | HOSE ASSY. |
| 38 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 39 | 384834A1 | 1 | LINE, Conduit, With Fuel Separator Filter |
| 40 | 700-412 | 2 | TEE, 13/16″-16 ORFS x M18 x 1.5 ORB Run, Inc. 2 – 4 |
| 41 | 316443A2 | 1 | FITTING, 13/16 fc sl x 18 Or, Inc. 17 – 20 |
| 42 | 86579691 | 1 | ELBOW, 90є, 13/16″-18 ORFS x M18 x 1.5 ORB, Inc. 22 – 24 |
| 43 | 700-102 | 2 | CONNECTOR, HYD., 13/16″-16 ORFS x M18 x 1.5 ORB, Inc. 26 – 28 |
| 44 | 87731875 | 1 | Inc. 30, 31 |
| 45 | 86991302 | 1 | VALVE, HYDRAULIC, Inc. 33 |
| 46 | 214-1408 | 1 | CLAMP, HOSE, #08, 0.50/0.91 Type F Worm |
| 47 | 87331123 | 1 | FITTING, (Not Shown) |
07-04 BRAKES – HYDRAULIC SYSTEM, WITH PNEUMATIC TRAILER BRAKES
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87731065 | 1 | VALVE, Brake, See Figure 07-05 |
| 3 | 14437985 | 1 | O-RING, 15.3MM ID x 2.4 Thk |
| 4 | 70923841 | 2 | O-RING, 1/2 ID x 1/16 |
| 5 | 87549263 | 1 | HOSE, Supply |
| 6 | 238-6012 | 3 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 7 | 87577426 | 1 | HOSE |
| 8 | 87454069 | 1 | ELBOW, 13/16 fc sl x 18 Or |
| 9 | 87443446 | 1 | CONDUIT |
| 11 | 1546024C1 | 5 | CLAMP |
| 12 | 829-1408 | 5 | NUT, M8, Cl 10 |
| 13 | 384870A1 | 5 | PLATE |
| 14 | 87348665 | 1 | TUBE ASSY., Right Hand Brake |
| 15 | 87363337 | 1 | TUBE ASSY., Left Hand Brake |
| 16 | 433588A1 | 1 | TUBE ASSY., Supply |
| 18 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 19 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 20 | 326965A1 | 1 | SCREEN |
| 21 | 87440347 | 1 | TUBE, Return |
| 23 | 9992298 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 24 | 86598101 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 25 | 87582257 | 2 | HOSE, Brake Pressure, Right Hand and Left Hand, 45 Degree End |
| 27 | 14437985 | 1 | O-RING, 15.3MM ID x 2.4 Thk |
| 28 | 70923841 | 1 | O-RING, 1/2 ID x 1/16 |
| 29 | 87363345 | 1 | TUBE ASSY. |
| 31 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 32 | 176143A1 | 1 | VALVE |
| 33 | 442240A1 | 2 | TUBE ASSY. |
| 35 | 237-6006 | 1 | O-RING, 6-1, 90 Duro, .468″ ID x .078″ Thk |
| 36 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 38 | 237-6006 | 1 | O-RING, 6-1, 90 Duro, .468″ ID x .078″ Thk |
| 39 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 40 | 515-2295 | 3 | CLAMP, 3/8″, Insul, 5/16″ Bolt |
| 42 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 43 | 384834A1 | 1 | LINE, Conduit |
| 44 | 700-412 | 2 | TEE, 13/16″-16 ORFS x M18 x 1.5 ORB Run, Inc. 2 – 4 |
| 45 | 214-1408 | 1 | CLAMP, HOSE, #08, 0.50/0.91 Type F Worm |
| 46 | 201-101 | 1 | CONNECTOR, HYD., 11/16″-16 ORFS x 9/16″-18 ORB, Inc. 37 – 39 |
| 47 | 201-304 | 2 | ELBOW, 90є, 11/16″-16 x 9/16″-18 Adj, ORFS, Inc. 34 – 36 |
| 48 | 87731875 | 1 | Inc. 30, 31 |
| 49 | 700-102 | 2 | CONNECTOR, HYD., 13/16″-16 ORFS x M18 x 1.5 ORB, Inc. 26 – 28 |
| 50 | 316443A2 | 1 | FITTING, Inc. 17 – 20 |
| 51 | 86579691 | 1 | ELBOW, 90є, 13/16″-18 ORFS x M18 x 1.5 ORB, Inc. 22 – 24 |
| 52 | 87331123 | 1 | FITTING, (Not Shown) |
07-05 BRAKES – CONTROL VALVE
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87731065 | 1 | VALVE, Inc. 1 – 21 |
| 7 | 279266A1 | 2 | SWITCH, Inc. 8, 9 |
| 8 | 237-6003 | 1 | O-RING, 3-1, .301″ ID x .064″ Thk |
| 10 | 397106A5 | 2 | SPOOL |
| 11 | 397105A5 | 2 | SLEEVE |
| 12 | 433199A1 | 2 | POPPET |
| 13 | 433196A2 | 2 | SPRING |
| 14 | 407387A1 | 2 | SEALRING |
| 15 | 238-7131 | 2 | O-RING, -131, Cl 7, 1.674″ ID x .103″ Thk |
| 16 | 407282A1 | 2 | RING, SNAP |
| 17 | 397110A1 | 2 | SPRING, COMPRESSION |
| 18 | 220056A1 | 3 | SCREW, Hex Soc Flat Hd, M10 x 20, 8.8 |
| 19 | A63399 | 2 | SEAL |
| 20 | 397111A1 | 1 | PLATE |
| 21 | 403356A1 | 1 | GASKET |
07-06 BRAKES – DIFFERENTIAL
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 1342723C2 | 2 | COVER |
| 2 | 813-16110 | 6 | BOLT, Hex, M16 x 110, 8.8, Right Hand |
| 2 | 814-16100 | 6 | BOLT, Hex, M16 x 100, 8.8, Left Hand |
| 10 | 120486C1 | 8 | PLATE, BRAKE |
| 11 | 120488C2 | 8 | PLATE, BRAKE |
| 12 | 1981187C1 | 2 | PLATE |
| 18 | 1349198C1 | 6 | ADJUSTER, Inc. 19, 20 |
| 19 | 37-1828 | 1 | DOWEL, 1/2″ x 1 3/4″ |
| 20 | 100-1450 | 2 | RING, SNAP, #50, Ext |
| 21 | 1342928C1 | 12 | WASHER |
| 25 | 120514C2 | 4 | TUBE |
| 26 | 238-5013 | 8 | O-RING, -013, 70 Duro, .426″ ID x .070″ Thk |
