CASE Steiger 430 IH 4WD Tractor

      No Comments on CASE Steiger 430 IH 4WD Tractor

CASE Steiger 430 IH 4WD Tractor — parts list, part 2 of 5

Assemblies on this page: 05-01 STEERING WHEEL AND COLUMN … 06-59 POWER SHIFT TRANSMISSION – FIFTH SHAFT ASSEMBLY.

05-01 STEERING WHEEL AND COLUMN

Pos Part no. Qty Description
1 87387459 1 STEERING COLUMN, See Figure: 05-04
2 895-11010 9 WASHER, M10 x 20 x 2
3 829-1410 7 NUT, M10, Cl 10
4 1977448C2 1 WASHER, Support
5 220056A1 4 SCREW, Hex Soc Flat Hd, M10 x 20, 8.8
6 87448525 1 BRACKET, Mounting, Steering Column
7 87309685 1 BRACKET, Mounting, Column / Pump
8 614-10030 2 BOLT, Hex, M10 x 30, 8.8
9 87448446 1 PEDAL, w/ Steering Adjustment
10 829-1508 1 NUT, M8, Cl 10
11 514-633 1 BOLT, Hex, M8 x 30, 8.8, Full Thd
12 729-845 1 PIN, CLEVIS, M8 x 45
13 282892A1 2 BUSHING, Nylon
14 733-2012 1 PIN, SPLIT (COTTER), M2 x 12
15 311812A1 1 SPRING, Extension
16 323657A1 1 PAD, Foot Release Pedal
17 301200A1 1 WHEEL (STEERING), , Deluxe Cab
17 359033A1 1 SCREW, , Luxury Cab
18 896-11016 1 WASHER, M17.5 x 30 x 4, HT
19 825-11414 1 NUT, M14 x 1.5, Cl 8
20 361024A3 1 CAP, Medallion, Steering Wheel
21 86993721 1 CONTROL, Transmission, w/ Self Cancel, See Figure: 05-03, With Power Shift Transmission
22 414332A1 1 CONTROL, Transmission, w/ Self Cancel, See Figure: 05-02, With Manual Shift Transmission
23 253679A1 1 RING, Magnetic
24 87426127 1 STEERING HYDRAULIC, Control Valve, See Figure: 05-08

05-02 TRANSMISSION CONTROL ASSEMBLY, WITH MANUAL SHIFT TRANSMISSION

Pos Part no. Qty Description
1 325362A1 1 CHASSIS, Transmission Control
3 284777A1 1 SWITCH, Turn Signal, With Self Cancel
4 325068A1 1 BELLOWS
5 414330A1 1 DECAL, Plate, FNRP
6 840-1410 7 SCREW, Cross Pan Hd, M4 x 10
8 303466A1 1 SYMBOLS, RH Turn Signal
9 303467A1 1 SYMBOLS, LH Turn Signal
10 892-11004 7 WASHER, LOCK, M4
11 905974R1 2 SCREW, SELF TAPPING, Pan Hd, M2.9 x 13
12 303465A2 1 LAMP, Flasher

05-03 TRANSMISSION CONTROL ASSEMBLY, WITH POWER SHIFT TRANSMISSION

Pos Part no. Qty Description
1 325362A1 1 CHASSIS, Transmission Control
2 325065A1 1 HOUSING, Lower
3 284777A1 1 SWITCH, Turn Signal, With Self Cancel
4 22-824 1 STRAP, CABLE, 3/16″ x 7 1/4″
5 447256A2 1 SWITCH, FNRP
6 840-1410 7 SCREW, Cross Pan Hd, M4 x 10
7 325064A1 1 HOUSING, Upper
8 303466A1 1 SYMBOLS, RH
9 303467A1 1 SYMBOLS, LH
10 892-11004 7 WASHER, LOCK, M4
11 325363A1 1 LEVER, FNRP
12 250939A1 1 SPRING
13 325068A1 1 BELLOWS
14 325066A2 1 GUARD
15 303465A2 1 LAMP, Flasher
16 392699A1 1 FASTENER
17 325533A1 1 HANDLE, FNRP
18 905974R1 2 SCREW, SELF TAPPING, Pan Hd, M2.9 x 13
19 358353A1 1 SYMBOLS, FNRP