07-07 PARK AND EMERGENCY BRAKE – LEVER AND LINKAGE
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 284357A2 | 1 | HANDLE |
| 2 | 375302A1 | 1 | BRACKET |
| 3 | 895-11008 | 3 | WASHER, M8 x 16 x 1.6 |
| 4 | 614-8025 | 3 | BOLT, Hex, M8 x 25, 8.8 |
| 5 | 284297A1 | 1 | CABLE |
| 6 | 427-6106 | 1 | PIN, CLEVIS, 3/8″ x 1 1/16″ |
| 7 | 427-6125 | 1 | PIN, CLEVIS, 3/8″ x 1 1/4″ |
| 8 | 733-2520 | 2 | PIN, SPLIT (COTTER), M2.5 x 20 |
| 9 | L11541 | 1 | STRAP, CABLE |
| 10 | 800-4313 | 1 | CIRCLIP, M13 |
| 11 | 895-18010 | 2 | WASHER, M10 x 18 x 1.6 |
| 12 | 87545438 | 1 | BRACKET, Assemble W/87545446 |
| 13 | 614-10020 | 1 | BOLT, Hex, M10 x 20, 8.8, Full Thd |
| 14 | 450061A1 | 1 | VALVE, , See Figure 07-09 |
| 15 | 895-11012 | 2 | WASHER, M12 x 24 x 2.5 |
| 16 | 1533540C1 | 2 | EYEBOLT |
| 17 | 800-1112 | 1 | RING, SNAP, M12, Ext |
| 18 | 713-126 | 2 | CLEVIS |
| 19 | 428302A1 | 1 | ROD |
| 20 | 728-630 | 2 | PIN, CLEVIS, M6 x 30 |
| 21 | 829-1406 | 2 | NUT, M6, Cl 10 |
| 22 | 427-6106 | 1 | PIN, CLEVIS, 3/8″ x 1 1/16″ |
| 23 | 895-11010 | 1 | WASHER, M10 x 20 x 2 |
| 24 | 733-2520 | 1 | PIN, SPLIT (COTTER), M2.5 x 20 |
| 25 | 428306A2 | 1 | BELLCRANK |
| 26 | 728-620 | 1 | PIN, CLEVIS, M6 x 20 |
| 27 | 895-11006 | 3 | WASHER, M6 |
| 28 | 733-1610 | 3 | PIN, SPLIT (COTTER), M1.6 x 10 |
| 29 | 327572A2 | 1 | SPRING |
| 30 | 628-8016 | 2 | BOLT, Hex, M8 x 16, 10.9, Full Thd |
| 31 | 87545446 | 1 | BRACKET |
| 32 | 825-2408 | 2 | NUT, M8 x 1.25, Flg, Cl 8 |
07-08 PARK AND EMERGENCY BRAKE – HYDRAULIC SYSTEM
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87433653 | 1 | PLATE ASSY., , See Figure 06-04 |
| 2 | 700-326 | 1 | ELBOW, 90є, 13/16″-18 ORFS x M22 x 1.5 ORB, Incl. 3, 4 |
| 3 | 637-63193 | 1 | O-RING, Cl 6, 19.3MM ID x 2.2 Thk |
| 4 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 5 | 448220A1 | 1 | TUBE ASSY. |
| 6 | 700-402 | 1 | TEE, 13/16″-16 ORFS x M18 x 1.5 ORB Br, Inc. 7, 8 |
| 7 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 8 | 238-6014 | 2 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 9 | 451179A2 | 1 | TUBE ASSY. |
| 10 | 700-412 | 1 | TEE, 13/16″-16 ORFS x M18 x 1.5 ORB Run, Inc. 11, 12 |
| 11 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 12 | 238-6014 | 2 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 14 | 450061A1 | 1 | VALVE, , See Figure 07-09 |
| 15 | 238-5112 | 6 | O-RING, -112, 70 Duro, .487″ ID x .103″ Thk |
| 16 | 238-5115 | 2 | O-RING, -115, 70 Duro, .674″ ID x .103″ Thk |
| 17 | 449874A1 | 1 | COVER |
| 18 | 864-10080 | 2 | SCREW, Hex Soc Hd, M10 x 80, 8.8 |
| 19 | 614-10030 | 7 | BOLT, Hex, M10 x 30, 8.8 |
| 20 | 700-332 | 1 | ELBOW, 90є, 13/16″-18 ORFS x M14 x 1.5 ORB, Inc. 21, 22 |
| 21 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 22 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 23 | 87587688 | 1 | TUBE ASSY., Emergency Break Valve Outlet |
| 24 | 700-443 | 1 | TEE, 13/16″-16 ORFS x M14 x 1.5 ORB Br, Inc. 25, 26, 27 |
| 25 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 26 | 238-6014 | 2 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 28 | 87441296 | 1 | TUBE, Park Brake Lower Supply |
| 29 | 87327182 | 1 | COVER |
| 30 | 628-10030 | 4 | BOLT, Hex, M10 x 30, 10.9, Full Thd |
| 31 | 87521424 | 1 | SENDER, TEMPERATURE, Transmission |
| 32 | 82029752 | 1 | DECAL |
| 33 | 701-411 | 1 | TEE, 13/16″-16 ORFS x 13/16″-16 Fem Sw Br |
| 34 | 201-102 | 1 | CONNECTOR, HYD., 13/16″-16 ORFS x 3/4″-16 ORB |
| 35 | 322529A1 | 1 | COUPLING |
| 36 | 143349A1 | 1 | DUST CAP |
07-09 PARK AND EMERGENCY BRAKE – VALVE ASSEMBLY
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 450061A1 | 1 | VALVE, Inc. 2 – 29 |
| 2 | 349295A1 | 1 | SOLENOID, Inc. 3 – 8 |
| 3 | 237-6008 | 1 | O-RING, 8-1, 90 Duro, .644″ ID x .087″ Thk |
| 4 | 238-5013 | 1 | O-RING, -013, 70 Duro, .426″ ID x .070″ Thk |
| 5 | 238-5014 | 1 | O-RING, -014, 70 Duro, .489″ ID x .070″ Thk |
| 7 | 298614A1 | 1 | SOLENOID |
| 8 | 349292A1 | 1 | NUT |
| 11 | 221578A1 | 4 | PLUG, Hex Soc, M18 x 1.5, ORB, Inc. 12 |
| 12 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 13 | 295920A1 | 1 | PIN |
| 14 | 314877A2 | 1 | SPOOL, Inc. 15 |
| 15 | 637-64236 | 1 | O-RING, Cl 6, 23.6MM ID x 2.9 Thk |
| 23 | 315514A1 | 1 | PLUG, Inc. 24 – 26 |
| 24 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 25 | 238-6013 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 26 | 237-6008 | 1 | O-RING, 8-1, 90 Duro, .644″ ID x .087″ Thk |
| 27 | 221576A1 | 1 | PLUG, Hex Soc, M14 x 1.5, ORB, Inc. 28 |
| 28 | 14437785 | 1 | O-RING, 11.3MM ID x 2.4 Thk |
07-10 PARK BRAKE – RELEASE
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87435703 | 1 | PLATE |
| 2 | 248-2164 | 1 | GROMMET, 1/4″ ID x 7/16″ Groove Dia |
| 3 | 87442200 | 1 | ROD |
| 4 | 279765A3 | 1 | PISTON |
| 5 | 282624A1 | 1 | SUPPORT |
| 6 | 627-8020 | 4 | BOLT, Hex, M8 x 20, 10.9 |
| 7 | 282456A1 | 1 | SPRING |
| 8 | 432-48 | 1 | PIN, SPLIT (COTTER), 1/16″ x 1/2″ |
| 9 | 279763A2 | 1 | BRAKE LEVER, Release |
| 13 | 638-53160 | 1 | O-RING, Cl 5, 16MM ID x 2.65 Thk |
| 14 | 87433653 | 1 | PLATE ASSY., , See Figure 06-04 |
| 15 | 136-159 | 1 | PIN, SPLIT (COTTER), Int, 3/16 x .080″ |
| 16 | 169850C2 | 2 | CLIP, CABLE |
07-11 TRAILER BRAKES – HYDRAULIC, EXCEPT ITALY – BSN Z7RZ01521
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87456032 | 1 | TUBE ASSY. |
| 2 | 87544278 | 1 | TUBE ASSY. |
| 3 | 87456034 | 1 | TUBE ASSY. |
| 4 | 87367652 | 1 | TUBE ASSY. |
| 5 | 87337403 | 1 | HOSE |
| 6 | 1975266C1 | 1 | CONNECTOR, HYD. |
| 7 | 3131463R91 | 1 | BREAKER POINTS |
| 8 | 87395937 | 1 | BRACKET |
| 9 | 515-22127 | 1 | CLAMP, 1/2″, Insul, 5/16″ Bolt |
| 10 | 844-8020 | 3 | BOLT, Hex Flg, M8 x 20, 8.8 |
| 11 | 515-2295 | 1 | CLAMP, 3/8″, Insul, 5/16″ Bolt |
| 12 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 13 | 363255A1 | 3 | CLAMP |
| 14 | 384870A1 | 3 | PLATE |
| 15 | 814-8055 | 3 | BOLT, Hex, M8 x 55, 8.8 |
| 16 | 384871A1 | 3 | PLATE |
| 17 | 87309386 | 1 | BRACKET |
| 18 | 87309660 | 1 | BRACKET |
| 19 | 614-10016 | 2 | BOLT, Hex, M10 x 16, 8.8, Full Thd |
| 20 | 87442945 | 1 | HOSE |
| 21 | 87312846 | 2 | ELBOW, Inc. 22 |
| 22 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 23 | 700-412 | 1 | TEE, 13/16″-16 ORFS x M18 x 1.5 ORB Run, Inc. 24, 25 |
| 24 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 25 | 238-6014 | 2 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 26 | 87312753 | 1 | VALVE, CHECK |
| 27 | 87435690 | 1 | TUBE ASSY. |
| 28 | 700-101 | 1 | CONNECTOR, HYD., 11/16″-16 ORFS x M14 x 1.5 ORB, Incl. 29, 30 |
| 29 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 30 | 238-6012 | 2 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 31 | 700-162 | 1 | CONNECTOR, HYD., 13/16″-16 ORFS x M22 x 1.5 ORB, Inc. 32, 33 |
| 32 | 637-63193 | 1 | O-RING, Cl 6, 19.3MM ID x 2.2 Thk |
| 33 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 34 | 86597761 | 1 | CONNECTOR, HYD., 13/16″-16 ORFS x M27 x 2 ORB, Incl. 35, 36 |
| 35 | 637-64236 | 1 | O-RING, Cl 6, 23.6MM ID x 2.9 Thk |
| 36 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 37 | 700-304 | 1 | ELBOW, 90є, 11/16″-18 ORFS x M14 x 1.5 ORB, Incl. 38, 39 |
| 38 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 39 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 40 | 87365235 | 1 | HOSE |
| 41 | 214-1408 | 2 | CLAMP, HOSE, #08, 0.50/0.91 Type F Worm |
| 42 | L11541 | 1 | STRAP, CABLE |
| 43 | 87324560 | 1 | VALVE, Trailer Brake (Shown) |
07-12 TRAILER BRAKES – HYDRAULIC, EXCEPT ITALY – ASN Z7RZ01521
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87620393 | 1 | TUBE ASSY., Load Sense, Aux Manifold |
| 2 | 87625086 | 1 | TUBE ASSY., Load Sense |
| 3 | 87655554 | 1 | HOSE ASSY., Brake Supply |
| 4 | 87659135 | 1 | TUBE ASSY., Aux Manifold Supply |
| 5 | 87337403 | 1 | HOSE |
| 6 | 1975266C1 | 1 | CONNECTOR, HYD. |
| 7 | 3131463R91 | 1 | BREAKER POINTS |
| 8 | 86988626 | 1 | BRACKET |
| 9 | 844-8020 | 2 | BOLT, Hex Flg, M8 x 20, 8.8 |
| 10 | 515-2295 | 1 | CLAMP, 3/8″, Insul, 5/16″ Bolt |
| 11 | 1546024C1 | 1 | CLAMP |
| 12 | 384870A1 | 1 | PLATE |
| 13 | 384871A1 | 1 | PLATE |
| 14 | 844-8045 | 1 | BOLT, Hex Flg, M8 x 45, 8.8 |
| 15 | 700-407 | 1 | TEE, 1 7/16″-12 ORFS x M33 x 2 ORB Run, Inc. 16, 17 |
| 16 | 238-6021 | 2 | O-RING, -021, 90 Duro, .926″ ID x .070″ Thk |
| 17 | 637-64296 | 1 | O-RING, Cl 6, 29.6MM ID x 2.9 Thk |
| 18 | 87442945 | 1 | HOSE |
| 19 | 87312846 | 2 | ELBOW, Inc. 20 |