05-05 HYDRAULICS – STEERING

Pos Part no. Qty Description
1 87426127 1 STEERING HYDRAULIC, Orbital, Steering Control, See Figure: 05-08
2 700-446 6 ELBOW, 45є, 11/16″-18 ORFS x M18 x 1.5 ORB, Inc. 3 & 4
3 637-64236 6 O-RING, Cl 6, 23.6MM ID x 2.9 Thk
4 238-6012 6 O-RING, -012, 90 Duro, .364″ ID x .070″ Thk
5 87312091 1 TUBE, Port ‘P’, Steering Orbital to Priority Valve
6 87312093 1 TUBE, Port ‘T’, Steering Orbital to Priority Valve
7 87312089 1 TUBE, Port ‘L’, Steering Orbital to Priority Valve
8 87312087 1 TUBE, Port ‘R’, Steering Orbital to Priority Valve
9 87312095 2 HOSE, 838 mm (33″), Steering Orbital to Priority Valve
10 87312096 1 HOSE, 785 mm (31″), Steering Orbital to Priority Valve
11 87347856 1 BRACKET, Tube Holder
12 895-11008 27 WASHER, M8 x 16 x 1.6
13 832-10408 14 NUT, LOCK, M8 x 1.25, Cl 8
14 627-8025 6 BOLT, Hex, M8 x 25, 10.9
15 87403324 1 BRACKET, SUPPORTING, Tube Mounting
16 87436024 1 MOUNTING PARTS, Plate, Steering Control Tubes
17 827-8060 2 BOLT, Hex, M8 x 60, 10.9
18 87439775 1 TUBE ASSY., Return, to Hydraulic Tank
19 1-4571 1 HOSE, 38 mm (1-1/2 in), to Hydraulic Tank
20 214-1436 2 CLAMP, HOSE, #36, 1.81/2.75 Type F Worm
21 238-6016 2 O-RING, -016, 90 Duro, .614″ ID x .070″ Thk
22 238-6014 1 O-RING, -014, 90 Duro, .489″ ID x .070″ Thk
23 700-102 1 CONNECTOR, HYD., 13/16″-16 ORFS x M18 x 1.5 ORB, Inc. 24 & 25
24 637-63153 1 O-RING, Cl 6, 15.3MM ID x 2.2 Thk
25 238-6014 1 O-RING, -014, 90 Duro, .489″ ID x .070″ Thk
26 700-305 4 ELBOW, 90є, 13/16″-18 ORFS x M18 x 1.5 ORB, Inc. 24 & 25
27 700-106 2 CONNECTOR, HYD., 11/16″-16 ORFS x M18 x 1.5 ORB, Inc. 3 & 4
28 87304378 1 BRACKET, Mounting, Steering Control Hoses
29 896-11012 3 WASHER, M13.5 x 24.5 x 3, HT
30 829-1412 3 NUT, M12, Cl 10
31 515-25508 1 CLAMP, 2″, Insul, 1/2″ Bolt
32 627-12025 1 BOLT, Hex, M12 x 25, 10.9
33 87304379 1 HOSE ASSY.
34 87439175 1 HOSE ASSY., 1257 mm (49-1/2″)
35 242563A1 1 CLAMP
36 892-11012 1 WASHER, LOCK, M12
37 364967A1 1 TEE, M18 or x 12 fc sl, Inc. 38 & 39
38 637-63153 1 O-RING, Cl 6, 15.3MM ID x 2.2 Thk
39 238-6014 1 O-RING, -014, 90 Duro, .489″ ID x .070″ Thk
40 178889A1 1 FITTING, Diagonstic, Inc. 41 – 43
41 H434163 1 DUST CAP, Dust
43 637-63113 1 O-RING, Cl 6, 11.3MM ID x 2.2 Thk
44 701-423 2 TEE, 13/16″-16 ORFS, Blkd Run, Inc. 39
45 701-903 2 NUT, LOCK, 13/16″-16, ORFS Blkhd
46 87439172 1 HOSE ASSY., 991 mm (39″), Articulation Cylinder to Priority Valve
47 87312871 1 HOSE, 1170 mm (45″), Articulation Cylinder to Priority Valve
48 367243A1 1 HOSE ASSY., 1605 mm (63″), Articulation Cylinder to Priority Valve
49 515-23286 1 CLAMP, 1 1/8″, Insul, 3/8″ Bolt
50 895-15008 2 WASHER, M8 x 20 x 1.6
51 829-1408 2 NUT, M8, Cl 10
52 367244A1 1 HOSE, 550 mm (21-1/2″), Articulation Cylinder to Priority Valve
53 50-2551T1 4 CLAMP
54 50-2533T1 4 PLATE, Cover
55 827-8070 2 BOLT, Hex, M8 x 70, 10.9
56 70-6085T2 2 PIN, 9-1/4″
57 496-21066 4 WASHER, 21/32″ x 1 5/16″ x .150″
58 627-16040 4 BOLT, Hex, M16 x 40, 10.9
59 70-5967T1 4 SPACER
60 406999A1 2 CYLINDER STEERING, Articulation, without Sensor, See Figure: 05-06
61 87312097 1 HOSE, 892 mm (35″), Steering Orbital to Priority Valve
62 87442925 1 VALVE, CONTROL, Priority / EHPS, See Figure: 08-15, BSN Z7F105376
62 87585897 1 VALVE, HYDRAULIC, Priority / EHPS. See Figure: 08-15, ASN Z7F105376
63 515-23206 6 CLAMP, 13/16″, Insul, 3/8″ Bolt
64 87438129 1 BRACKET, SUPPORTING, EHPS / Priority Valve, BSN Z7F105578
64 87550230 1 BRACKET, EHPS / Priority Valve, ASN Z7F105578
65 627-8020 3 BOLT, Hex, M8 x 20, 10.9, , Used on Power Shift Models
65 627-8016 3 BOLT, Hex, M8 x 16, 10.9, , Used with Manual Shift Transmission
66 895-11010 2 WASHER, M10 x 20 x 2
67 829-1410 2 NUT, M10, Cl 10

05-06 CYLINDER ASSEMBLY – ARTICULATION

Pos Part no. Qty Description
1 409685A1 2 JOINT
2 D95143 8 SEAL
3 70-6013T2 2 PIN
4 70-5967T1 2 SPACER
5 627-16035 2 BOLT, Hex, M16 x 35, 10.9
6 896-11016 2 WASHER, M17.5 x 30 x 4, HT
7 86637724 2 PLUG, Hex Soc, 1/8″-27 NPTF
8 219-36 1 NIPPLE, LUBE, 45є, 1/8″ NPT x 7/8″ lg
9 217-1014 1 ELBOW, 90є, 1/8″-27 Female x 1/8″-27 Male
10 F53473 1 NUT
11 86636814 1 NIPPLE, LUBE, 1/4″-28 x .52″ lg
12 1339090C1 1 HOSE, 838 mm (33″)
13 387651A1 1 JACK BODY, Barrel
14 387652A1 1 CAP CYLINDER END
19 387650A1 1 ROD, PISTON
20 387648A1 1 PISTON
21 232-46320 1 NUT, LOCK, 1 1/4″-12, GC

05-07 ARTICULATION LOCKS

Pos Part no. Qty Description
1 403824A2 1 LOCK, Articulation, QUADTRAC & Scraper Tractor
1 403820A2 1 LOCK, Articulation, with Stops, STX Wheel Tractor
1 403817A2 1 LOCK, Articulation, without Stops, STX Wheel Tractor
2 440518A1 1 DECAL, Locking Block
3 427-8325 1 PIN, CLEVIS, 1/2″ x 3 1/4″
4 435425A1 1 PIN, Hair
5 403822A1 4 STOP, Articulation
6 214-1464 2 CLAMP, HOSE, #64, 3.56/4.50 Type F Worm, 3-9/16 – 4-1/2 in dia
7 321323A1 2 ADAPTER, Bushing
8 896-15012 1 WASHER, M12 x 28.5 x 4, HT
9 406390A1 1 HANDLE, Mounting, Articulation Lock