| 20 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 21 | 701-422 | 1 | TEE, 11/16″-16 ORFS x 11/16″-16 Fem Sw Run, Inc. 22 |
| 22 | 238-6012 | 2 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 23 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 25 | 86579691 | 1 | ELBOW, 90є, 13/16″-18 ORFS x M18 x 1.5 ORB, Inc. 27, 28 |
| 27 | 9992298 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 28 | 86598101 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 29 | 700-166 | 2 | CONNECTOR, HYD., 1 7/16″-12 ORFS x M27 x 1.5 ORB, Inc. 30, 31 |
| 30 | 238-6021 | 2 | O-RING, -021, 90 Duro, .926″ ID x .070″ Thk |
| 31 | 637-64236 | 2 | O-RING, Cl 6, 23.6MM ID x 2.9 Thk |
| 32 | 86597761 | 1 | CONNECTOR, HYD., 13/16″-16 ORFS x M27 x 2 ORB |
| 33 | 637-64236 | 1 | O-RING, Cl 6, 23.6MM ID x 2.9 Thk |
| 34 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 35 | 700-304 | 1 | ELBOW, 90є, 11/16″-18 ORFS x M14 x 1.5 ORB, Incl. 36, 37 |
| 36 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 37 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 38 | 87365235 | 1 | HOSE |
| 39 | 214-1408 | 2 | CLAMP, HOSE, #08, 0.50/0.91 Type F Worm |
| 40 | L11541 | 1 | STRAP, CABLE |
| 41 | 87624376 | 1 | VALVE |
| 42 | 701-901 | 1 | CAP, 1 7/16″-12 ORFS, , Not Required With Power Beyond |
07-13 TRAILER BRAKES – HYDRAULIC – ACCUGUIDE
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87337403 | 1 | HOSE |
| 2 | 1975266C1 | 1 | CONNECTOR, HYD. |
| 3 | 3131463R91 | 1 | BREAKER POINTS |
| 4 | L11541 | 1 | STRAP, CABLE |
| 5 | 87365235 | 1 | HOSE |
| 6 | 87312846 | 2 | ELBOW, Inc. 7 |
| 7 | 637-63153 | 2 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 8 | 214-1408 | 2 | CLAMP, HOSE, #08, 0.50/0.91 Type F Worm |
| 9 | 87442945 | 1 | HOSE |
| 10 | 700-412 | 2 | TEE, 13/16″-16 ORFS x M18 x 1.5 ORB Run, Inc. 11 – 13 |
| 12 | 14437985 | 2 | O-RING, 15.3MM ID x 2.4 Thk |
| 13 | 70923841 | 4 | O-RING |
| 14 | 87348655 | 1 | TUBE ASSY., Left Hand |
| 15 | 86991302 | 1 | VALVE, HYDRAULIC |
| 17 | 238-6012 | 3 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 18 | 87348656 | 1 | TUBE ASSY., Right Hand |
| 19 | 87549263 | 1 | HOSE, Supply |
| 20 | 87443446 | 1 | CONDUIT |
| 21 | 87363337 | 1 | TUBE ASSY., Left Hand Brake |
| 22 | 87348665 | 1 | TUBE ASSY., Right Hand Brake |
| 23 | 87363345 | 1 | TUBE ASSY., Trailer Brake pilot |
| 24 | 86988933 | 1 | CONNECTOR, HYD., Inc. 25, 26 |
| 26 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 27 | 87448971 | 1 | HOSE, Supply, Right Hand |
| 28 | 87448974 | 1 | HOSE, Supply, Left Hand |
| 29 | 87451399 | 1 | CONDUIT |
| 30 | 87318281 | 1 | CONDUIT |
| 31 | 701-415 | 1 | TEE, 1″-14 ORFS, Inc. 32 |
| 32 | 238-6016 | 3 | O-RING, -016, 90 Duro, .614″ ID x .070″ Thk |
| 33 | 87435660 | 1 | TUBE ASSY., Hitch Supply |
| 34 | 700-306 | 1 | ELBOW, 90є, 1″-14 ORFS x M22 x 1.5 ORB, Incl. 35, 36 |
| 35 | 637-63193 | 1 | O-RING, Cl 6, 19.3MM ID x 2.2 Thk |
| 36 | 238-6016 | 1 | O-RING, -016, 90 Duro, .614″ ID x .070″ Thk |
| 37 | 87367650 | 1 | TUBE ASSY., Load Sense |
| 38 | 1546024C1 | 1 | CLAMP |
| 39 | 384870A1 | 1 | PLATE |
| 40 | 384871A1 | 1 | PLATE |
| 41 | 844-8045 | 1 | BOLT, Hex Flg, M8 x 45, 8.8 |
| 42 | 87625088 | 1 | TUBE ASSY. |
| 43 | 700-304 | 1 | ELBOW, 90є, 11/16″-18 ORFS x M14 x 1.5 ORB, Incl. 44, 45 |
| 44 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 45 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 46 | 87625086 | 1 | TUBE ASSY., Load Sense |
| 47 | 87655554 | 1 | HOSE ASSY., Brake Supply |
| 48 | 87659135 | 1 | TUBE ASSY., Aux Manifold Supply |
| 49 | 700-407 | 1 | TEE, 1 7/16″-12 ORFS x M33 x 2 ORB Run, Inc. 50, 51 |
| 50 | 238-6021 | 2 | O-RING, -021, 90 Duro, .926″ ID x .070″ Thk |
| 51 | 637-64296 | 1 | O-RING, Cl 6, 29.6MM ID x 2.9 Thk |
| 52 | 844-10016 | 1 | BOLT, Hex Flg, M10 x 16, 8.8, Full Thd |
| 53 | 515-23206 | 1 | CLAMP, 13/16″, Insul, 3/8″ Bolt |
| 54 | 844-8020 | 1 | BOLT, Hex Flg, M8 x 20, 8.8 |
| 55 | 87451398 | 1 | CONDUIT |
| 56 | 87624376 | 1 | VALVE |
| 57 | 87418091 | 1 | STUD |
| 58 | 87445565 | 2 | STUD |
| 59 | 86579691 | 1 | ELBOW, 90є, 13/16″-18 ORFS x M18 x 1.5 ORB, Inc. 60, 61, 62 |
| 61 | 9992298 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 62 | 86598101 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 63 | 515-2295 | 3 | CLAMP, 3/8″, Insul, 5/16″ Bolt |