05-08 STEERING CONTROL VALVE

Pos Part no. Qty Description
1 87426127 1 STEERING HYDRAULIC, Control Orbital, Inc. 2 – 22
23 87345879 1 KIT, Steering Valve Seal, Inc. 6, 9, 15, & 19

05-09 ACCUGUIDE – HYDRAULIC, STEERING

Pos Part no. Qty Description
1 87426127 1 STEERING HYDRAULIC, Orbital Steering Control, See Figure: 05-08
2 700-446 1 ELBOW, 45є, 11/16″-18 ORFS x M18 x 1.5 ORB, Inc. 3 & 4
3 637-64236 6 O-RING, Cl 6, 23.6MM ID x 2.9 Thk
4 238-6012 6 O-RING, -012, 90 Duro, .364″ ID x .070″ Thk
5 87312091 1 TUBE, Port ‘P’, Steering Orbital to Priority Valve
6 87347199 1 HOSE, Steering Orbital to Priority Valve
7 87452749 1 SWITCH, PRESSURE, In-Line Flow
8 87347197 1 HOSE, 160 mm (6-1/4″), Adapter
9 700-106 1 CONNECTOR, HYD., 11/16″-16 ORFS x M18 x 1.5 ORB, Inc. 3 & 4
10 87436468 1 VALVE, CONTROL, Priority, See Figure: 08-15, BSN Z7F105376
10 87585898 1 VALVE, HYDRAULIC, Priority, See Figure: 08-15, ASN Z7F105376
11 700-305 4 ELBOW, 90є, 13/16″-18 ORFS x M18 x 1.5 ORB, Inc. 12 & 13
12 637-63153 1 O-RING, Cl 6, 15.3MM ID x 2.2 Thk
13 238-6014 1 O-RING, -014, 90 Duro, .489″ ID x .070″ Thk
14 87439175 1 HOSE ASSY., 1257 mm (49-1/2″), Priority Valve to Articulation Cylinder
15 701-423 2 TEE, 13/16″-16 ORFS, Blkd Run, Inc. 13
16 50-2551T1 4 CLAMP
17 701-903 2 NUT, LOCK, 13/16″-16, ORFS Blkhd
18 87439172 1 HOSE ASSY., 991 mm (39″), Priority Valve to Articulation Cylinder
19 700-102 1 CONNECTOR, HYD., 13/16″-16 ORFS x M18 x 1.5 ORB, Inc. 12 & 13
20 87304379 1 HOSE ASSY., 1308 mm (51-1/2″), Priority Valve to Articulation Cylinder
21 367244A1 1 HOSE, 550 mm (21-1/2″), Priority Valve to Articulation Cylinder
22 367243A1 1 HOSE ASSY., 1605 mm (63″), Priority Valve to Articulation Cylinder
23 87312871 1 HOSE, 1170 mm (46″), Priority Valve to Articulation Cylinder
24 242563A1 1 CLAMP
25 892-11012 1 WASHER, LOCK, M12
26 829-1412 3 NUT, M12, Cl 10
27 50-2533T1 4 PLATE, Cover
28 827-8070 2 BOLT, Hex, M8 x 70, 10.9
29 895-11008 4 WASHER, M8 x 16 x 1.6
30 832-10408 2 NUT, LOCK, M8 x 1.25, Cl 8
31 87529571 1 CYLINDER STEERING, Steering Articulation, with Sensor, See Figure: 05-10, BSN Z7F105338
31 87552147 1 CYLINDER STEERING, Articulation, with Sensor, See Figure: 05-10 (01), ASN Z7F105338
32 406999A1 1 CYLINDER STEERING, Articulation, without Sensor, See Figure: 05-06
33 70-6085T2 2 PIN, 9-1/2″
34 627-16040 4 BOLT, Hex, M16 x 40, 10.9
35 496-21066 4 WASHER, 21/32″ x 1 5/16″ x .150″
36 70-5967T1 4 SPACER
37 515-23206 1 CLAMP, 13/16″, Insul, 3/8″ Bolt
38 364967A1 1 TEE, M18 or x 12 fc sl, Inc. 12 & 13
39 178889A1 1 FITTING, Diagnostic, Inc. 40 – 42
40 H434163 1 DUST CAP, Dust
42 637-63113 1 O-RING, Cl 6, 11.3MM ID x 2.2 Thk

05-10(01) ACCUGUIDE – CYLINDER ASSY., ARTICULATION W/ SENSOR, ASN Z7F105338

Pos Part no. Qty Description
1 87397776 1 CASE, Barrel
2 87552145 1 SENSOR, Rod, Rear Articlation
6 87397773 1 PISTON
8 87397775 1 SHAFT
11 87397774 1 HEAD
18 87397843 1 MAGNET
19 87397844 2 SPACER
20 87532453 1 RING, SNAP, Retaining
21 70-6013T2 2 PIN
22 87397777 1 KIT, SEALS, Inc. 3 – 5, 7, 9, 10, 12 – 14
23 70-5967T1 2 SPACER
24 896-11016 2 WASHER, M17.5 x 30 x 4, HT
25 627-16035 2 BOLT, Hex, M16 x 35, 10.9
26 217-429 2 PLUG, Hex Soc, 1/8″-27 NPTF, Socketless Pipe
27 219-36 1 NIPPLE, LUBE, 45є, 1/8″ NPT x 7/8″ lg
28 217-1014 1 ELBOW, 90є, 1/8″-27 Female x 1/8″-27 Male
29 1339090C1 1 HOSE, Grease
30 F53473 1 NUT
31 276426A1 1 CONNECTOR, ELEC, 4 Pin Socket
32 280448A1 1 LOCK, STOP, Wedge, Connector
33 219-20 1 NIPPLE, LUBE, 1/4″-28 x .52″ lg
34 409685A1 2 JOINT, Knuckle
35 D95143 8 SEAL, Wiper, Rod
36 87552166 1 SEAL, Connector, Rubber Boot