| 64 | 700-166 | 2 | CONNECTOR, HYD., 1 7/16″-12 ORFS x M27 x 1.5 ORB, Inc. 65, 66 |
| 65 | 238-6021 | 2 | O-RING, -021, 90 Duro, .926″ ID x .070″ Thk |
| 66 | 637-64236 | 2 | O-RING, Cl 6, 23.6MM ID x 2.9 Thk |
| 67 | 701-901 | 1 | CAP, 1 7/16″-12 ORFS |
| 68 | 86985195 | 1 | BRACKET |
| 69 | 701-422 | 1 | TEE, 11/16″-16 ORFS x 11/16″-16 Fem Sw Run, Inc. 70 |
| 70 | 238-6012 | 2 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 71 | 87620393 | 1 | TUBE ASSY., Load Sense, Aux Manifold |
07-14 TRAILER BRAKES – HYDRAULIC, ITALY ONLY
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 446347A1 | 1 | VALVE, Trailer Brake |
| 2 | 1533774C2 | 1 | VALVE, HYDRAULIC, Priority |
| 3 | 1348540C1 | 1 | VALVE, CHECK, Check |
| 4 | 844-8025 | 4 | BOLT, Hex Flg, M8 x 25, 8.8 |
| 5 | 384870A1 | 3 | PLATE |
| 6 | 87403709 | 1 | BRACKET |
| 7 | 201-102 | 3 | CONNECTOR, HYD., 13/16″-16 ORFS x 3/4″-16 ORB, Includes 8, 9 |
| 8 | 237-6008 | 1 | O-RING, 8-1, 90 Duro, .644″ ID x .087″ Thk |
| 9 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 10 | 201-101 | 3 | CONNECTOR, HYD., 11/16″-16 ORFS x 9/16″-18 ORB, Includes 11, 12 |
| 11 | 237-6006 | 1 | O-RING, 6-1, 90 Duro, .468″ ID x .078″ Thk |
| 12 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 13 | 86985133 | 1 | TUBE ASSY., Steering Supply |
| 14 | 451058A1 | 1 | TUBE ASSY., Steering Sensor |
| 15 | 433945A1 | 1 | TUBE ASSY., Steering Supply |
| 16 | 433946A1 | 1 | TUBE ASSY., Steering Sensor |
| 17 | 201-434 | 1 | TEE, 11/16″-18 ORFS x 11/16″-18 Sw Br, 11/16 fc sl x 11/16 sw, Inc. 18 |
| 18 | 238-6012 | 2 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 19 | 895-11008 | 2 | WASHER, M8 x 16 x 1.6 |
| 20 | 614-8016 | 2 | BOLT, Hex, M8 x 16, 8.8 |
| 21 | 844-10025 | 2 | BOLT, Hex Flg, M10 x 25, 8.8, Full Thd, M10 x 20; 8.8 |
| 22 | 363255A1 | 2 | CLAMP |
| 23 | 384871A1 | 3 | PLATE |
| 24 | 814-8055 | 2 | BOLT, Hex, M8 x 55, 8.8, M8 x 55; 8,8 |
| 29 | 201-322 | 1 | ELBOW, 90є, 9/16″-18 Adj x 9/16″-18 Fem Sw, ORFS, 9/16 Or x 11/16 sw, Inc. 30 |
| 30 | 237-6006 | 1 | O-RING, 6-1, 90 Duro, .468″ ID x .078″ Thk |
| 31 | 201-106 | 1 | CONNECTOR, HYD., 11/16″-16 ORFS x 3/4″-16 ORB, 11/16 fc sl x 3/4 Or, Inc. 32, 33 |
| 32 | 237-6008 | 1 | O-RING, 8-1, 90 Duro, .644″ ID x .087″ Thk |
| 33 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 34 | 515-22127 | 2 | CLAMP, 1/2″, Insul, 5/16″ Bolt |
| 35 | 86985131 | 1 | BRACKET |
| 36 | 515-2295 | 4 | CLAMP, 3/8″, Insul, 5/16″ Bolt, 3/8 ID |
| 37 | 434093A1 | 1 | ADAPTER, Inc. 38, 39 |
| 38 | 238-5119 | 1 | O-RING, -119, 70 Duro, .924″ ID x .103″ Thk |
| 39 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 40 | 448524A1 | 1 | TUBE ASSY. |
| 41 | 87403712 | 1 | TUBE ASSY., Trailer Brake Supply |
| 42 | 87403713 | 1 | TUBE ASSY., Trailer Brake Return |
| 43 | 448527A1 | 1 | TUBE ASSY., Trailer Brake Sensor |
| 44 | 86985790 | 1 | HOSE |
| 45 | 448548A1 | 3 | CONNECTOR, HYD. |
| 46 | 86985788 | 1 | CONNECTOR, HYD. |
| 47 | 443761A1 | 1 | BRACKET |
| 48 | 844-10016 | 1 | BOLT, Hex Flg, M10 x 16, 8.8, Full Thd, M10 x 16; 8.8 |
| 49 | 844-8060 | 3 | BOLT, Hex Flg, M8 x 60, 8.8, M8 x 60; 8.8 |
| 50 | 3131463R91 | 1 | BREAKER POINTS |
| 51 | 1975266C1 | 1 | CONNECTOR, HYD. |
| 52 | 515-23286 | 1 | CLAMP, 1 1/8″, Insul, 3/8″ Bolt |
| 53 | 700-169 | 1 | CONNECTOR, HYD., 13/16″-16 ORFS x M16 x 1.5 ORB, 13/16 fc sl x 16 Or, Inc. 54, 55 |
| 54 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 55 | 637-63133 | 1 | O-RING, Cl 6, 13.3MM ID x 2.2 Thk, 13,3 ID x 2,2 |
| 56 | 201-329 | 1 | ELBOW, 90є, 9/16″-18 x 9/16″-18 Fem Sw ORFS, 9/16 fc sl x 9/16 sw, Inc. 57 |
| 57 | 238-6011 | 1 | O-RING, -011, 90 Duro, .301″ ID x .070″ Thk |
| 58 | 87403625 | 1 | ADAPTER, Inc. 59 |
| 59 | 237-6004 | 1 | O-RING, 4-1, 90 Duro, .351″ ID x .072″ Thk |
| 60 | 87406506 | 1 | SWITCH, PRESSURE |
| 61 | 700-443 | 1 | TEE, 13/16″-16 ORFS x M14 x 1.5 ORB Br, 13/16 fc sl x x 14 Or, Inc. 62, 63 |
| 62 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 63 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 64 | 86989146 | 1 | ADAPTER |
| 65 | 87401139 | 1 | SWITCH, PRESSURE |
| 66 | 87409357 | 1 | HARNESS |
| 67 | 221578A1 | 1 | PLUG, Hex Soc, M18 x 1.5, ORB, Includes 68 |
| 68 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 69 | 410573A1 | 1 | CLAMP |
| 70 | 700-154 | 1 | CONNECTOR, HYD., 13/16″-16 ORFS x M14 x 1.5 ORB, 13/16 fc sl x 14 Or, Inc. 71, 72 |
| 71 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 72 | 238-6014 | 1 | O-RING, -014, 90 Duro, .489″ ID x .070″ Thk |
| 73 | 825-2408 | 1 | NUT, M8 x 1.25, Flg, Cl 8 |
| 74 | 844-8020 | 3 | BOLT, Hex Flg, M8 x 20, 8.8 |
| 75 | 701-907 | 1 | CAP, 1 3/16″-12 ORFS, 1-3/16 |
| 76 | 844-8025 | 1 | BOLT, Hex Flg, M8 x 25, 8.8 |
| 77 | 87402551 | 1 | TEE, Inc. 76, 77 |
| 78 | 637-64296 | 1 | O-RING, Cl 6, 29.6MM ID x 2.9 Thk, 29,6 ID x 2,9 |
| 79 | 238-6018 | 1 | O-RING, -018, 90 Duro, .739″ ID x .070″ Thk |
| 80 | 87403003 | 1 | CONNECTOR, HYD., 14 Or x 14 Or, Inc. 79 |
| 81 | 637-63113 | 2 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 82 | 87403711 | 1 | TUBE ASSY. |
| 83 | 87403714 | 1 | CONNECTOR, HYD., Inc. 82 |
| 84 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 85 | 238-6016 | 3 | O-RING, -016, 90 Duro, .614″ ID x .070″ Thk |
| 86 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk |
| 87 | 448529A2 | 1 | BRACKET |
| 88 | 844-8020 | 3 | BOLT, Hex Flg, M8 x 20, 8.8 |
| 89 | 238-6011 | 1 | O-RING, -011, 90 Duro, .301″ ID x .070″ Thk |
07-15 VALVE – HYDRAULIC TRAILER BRAKE
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87324560 | 1 | VALVE, Trailer Brake (Shown), BSN Z7RZ01521 |
| 1 | 87624376 | 1 | VALVE, Trailer brake, ASN Z7RZ01521 |
| 3 | 87324557 | 1 | PLUG, STOP, Inc. 4 |
| 4 | 637-63193 | 1 | O-RING, Cl 6, 19.3MM ID x 2.2 Thk |
| 5 | 87444752 | 1 | BRAKE SPRING |
| 6 | 87324553 | 1 | SPOOL |
| 7 | 86988723 | 1 | SPOOL, Inner |
| 8 | 87444751 | 1 | BRAKE SPRING, Inner |
| 9 | 87444750 | 1 | BRAKE SPRING, Outer |
| 10 | 87312086 | 1 | PISTON, Priority |
| 12 | 87454597 | 1 | PLUG |
| 13 | 637-64296 | 1 | O-RING, Cl 6, 29.6MM ID x 2.9 Thk |
| 14 | 221580A1 | 1 | PLUG, Hex Soc, M27 x 2, ORB, Inc. 15 |
| 15 | 637-64236 | 1 | O-RING, Cl 6, 23.6MM ID x 2.9 Thk |
| 16 | 87324556 | 1 | SPOOL, Priority (Shown), BSN Z7RZ01521 |
| 16 | 87627346 | 1 | SPOOL, Priority, ASN Z7RZ01521 |
| 17 | 408447A1 | 1 | SPRING, COMPRESSION |
| 18 | 87432142 | 1 | FITTING, PIPE, Orifice, Inc. 19 (Shown), BSN Z7RZ01521 |
| 18 | 218-5212 | 1 | PLUG, Hex Soc, 1 1/16″-12 ORB, Inc. 19, ASN Z7RZ01521 |
| 19 | 237-6012 | 1 | O-RING, 12-1, 90 Duro, .924 ID x .118″ Thk |
| 20 | 243756A1 | 5 | PLUG, 7 mm |
| 21 | 221578A1 | 1 | PLUG, Hex Soc, M18 x 1.5, ORB, Inc. 22 |
| 22 | 637-63153 | 1 | O-RING, Cl 6, 15.3MM ID x 2.2 Thk |
| 23 | 223971A1 | 1 | VALVE, CHECK, , ASN Z7RZ01521 |
| 24 | 637-63113 | 1 | O-RING, Cl 6, 11.3MM ID x 2.2 Thk, , ASN Z7RZ01521 |
| 25 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk, , ASN Z7RZ01521 |
07-16 TRAILER BRAKES – PNEUMATIC, AIR COMPRESSOR MOUNTING AND DRIVE
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87354605 | 1 | SUPPORT |
| 3 | 87354608 | 1 | PLATE, ADJUSTING |
| 4 | 87340869 | 1 | COMPRESSOR |
| 5 | 864-8040 | 4 | SCREW, Hex Soc Hd, M8 x 40, 8.8 |
| 6 | 614-10090 | 1 | BOLT, Hex, M10 x 90, 8.8, Full Thd |
| 7 | 87364913 | 1 | ADAPTER, Elbow, M10 x 7/16 |
| 8 | 87366493 | 4 | STUD |
| 10 | 87434646 | 1 | UNION, 11/16 fc sl x 16, Inc. 11 |
| 11 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 12 | 87551841 | 1 | ADAPTER |
| 13 | 829-2410 | 4 | NUT, M10 x 1.5, Flg, Cl 10 |
| 14 | 87434210 | 1 | STEM |
| 15 | 87551845 | 1 | WASHER, COPPER |
| 17 | J918215 | 1 | ADAPTER |
| 18 | 201-304 | 1 | ELBOW, 90є, 11/16″-16 x 9/16″-18 Adj, ORFS, Inc. 19, 20, 44 |
| 19 | 237-6006 | 1 | O-RING, 6-1, 90 Duro, .468″ ID x .078″ Thk |
| 20 | 238-6012 | 1 | O-RING, -012, 90 Duro, .364″ ID x .070″ Thk |
| 21 | 177335A3 | 1 | PLATE, LARGE |
| 22 | J903475 | 1 | SEAL |
| 23 | J915800 | 1 | O-RING |
| 24 | T103887 | 2 | WASHER |
| 25 | 614-6012 | 2 | BOLT, Hex, M6 x 12, 8.8 |
| 26 | 87365032 | 1 | HOSE, Compressor Supply |
| 27 | 87365056 | 1 | HOSE ASSY., Lube Out |
| 28 | 87357622 | 1 | HOSE, Air Cleaner to Turbo, BSN Z7RZ03901 |
| 28 | 87651299 | 1 | HOSE, Air Cleaner to Turbo, ASN Z7RZ03901 |
| 29 | 214-1412 | 2 | CLAMP, HOSE, #12, 0.69/1.25 Type F Worm |
| 30 | 87341092 | 1 | PULLEY |
| 32 | 87366024 | 1 | V-BELT |
| 33 | 700-171 | 1 | CONNECTOR, HYD., 9/16″-18 ORFS x M10 x 1 ORB, Inc. 34 |