06-01 TRANSMISSION SHIFTER AND THROTTLE CONTROL

Pos Part no. Qty Description
1 258010A2 1 SWITCH, Up / Down Transmission Gear Shift, With Power Shift Transmission
1 428314A1 1 SWITCH, Hi / Low Transmission Shift, With Manual Shift Transmission
2 235676A1 2 CONNECTOR
3 22-824 2 STRAP, CABLE, 3/16″ x 7 1/4″
4 367607A1 1 BRACKET, Throttle / Tranmission Shifter
5 87622401 1 GRIP, Switch Face
6 388706A1 1 PUSH BUTTON, Select-Shift, With Power Shift Transmission
7 293388A2 1 GRIP, Throttle, Vinyl, With Manual Shift Transmission
7 388705A1 1 GRIP, Throttle, Vinyl, With Power Shift Transmission
7 388864A1 1 GRIP, Throttle, Leather, With Power Shift Transmission

06-02 TRANSMISSION SHIFT CONTROLS, MANUAL SHIFT TRANSMISSION

Pos Part no. Qty Description
2 396435A2 1 SUPPORT
3 396444A1 1 CRANK, Linkage Pivot
4 396445A1 1 CRANK, Linkage Pivot
5 396446A1 1 CRANK, Linkage Pivot
6 396447A1 1 CRANK, Linkage Pivot
7 402749A1 8 BALL JOINT, Female – RH
8 431198A1 4 ROD
9 627-10030 4 BOLT, Hex, M10 x 30, 10.9, Full Thd
10 403749A1 4 NUT, M10
11 431052A1 6 BUSHING
12 398870A1 2 BUSHING
13 829-1410 4 NUT, M10, Cl 10
14 412355A1 1 BELLOWS
15 430415A1 1 PIN ASSY.
16 430546A1 1 SPACER
17 895-25006 1 WASHER, M6 x 18 x 1.6
18 627-6020 1 BOLT, Hex, M6 x 20, 10.9
25 402749A1 1 BALL JOINT, Female – RH
26 404639A1 1 BALL JOINT, Female – LH
27 627-10030 9 BOLT, Hex, M10 x 30, 10.9, Full Thd
28 403749A1 13 NUT, M10; 8
29 627-10035 4 BOLT, Hex, M10 x 35, 10.9, Full Thd
30 895-15008 5 WASHER, M8 x 20 x 1.6
31 627-8030 5 BOLT, Hex, M8 x 30, 10.9
32 408566A1 3 INSERT
33 895-25006 2 WASHER, M6 x 18 x 1.6
34 614-6020 2 BOLT, Hex, M6 x 20, 8.8
35 404287A1 2 INSERT
36 430415A1 1 PIN ASSY.
37 627-6020 1 BOLT, Hex, M6 x 20, 10.9
38 430546A1 1 SPACER
39 410846A4 1 SHROUD
40 412354A2 2 BELLOWS, Rubber Boot
41 418038A1 1 GRIP, Gear Shifter
42 418039A1 1 GRIP, Range Shifter
43 871-5012 2 SCREW, Hex Soc Flat Hd, M5 x 12, 10.9
44 369929A1 2 FASTENER, Christmas Tree
45 449068A1 2 STUD
46 829-1408 2 NUT, M8, Cl 10
47 357564A1 2 FASTENER, Velcro

06-03 SHIFTING UNIT ASSEMBLY, WITH MANUAL SHIFT TRANSMISSION

Pos Part no. Qty Description
1 404630A3 1 PANEL, SIDE, Mounting, LH
2 404632A3 1 PANEL, SIDE, Mounting, Center LH
3 404633A3 1 PANEL, SIDE, Mounting, Center RH
4 404631A3 1 PANEL, SIDE, Mounting, RH
5 627-8030 2 BOLT, Hex, M8 x 30, 10.9
6 543-704 4 SCREW, Hex Flat Hd, M6 x 12, 4.8
7 430841A1 1 PIN ASSY.
8 409795A2 2 CLIP, SPRING
9 404635A1 2 SPACER
10 829-1406 6 NUT, M6, Cl 10
11 614-6020 2 BOLT, Hex, M6 x 20, 8.8
12 409796A2 2 CLIP, SPRING
13 404634A1 2 SPACER
14 827-8110 2 BOLT, Hex, M8 x 110, 10.9
15 800-1112 1 RING, SNAP, M12, Ext
16 409790A4 1 LEVER ASSY., Gear Shifter
17 409793A3 1 LEVER ASSY., Range Shifter
18 404644A2 2 LEVER ASSY., Shift, LH
19 419660A2 2 LEVER, Shift, RH
20 614-6016 16 BOLT, Hex, M6 x 16, 8.8
21 398870A1 4 BUSHING
22 895-18012 2 WASHER, M12 x 20 x 2
23 419737A1 4 GUIDE
24 419597A2 2 LINKAGE
25 431052A1 8 BUSHING
26 827-6060 4 BOLT, Hex, M6 x 60, 10.9
27 827-8090 2 BOLT, Hex, M8 x 90, 10.9
28 832-10408 2 NUT, LOCK, M8 x 1.25, Cl 8
29 409797A1 2 TORSION SPRING
30 396431A1 2 TUBE, Mounting, Square
31 832-10406 4 NUT, LOCK, M6 x 1, Cl 8
32 87426775 1 BRACKET, Mounting, Shifter Shroud