| 34 | 238-6011 | 1 | O-RING, -011, 90 Duro, .301″ ID x .070″ Thk |
| 37 | 87380498 | 1 | PULLEY |
| 38 | 87547253 | 1 | HOSE, Outlet |
| 39 | 86991153 | 1 | ADAPTER |
| 40 | 87403388 | 1 | CONDUIT |
| 41 | 214-3280 | 2 | CLAMP, HOSE, 4.25/5.125 HD Worm, W/liner |
| 42 | 86991000 | 2 | CLAMP, Tie, Dual |
| 47 | 87364042 | 1 | HOSE, Intake |
| 48 | 892-11008 | 4 | WASHER, LOCK, M8 |
| 49 | 87433913 | 1 | PLATE ASSY. |
| 50 | 87531675 | 1 | GASKET |
| 51 | 87456432 | 1 | PLUG |
| 52 | 92-11075 | 1 | WASHER, LOCK, 3/4″ |
| 53 | 933678R1 | 1 | NUT, Thin, M18 x 1.5, Cl 04 |
07-17 TRAILER BRAKES – PNEUMATIC, RESERVOIR, EXCEPT ITALY
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 1530988C1 | 2 | TANK, AIR |
| 2 | 86985993 | 2 | BRACKET |
| 3 | 844-12030 | 4 | BOLT, Hex Flg, M12 x 30, 8.8 |
| 4 | 87592916 | 4 | SPACER, Air Tank Mount |
| 5 | 814-10075 | 4 | BOLT, Hex, M10 x 75, 8.8 |
| 6 | 895-11010 | 4 | WASHER, M10 x 20 x 2 |
| 7 | 829-1410 | 4 | NUT, M10, Cl 10 |
| 8 | 86985963 | 1 | BRACKET, Right Hand |
| 9 | 86985965 | 1 | BRACKET, Left Hand |
| 10 | 443287A1 | 1 | VALVE |
| 11 | 716954R1 | 1 | PLUG, Hex, M22 x 1.5 |
| 12 | 3076154R1 | 3 | O-RING |
| 13 | 3076153R1 | 3 | RING, THRUST |
| 14 | 82001979 | 1 | VALVE, Silencer |
| 15 | 87391194 | 1 | SWITCH |
| 16 | 87680624 | 1 | REDUCER |
| 17 | 713845R1 | 1 | WASHER, SEALING, M12 x 15.5 x 1.5 |
| 18 | 82001015 | 1 | VALVE, CONTROL, Unloader |
| 19 | 844-8080 | 2 | BOLT, Hex Flg, M8 x 80, 8.8 |
| 20 | 87342627 | 1 | BRACKET |
| 21 | 844-12020 | 2 | BOLT, Hex Flg, M12 x 20, 8.8, Full Thd |
| 22 | 86991154 | 1 | HOSE, Unloader Valve Supply |
| 23 | 86984484 | 2 | CONNECTION |
| 24 | 86985957 | 1 | HOSE |
| 25 | 442930A1 | 1 | ELBOW |
| 26 | 442924A1 | 1 | CONNECTOR, HYD. |
| 27 | 86985952 | 1 | HOSE |
| 28 | 442929A1 | 1 | ELBOW |
| 29 | 86985955 | 1 | HOSE |
| 30 | 442925A1 | 1 | TEE |
| 31 | 214-1536 | 1 | CLAMP, HOSE, #36, 1.81/2.75 Type F Worm, W/liner |
| 32 | 897123H2 | 2 | VALVE |
| 33 | 86985951 | 1 | HOSE |
| 34 | 109619A1 | 2 | CLAMP |
| 35 | 384870A1 | 2 | PLATE |
| 36 | 384871A1 | 2 | PLATE |
| 37 | 814-8055 | 2 | BOLT, Hex, M8 x 55, 8.8 |
| 38 | 238-5117 | 1 | O-RING, -117, 70 Duro, .799″ ID x .103″ Thk |
07-18 TRAILER BRAKES – PNEUMATIC, RESERVOIR, ITALY ONLY
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 1530988C1 | 2 | TANK, AIR |
| 2 | 86985993 | 2 | BRACKET |
| 3 | 844-12030 | 4 | BOLT, Hex Flg, M12 x 30, 8.8 |
| 4 | 87592916 | 4 | SPACER, Air Tank Mount |
| 5 | 814-10075 | 4 | BOLT, Hex, M10 x 75, 8.8 |
| 6 | 895-11010 | 4 | WASHER, M10 x 20 x 2 |
| 7 | 829-1410 | 4 | NUT, M10, Cl 10 |
| 8 | 86985963 | 1 | BRACKET, Right Hand |
| 9 | 86985965 | 1 | BRACKET, Left Hand |
| 10 | 443287A1 | 1 | VALVE |
| 11 | 716954R1 | 1 | PLUG, Hex, M22 x 1.5 |
| 12 | 3076154R1 | 3 | O-RING |
| 13 | 3076153R1 | 3 | RING, THRUST |
| 14 | 82001979 | 1 | VALVE, Silencer |
| 15 | 87391194 | 1 | SWITCH |
| 16 | 87680624 | 1 | REDUCER |
| 17 | 713845R1 | 2 | WASHER, SEALING, M12 x 15.5 x 1.5 |
| 18 | T103977 | 1 | VALVE, PRESSURE RELIEF, Unloader |
| 19 | 844-8080 | 2 | BOLT, Hex Flg, M8 x 80, 8.8 |
| 20 | 87342627 | 1 | BRACKET |
| 21 | 844-12020 | 2 | BOLT, Hex Flg, M12 x 20, 8.8, Full Thd |
| 22 | 87456291 | 1 | HOSE, Unloader Valve Supply |
| 23 | 86984484 | 2 | CONNECTION |
| 24 | 87526409 | 1 | HOSE |
| 25 | 442930A1 | 1 | ELBOW |
| 26 | 442924A1 | 1 | CONNECTOR, HYD. |
| 27 | 87456293 | 1 | HOSE |
| 28 | 442929A1 | 1 | ELBOW |
| 29 | 87456294 | 1 | HOSE |
| 30 | 442925A1 | 1 | TEE |
| 31 | 214-1536 | 1 | CLAMP, HOSE, #36, 1.81/2.75 Type F Worm, W/liner |
| 32 | 897123H2 | 2 | VALVE |
| 33 | 933321R1 | 1 | PLUG, Hex, M12 x 1.5 |
| 34 | 87456290 | 1 | HOSE |
| 35 | 109619A1 | 2 | CLAMP |
| 36 | 384870A1 | 2 | PLATE |
| 37 | 384871A1 | 2 | PLATE |
| 38 | 814-8055 | 2 | BOLT, Hex, M8 x 55, 8.8 |
| 39 | 238-5117 | 1 | O-RING, -117, 70 Duro, .799″ ID x .103″ Thk |
07-19 TRAILER BRAKES – PNEUMATIC, VALVES
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 86987547 | 1 | BRACKET |
| 2 | 844-10025 | 2 | BOLT, Hex Flg, M10 x 25, 8.8, Full Thd |
| 3 | 224360A1 | 1 | VALVE |
| 4 | 844-8060 | 2 | BOLT, Hex Flg, M8 x 60, 8.8 |
| 5 | 3229351R1 | 1 | BALL JOINT |
| 6 | 825-2408 | 1 | NUT, M8 x 1.25, Flg, Cl 8 |