06-04 CLUTCH PEDAL, MANUAL SHIFT TRANSMISSION

Pos Part no. Qty Description
1 222462A2 1 PEDAL, Clutch
2 281093A1 2 WASHER
3 435476A1 1 CABLE
4 800-1125 1 RING, SNAP, M25, Ext
5 278210A1 1 SPRING
6 397144A1 1 CLEVIS
7 427-6081 1 PIN, CLEVIS, 3/8″ x 11/16″
8 432-612 1 PIN, SPLIT (COTTER), 3/32″ x 3/4″
9 425-155 3 NUT, Jam, 5/16″-24, G5
10 248-2376 1 GROMMET, 5/8″ ID x 1 1/4″ Groove Dia, Str Cut
11 19-885 1 NUT
12 458-412 2 BOLT, Hex Flg, 1/4″-20 x 3/4″, G5, Full Thd
13 90-8048T1 1 FLANGE
14 829-1408 2 NUT, M8, Cl 10
15 627-8035 1 BOLT, Hex, M8 x 35, 10.9
16 417927A1 1 SWITCH, Plunger
17 281893A1 1 BEARING
18 614-10025 2 BOLT, Hex, M10 x 25, 8.8, Full Thd
19 321961A1 2 MOLDING
20 370247A3 1 SUPPORT, Tube, Clutch / Brake Pedal
21 90-8047T1 1 SLEEVE
22 32-212 2 PIN, SPLIT (COTTER), 1/32″ x 3/4″
23 60-6241T1 1 END, Cable
24 19-6041 1 PIN
25 437369A1 1 BRACKET, Mounting, Clamp
26 R43926 1 CLAMP
27 627-8025 1 BOLT, Hex, M8 x 25, 10.9
28 895-11008 1 WASHER, M8 x 16 x 1.6
29 353-422 1 PLUG, Dome, 1.250″ hole, Nylon, Clutch, Cable Clearance Hole

06-05 CLUTCH PEDAL, POWER SHIFT TRANSMISSION

Pos Part no. Qty Description
1 222462A2 1 PEDAL, Clutch
2 281093A1 2 WASHER
3 87448885 1 SUPPORT, Tube, Clutch / Brake Pedal
4 627-10020 1 BOLT, Hex, M10 x 20, 10.9, Full Thd
5 278210A1 1 SPRING
6 353-422 1 PLUG, Dome, 1.250″ hole, Nylon
7 283659A1 1 SENSOR, Clutch Position
8 305155A2 1 BUSHING
9 840-1530 2 SCREW, Cross Pan Hd, M5 x 30
10 322409A1 1 PIN
11 222463A2 1 LINK
12 60-2404T1 2 RETAINER, Clip
13 800-1110 1 RING, SNAP, M10, Ext, M10
14 829-1408 1 NUT, M8, Cl 10
15 614-8035 1 BOLT, Hex, M8 x 35, 8.8
16 355341A1 1 SWITCH, Plunger
17 281893A1 1 BEARING
18 614-10025 2 BOLT, Hex, M10 x 25, 8.8, Full Thd
19 321961A1 2 MOLDING

06-06 WHEELS SINGLE AND DUALS WITH SPACERS

Pos Part no. Qty Description
3 87312787 4 WHEEL, 32 x DWM44, For Tires: 76 x 50-32, Scraper Application, Used with Single Wheel Dual Hub
4 405822A1 1 SPACER, 127 mm (5 in)
5 405823A1 1 SPACER, 254 mm (10 in)
6 405824A1 1 SPACER, 330 mm (13 in)
7 827-22160 10 BOLT, Hex, M22 x 150, 10.9
8 827-22080 40 BOLT, Hex, M22 x 80, 10.9, Full Thd
9 827-22130 10 BOLT, Hex, M22 x 130, 10.9
10 896-11022 40 WASHER, M22 x 44 x 4, HT
12 627-16050 64 BOLT, Hex, M16 x 50, 10.9, , Scraper Application, Used with Single Wheel Dual Hub Application
13 896-11016 64 WASHER, M17.5 x 30 x 4, HT, , Scraper Application, Used with Single Wheel Dual Hub Application
14 87380382 1 RING, Side, with Driver Pocket, 32″ x 1″
15 87380372 1 KEY, Driver
16 87380409 1 RING, Locking, 32″ x 31″ Type VA5
17 87380429 1 DISC, Hub Mounting, FC .375″ x 24.625″ OD / 10 Holes

06-07 WHEELS TRIPLES WITH SPACERS

Pos Part no. Qty Description
1 396113A1 12 RIM, W16A x 46, For Tires: 850/55-42, 900/50R42
1 193857A1 12 WHEEL, W18A x 42, For Tires: 520/85R42, 20.8R42
2 409987A1 1 SPACER, 711 mm (28″)
3 496-31094 10 WASHER, 15/16″ x 1 3/4″ x .219″, HDN
4 827-22140 10 BOLT, Hex, M22 x 140, 10.9
6 827-22080 40 BOLT, Hex, M22 x 80, 10.9, Full Thd

06-08 HUB ASSEMBLY MOUNTING

Pos Part no. Qty Description
1 405812A1 1 HUB
3 396-31081 6 WASHER, 13/16″ x 1 1/2″ x .219″, HDN
4 228273A1 6 BOLT, M20 x 110; 10,9
5 303401A1 3 PLUG
6 38-11608 4 PIN, LOCK, 1/4″ x 1/2″, Slotted
7 A63219 4 KEY, 3/4″ x 6″
8 896-11022 40 WASHER, M22 x 44 x 4, HT
9 827-22080 40 BOLT, Hex, M22 x 80, 10.9, Full Thd

06-09 TRACKS, QUADTRAC TRACTOR

Pos Part no. Qty Description
1 87734601 4 RUBBER TRACK, 762 mm (30″), Scraper Application
1 437739A1 4 RUBBER TRACK, 762 mm (30″), Arctic QUADTRAC Tractor Application
1 87403790 4 RUBBER TRACK, 762 mm (30″)
1 87734600 4 RUBBER TRACK, 914 mm (36″)
1 87395014 4 RUBBER TRACK, 762 mm (30″), Europe Option

06-10 YOKE MOUNTING, QUADTRAC TRACTOR

Pos Part no. Qty Description
1 87423303 1 YOKE, Inc. 2, See Figure 06-79
2 837-16040 2 DOWEL, M16 x 40
3 896-12016 24 WASHER, M17.5 x 30 x 4, HT
4 828-16150 24 BOLT, Hex, M16 x 150, 10.9
5 87451761 2 PLATE, END, Yoke
6 896-11024 6 WASHER, M24 x 44.5 x 5, HT
7 9780129 6 BOLT, Hex, M24 x 50, 10.9, Full Thd
8 87439071 1 BOLT, M20 x 130, CL10.9
9 896-15020 4 WASHER, M20 x 44.5 x 5, HT
10 87439070 1 SPACER
11 829-4420 1 NUT, Thin, M20 x 2.5, Cl 05
12 87447339 6 SPACER
13 827-24130 4 BOLT, Hex, M24 x 130, 10.9
14 827-24190 2 BOLT, Hex, M24 x 190, 10.9
15 87425780 1 WEDGE, Block
16 496-41034 1 WASHER, .344″ x 1″ x .098″, HDN
17 627-8100 1 BOLT, Hex, M8 x 100, 10.9, Full Thd
18 87439068 1 PLATE, Scraper, Used on QUADTRAC Scraper Application
19 87439069 2 BAR, Retention
20 827-20080 2 BOLT, Hex, M20 x 80, 10.9
21 87428948 2 BUMPER, Rubber
22 896-11012 4 WASHER, M13.5 x 24.5 x 3, HT
23 86836488 4 SCREW, Hex Soc But Hd, M12 x 1.75 x 25, 12.9
24 87423822 2 PIN
25 87423819 2 SPACER
26 896-11016 2 WASHER, M17.5 x 30 x 4, HT
27 627-16035 2 BOLT, Hex, M16 x 35, 10.9
28 87423202 2 BEARING, Thrust

06-11 UNDERCARRIAGE – MOUNTING, QUADTRAC TRACTOR

Pos Part no. Qty Description
1 87326383 1 MOUNTING PARTS, Undercarriage
2 389761A1 1 SUSPENSION, Rear, Rubber Mount
3 389763A1 1 SUSPENSION, Front, Rubber Mount
4 87438307 6 WHEEL ASSY, Roller
5 231765A1 6 U-BOLT
6 832-46416 12 NUT, LOCK, M16 x 2, Cl 8
7 896-11016 22 WASHER, M17.5 x 30 x 4, HT
11 87441100 1 WHEEL ASSY, Idler, Bolt-on
12 627-16050 9 BOLT, Hex, M16 x 50, 10.9
13 827-16180 2 BOLT, Hex, M16 x 180, 10.9
14 87423203 4 SEAL
15 87423204 2 BEARING ASSY
16 896-11024 22 WASHER, M24 x 44.5 x 5, HT
17 827-24080 20 BOLT, Hex, M24 x 80, 10.9, Full Thd
18 827-20200 1 BOLT, Hex, M20 x 200, 10.9
19 832-46420 1 NUT, LOCK, M20 x 2.5, Cl 8
20 827-22140 2 BOLT, Hex, M22 x 140, 10.9
21 87304299 1 HYDRAULIC CYLINDER, Track Tensioning
22 255729A1 1 SPRING, Track Tensioning
23 627-16040 8 BOLT, Hex, M16 x 40, 10.9
24 827-16140 2 BOLT, Hex, M16 x 140, 10.9
25 408786A1 1 BEAM, Roller Wheel
26 435507A1 1 LINKAGE, Track Tensioning
27 827-16110 2 BOLT, Hex, M16 x 110, 10.9
28 896-11022 2 WASHER, M22 x 44 x 4, HT
29 87324220 2 SHAFT, IDLE, Pivot
30 430710A1 1 PAD
31 827-24100 2 BOLT, Hex, M24 x 100, 10.9
32 87585083 2 TUBE SPACER
33 87377667 1 KIT, SEALS, Track Tensioning Cylinder

06-12 AXLE ASSEMBLY – FRONT IDLER, QUADTRAC TRACTOR

Pos Part no. Qty Description
1 87681164 1 PIVOT, Shaft Assy., Inc. 2 & 3
1 87345926 1 Shaft Assy., Inc. 2 & 3, Arctic QUADTRAC Tractor Application
4 87416606 1 HUB, Front Idler
4 379708A3 1 HUB, Front Idler, Arctic QUADTRAC Tractor Application
5 87437010 2 SEAL, Face
5 87427009 2 SEAL, SHAFT, Multiple Lip, Arctic QUADTRAC Tractor Application
6 87387720 2 RETAINER
7 87449801 2 BOLT, M20 x 40, 10.9
8 87408174 2 CAP, , Also Order 246406A1 Plug
9 800-21130 2 RING, SNAP, M130, Int
10 87038806 2 RING, SNAP, M38, Int
11 329647A1 1 PIN
12 238-5426 2 O-RING, -426, 70 Duro, 4.600″ ID x .275″ Thk
13 87416602 2 COVER, Cap
14 87324810 2 BEARING
15 87451047 2 SEAL
16 246406A1 2 PLUG, M12 x 1.5, ORB, Inc. 17
17 637-63093 2 O-RING, Cl 6, 9.3MM ID x 2.2 Thk
18 87441100 1 WHEEL ASSY, Bolt-on
20 371884A1 4 CONE
21 371878A1 4 CUP

06-13 AXLE ASSEMBLY – REAR IDLER, QUADTRAC TRACTOR

Pos Part no. Qty Description
1 87451058 1 SHAFT, Assy., Rear Idler
2 87304016 2 CUP
3 238-5426 2 O-RING, -426, 70 Duro, 4.600″ ID x .275″ Thk
4 371884A1 4 CONE
5 371878A1 4 CUP
6 87416606 1 HUB, Rear Idler
6 379708A3 1 HUB, Rear Idler, Arctic QUADTRAC Tractor Application
7 87387720 2 RETAINER
8 87449801 2 BOLT, M20 x 40, 10.9
9 87408174 2 CAP, , Also Order 246406A1 Plug
10 800-21130 2 RING, SNAP, M130, Int
11 87437010 2 SEAL, Face
12 246406A1 2 PLUG, M12 x 1.5, ORB, Inc. 13
13 637-63093 2 O-RING, Cl 6, 9.3MM ID x 2.2 Thk
14 87441100 1 WHEEL ASSY, Rear Idler, Bolt-on