| 7 | 231532A1 | 1 | BALL JOINT |
| 8 | 3233348R1 | 1 | CLIP |
| 9 | 829-1408 | 1 | NUT, M8, Cl 10 |
| 10 | 86985983 | 1 | ROD |
| 11 | D136773 | 1 | BALL JOINT |
| 12 | 427-6200 | 1 | PIN, CLEVIS, 3/8″ x 2″ |
| 13 | 895-11010 | 2 | WASHER, M10 x 20 x 2 |
| 14 | 733-2520 | 1 | PIN, SPLIT (COTTER), M2.5 x 20 |
| 15 | 442928A1 | 2 | ELBOW |
| 16 | 86985944 | 1 | HOSE |
| 17 | 442926A1 | 1 | TEE |
| 18 | 86985943 | 1 | HOSE |
| 19 | 442925A1 | 1 | TEE |
| 20 | 515-23238 | 2 | CLAMP, 15/16″, Insul, 3/8″ Bolt |
| 21 | 844-8020 | 6 | BOLT, Hex Flg, M8 x 20, 8.8 |
| 22 | 86985946 | 1 | HOSE |
| 23 | 86987467 | 1 | TEE |
| 24 | 86987483 | 1 | HOSE |
| 25 | 86985947 | 1 | HOSE |
| 26 | 1531984C1 | 2 | VALVE, SOLENOID |
| 27 | 845-8095 | 2 | BOLT, Hex Flg, M8 x 95, 8.8 |
| 28 | 1531863C1 | 2 | SLEEVE |
| 29 | 3138533R1 | 2 | SLEEVE |
| 30 | 3138527R1 | 2 | NUT, Coupling, M12 x 1.5 |
| 31 | 327970A1 | 2 | PLUG |
| 32 | 442927A1 | 3 | ELBOW |
| 33 | 86985949 | 1 | HOSE |
| 34 | 86985948 | 1 | HOSE |
| 35 | 86984486 | 1 | ELBOW |
| 36 | 86985956 | 1 | HOSE |
| 37 | 86985945 | 1 | HOSE |
| 38 | 442929A1 | 1 | ELBOW |
| 39 | 325137A1 | 1 | VALVE |
| 40 | 844-8030 | 1 | BOLT, Hex Flg, M8 x 30, 8.8, Full Thd |
| 41 | 442922A1 | 1 | CONNECTOR, HYD. |
| 42 | 515-23159 | 1 | CLAMP, 5/8″, Insul, 3/8″ Bolt |
07-20 TRAILER BRAKES – PNEUMATIC, COUPLERS, EXCEPT ITALY
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | 4304140R91 | 1 | BREAKER POINTS, Red |
| 3 | 3401424R1 | 1 | BREAKER POINTS, Yellow |
| 4 | 442909A1 | 2 | CONNECTOR, HYD. |
| 6 | 87615022 | 1 | SUPPORT |
| 7 | 844-10030 | 2 | BOLT, Hex Flg, M10 x 30, 8.8, Full Thd |
| 13 | 87693059 | 1 | HOSE, Air Brake, Yellow |
| 18 | 442925A1 | 1 | TEE |
| 19 | 87693069 | 1 | HOSE, Air Brake, Red |
| 21 | 442929A1 | 1 | ELBOW |
| 22 | 515-22127 | 2 | CLAMP, 1/2″, Insul, 5/16″ Bolt |
| 23 | 844-8030 | 1 | BOLT, Hex Flg, M8 x 30, 8.8, Full Thd |
| 24 | 176492A1 | 1 | SPACER |
| 25 | 443761A1 | 1 | BRACKET |
| 26 | 844-10020 | 1 | BOLT, Hex Flg, M10 x 20, 8.8 |
| 27 | 87456290 | 1 | HOSE |
07-21 TRAILER BRAKES – PNEUMATIC, COUPLERS, ITALY ONLY
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 82016630 | 1 | COUPLING, PUSH-PULL |
| 2 | 844-10030 | 3 | BOLT, Hex Flg, M10 x 30, 8.8, Full Thd |
| 3 | 825-2410 | 3 | NUT, M10 x 1.5, Flg, Cl 8 |
| 4 | 87420709 | 1 | BRACKET |
| 5 | 614-12025 | 2 | BOLT, Hex, M12 x 25, 8.8 |
| 6 | 825-1020 | 2 | NUT, M20, Cl 8 |
| 7 | 87421630 | 1 | CONNECTION |
| 8 | 87664140 | 1 | HOSE |
| 9 | 87420660 | 1 | HOSE |
| 10 | 442925A1 | 1 | TEE |
| 11 | 515-22127 | 1 | CLAMP, 1/2″, Insul, 5/16″ Bolt |
| 12 | 844-8020 | 1 | BOLT, Hex Flg, M8 x 20, 8.8 |
| 13 | 443761A1 | 1 | BRACKET |
| 14 | 844-10020 | 1 | BOLT, Hex Flg, M10 x 20, 8.8 |
| 15 | 442929A1 | 1 | ELBOW |
| 16 | 87591541 | 1 | ELBOW |
08-01 HYDRAULIC SYSTEM – OIL COOLER STANDARD PERFORMANCE
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | 87358481 | 1 | HOSE ASSY., Oil Cooler Supply |
| 2 | 87456457 | 1 | SEAL |
| 3 | 238-6018 | 2 | O-RING, -018, 90 Duro, .739″ ID x .070″ Thk |
| 4 | 86017630 | 1 | PIN |
| 5 | 87332352 | 1 | BRACKET |
| 6 | 825-2408 | 9 | NUT, M8 x 1.25, Flg, Cl 8 |
| 7 | 814-8060 | 1 | BOLT, Hex, M8 x 60, 8.8 |
| 9 | 87355593 | 1 | PIPE, Oil Supply |
| 10 | 118576A1 | 2 | CLAMP |
| 11 | 87336914 | 1 | BRACKET, Oil Cooler Tubes |
| 12 | 87394076 | 1 | BRACKET |
| 13 | 555-1 | 1 | BOLT, Hex Flg, M8 x 16, 8.8 |
| 14 | 1347127C1 | 4 | PLATE |
| 15 | 844-8060 | 1 | BOLT, Hex Flg, M8 x 60, 8.8 |
| 16 | 87355596 | 1 | PIPE, Oil Return |
| 17 | 124668A1 | 1 | CLAMP |
| 18 | 87456576 | 1 | SEAL |
| 19 | 87592556 | 1 | TUBE ASSY., Hose, Oil Cooler Return |
| 20 | 832-10408 | 1 | NUT, LOCK, M8 x 1.25, Cl 8 |
| 21 | 87455275 | 1 | BRACKET, , BSN Z7RW05168 |
| 21 | 87603124 | 1 | BRACKET, , ASN Z7RW05168 |
| 22 | 87360031 | 1 | COOLER, OIL, Transmission (Shown), BSN Z7RZ04678 |
| 22 | 87549515 | 1 | COOLER, OIL, Transmission, ASN Z7RZ04678 |
| 23 | 87306467 | 1 | TUBE ASSY., Oil Cooler Return to Filter |
| 24 | 401600A1 | 1 | HEAD ASSY., Filter |
| 25 | 87427822 | 1 | VALVE, Priority |
| 26 | 87443859 | 1 | TUBE |
| 27 | J934178 | 1 | STUD |
| 28 | 895-25008 | 1 | WASHER, M8 x 20 x 1.6 |
| 29 | 825-5148 | 1 | NUT, M8, Flg Ser |