06-14 AXLE ASSEMBLY – ROLLER SHAFT

Pos Part no. Qty Description
1 87431253 3 SHAFT, ROLLER, Assy.
2 87304018 2 CUP, Roller
3 246406A1 6 PLUG, M12 x 1.5, ORB, Inc. 4
4 637-63093 1 O-RING, Cl 6, 9.3MM ID x 2.2 Thk
5 87437009 6 SEAL, Roller Face
5 87427008 6 SEAL, Multiple Lip, Arctic QUADTRAC Tractor Application
6 87438307 2 WHEEL ASSY, Roller
6 87746541 2 WHEEL, Rooler, Arctic QUADTRAC Tractor Application
7 A61447 12 BEARING, CONE, 2-1/16″ ID
8 625743C1 12 BEARING, CUP, Cup, 3-35/64″ OD
9 87387720 6 RETAINER, Hardened
10 87449801 6 BOLT, M20 x 40, CL10.9
11 86984140 6 SEAL, O-Ring
12 800-21110 6 RING, SNAP, M110, Int, Retaining
13 87404689 6 CAP, Wheel, Also Order 246406A1 Plug

06-15 DRIVE WHEEL, QUADTRAC TRACTOR

Pos Part no. Qty Description
1 87498856 4 WHEEL, Cast
2 896-11024 40 WASHER, M24 x 44.5 x 5, HT
3 627-24070 40 BOLT, Hex, M24 x 70, 10.9, Full Thd

06-16 TRACK TENSIONING, QUADTRAC TRACTOR

Pos Part no. Qty Description
1 87306552 8 BRACKET, Mounting, Track Tension Hose
2 87306678 2 TEE, 11/16″-16 ORFS, Blkhd Br, Inc. 3
3 238-6012 3 O-RING, -012, 90 Duro, .364″ ID x .070″ Thk
4 701-909 2 NUT, LOCK, 11/16″-16, Blkhd
5 829-1408 6 NUT, M8, Cl 10
6 515-23127 16 CLAMP, 1/2″, Insul, 3/8″ Bolt
8 627-8020 16 BOLT, Hex, M8 x 20, 10.9
7 895-11008 18 WASHER, M8 x 16 x 1.6
9 87306548 1 HOSE ASSY., 1836 mm (72-9/32″), Track Tensioning
9 444422A1S 1 HOSE ASSY., 1816 mm (71-1/2″), Track Tensioning, Arctic QUADTRAC Tractor Application
10 87306549 2 HOSE ASSY., 1956mm (77″), Track Tensioning
10 444421A1S 2 HOSE ASSY., 1943 mm (76-1/2″), Track Tensioning, Arctic QUADTRAC Tractor Application
11 87306550 1 HOSE ASSY., 2015mm (79-5/16″), Track Tensioning
11 444421A1S 1 HOSE ASSY., 1943 mm (76-1/2″), Track Tensioning, Arctic QUADTRAC Tractor Application
12 87306549 1 HOSE ASSY., 1956mm (77″), Track Tensioning
12 444422A1S 1 HOSE ASSY., 1816 mm (71-1/2″), Track Tensioning, Arctic QUADTRAC Tractor Application
13 87306651 1 HOSE ASSY., 850 mm ( 33-15/32″), Track Tensioning
13 437276A1S 1 HOSE ASSY., 1700 mm (67″), Track Tensioning, Arctic QUADTRAC Tractor Application
14 700-153 1 CONNECTOR, HYD., 9/16″-18 ORFS x M14 x 1.5 ORB, Inc. 15, 16
15 637-63113 1 O-RING, Cl 6, 11.3MM ID x 2.2 Thk
16 238-6011 1 O-RING, -011, 90 Duro, .301″ ID x .070″ Thk
17 87329138 1 HOSE, 883 mm (34-3/4″), Track Tensioning
17 437275A1S 1 HOSE ASSY., 900 mm (35-7/16″), Arctic QUADTRAC Tractor Application
18 700-378 1 ELBOW, 90є, 9/16″-18 ORFS x M14 x 1.5 ORB, Inc. 19, 20
19 637-63113 1 O-RING, Cl 6, 11.3MM ID x 2.2 Thk
20 238-6011 1 O-RING, -011, 90 Duro, .301″ ID x .070″ Thk
21 314270A1 4 VALVE, CHECK, M10 fc sl x 18 orb, Inc. 22, 23
22 637-63153 4 O-RING, Cl 6, 15.3MM ID x 2.2 Thk
23 238-6012 4 O-RING, -012, 90 Duro, .364″ ID x .070″ Thk
24 325647A2 4 COUPLING, M18, Diagnostic
25 87450401 4 BRACKET, SUPPORTING, Track Tension Hose
26 896-11016 8 WASHER, M17.5 x 30 x 4, HT
27 627-16040 4 BOLT, Hex, M16 x 40, 10.9
28 701-319 1 ELBOW, 90є, 11/16″-16 ORFS x 11/16″-16 Fem Sw, Incl. 23

06-17 DRIVE SHAFT – MOUNTING

Pos Part no. Qty Description
1 87440506 1 SHAFT, DRIVE, Input, 8C, See Figure 06-18, With Manual Shift Transmission, With 450 Series Axles
1 87440505 1 SHAFT, DRIVE, Input, 8C, See Figure 06-18, With 450 Series Axles, With Power Shift Transmission
1 87440503 1 SHAFT, DRIVE, Input, 8.5C, See Figure 06-18, With 500 Series Axles, With Power Shift Transmission
2 378758A2 1 DAMPER, Vibration, Also Order 80-1716
3 80-1716 12 SCREW, 12 Pt Flg, Hd, 7/16″-14 x 1, Gr 8
4 496-81010 12 WASHER
5 426-1024 10 BOLT, Hex, 5/8″-11 x 1 1/2″, G8, Full Thd
6 827-12050 24 BOLT, Hex, M12 x 50, 10.9, , With 450 Series Axles
6 827-12060 24 BOLT, Hex, M12 x 60, 10.9, , With 500 Series Axles
7 402186A1 1 SHAFT, DRIVE, Front Axle, 8C, See Figure 06-18, With 450 Series Axles
7 402191A1 1 SHAFT, DRIVE, Front Axle, 8,5C, See Figure 06-18, With 500 Series Axles
8 402187A1 1 SHAFT, DRIVE, Articulation, 8C, See Figure 06-18, With 450 Series Axles
8 402192A1 1 SHAFT, DRIVE, Articulation, 8,5C, See Figure 06-18, With 500 Series Axles
9 402188A1 1 SHAFT, DRIVE, Rear Axle, 8C, See Figure 06-18, With 450 Series Axles
9 402193A1 1 SHAFT, DRIVE, Rear Axle, 8,5C, See Figure 06-18, With 500 Series Axles
10 451767A1 1 BEARING, Pillow Block, See Figure 06-18
11 827-20250 2 BOLT, Hex, M20 x 250, 10.9
12 896-15020 2 WASHER, M20 x 44.5 x 5, HT
13 829-1420 2 NUT, M20, Cl 10
14 406056A1 1 SPACER

06-18 DRIVE SHAFT

Pos Part no. Qty Description
1 87440506 1 SHAFT, DRIVE, Input, 8C, Inc. 1 – 6, With Advanced Farming Systems (AFS), With 450 Series Axles
1 87440505 1 SHAFT, DRIVE, Input, 8,5C, Inc. 1- 6, With 450 Series Axles, With Power Shift Transmission
1 87440503 1 SHAFT, DRIVE, Input, 8,5C, Inc. 1 – 6, With 500 Series Axles, With Power Shift Transmission
4 827-12050 4 BOLT, Hex, M12 x 50, 10.9, , With 450 Series Axles
4 827-12060 4 BOLT, Hex, M12 x 60, 10.9, , With 500 Series Axles
5 404151A1 1 SEAL
6 86000308 1 KIT, Spider Assy., 8C, With 450 Series Axles
6 309093A1 1 SPIDER ASSY., 8,5C, With 500 Series Axles
7 402186A1 1 SHAFT, DRIVE, Front Axle, 8C, Inc. 7 – 10, With 450 Series Axles
7 402191A1 1 SHAFT, DRIVE, Front Axle, 8,5 C, Inc. 7 – 10, With 500 Series Axles
9 827-12050 8 BOLT, Hex, M12 x 50, 10.9, , With 450 Series Axles
9 827-12060 8 BOLT, Hex, M12 x 60, 10.9, , With 500 Series Axles
10 431621A1 2 KIT, 8C, With 450 Series Axles
10 309093A1 2 SPIDER ASSY., 8,5C, With 500 Series Axles
11 402187A1 1 SHAFT, DRIVE, Articulation, 8C, Inc. 11 – 15, With 450 Series Axles
11 402192A1 1 SHAFT, DRIVE, Articulation, 8,5C, Inc. 11 – 15, With 500 Series Axles
13 827-12050 8 BOLT, Hex, M12 x 50, 10.9, , With 450 Series Axles
13 827-12060 8 BOLT, Hex, M12 x 60, 10.9, , With 500 Series Axles
14 431621A1 2 KIT, 8C, With 450 Series Axles
14 309093A1 2 SPIDER ASSY., 8,5C, With 500 Series Axles
15 404151A1 1 SEAL
16 402188A1 1 SHAFT, DRIVE, Rear Axle, 8C, Inc. 17 – 22, With 450 Series Axles
16 402193A1 1 SHAFT, DRIVE, Rear Axle, 8,5C, Inc. 17 – 22, With 500 Series Axles
18 827-12050 4 BOLT, Hex, M12 x 50, 10.9, , With 450 Series Axles
18 827-12060 4 BOLT, Hex, M12 x 60, 10.9, , With 500 Series Axles
19 431621A1 2 KIT, 8C, With 450 Series Axles
19 309093A1 2 SPIDER ASSY., 8,5C, With 500 Series Axles
20 404451A1 1 YOKE, 8C, With 450 Series Axles
20 407633A1 1 YOKE, 8,5C, With 500 Series Axles
21 396-11131 1 WASHER, 1 5/16″ x 2 1/2″ x .150″
22 131-487 1 NUT, LOCK, 1 1/4″-18
23 451767A1 1 BEARING, Pillow Block

06-19 POWER TAKEOFF – CLUTCH LUBRICATION, WITH MANUAL SHIFT TRANSMISSION

Pos Part no. Qty Description
1 701-320 1 ELBOW, 90є, 13/16″-16 ORFS x 13/16″-16 Fem Sw, Inc. 2
2 238-6014 4 O-RING, -014, 90 Duro, .489″ ID x .070″ Thk
3 435901A1 1 BRACKET
4 435596A1 1 TUBE ASSY.
5 700-304 2 ELBOW, 90є, 11/16″-18 ORFS x M14 x 1.5 ORB, Incl. 6, 7
6 238-6012 1 O-RING, -012, 90 Duro, .364″ ID x .070″ Thk
7 637-63113 1 O-RING, Cl 6, 11.3MM ID x 2.2 Thk
8 700-305 1 ELBOW, 90є, 13/16″-18 ORFS x M18 x 1.5 ORB, Inc. 2, 10
9 435902A1 1 TUBE ASSY.
10 637-63153 1 O-RING, Cl 6, 15.3MM ID x 2.2 Thk
11 401365A2 1 BRACKET
12 896-11012 1 WASHER, M13.5 x 24.5 x 3, HT
13 627-16035 2 BOLT, Hex, M16 x 35, 10.9
14 700-102 1 CONNECTOR, HYD., 13/16″-16 ORFS x M18 x 1.5 ORB, Inc. 2, 15
15 637-64236 1 O-RING, Cl 6, 23.6MM ID x 2.9 Thk
16 895-11016 1 WASHER, M16 x 30 x 3
17 435598A1 1 TUBE ASSY.
18 401398A1 1 BRACKET
19 515-2295 2 CLAMP, 3/8″, Insul, 5/16″ Bolt
20 515-22127 3 CLAMP, 1/2″, Insul, 5/16″ Bolt
21 627-8030 4 BOLT, Hex, M8 x 30, 10.9
22 829-1408 4 NUT, M8, Cl 10
23 827-10070 2 BOLT, Hex, M10 x 70, 10.9
24 413944A1 1 VALVE, Power Takeoff, See Figure: 06-21
25 238-5112 5 O-RING, -112, 70 Duro, .487″ ID x .103″ Thk
27 627-12030 1 BOLT, Hex, M12 x 30, 10.9
26 895-11008 8 WASHER, M8 x 16 x 1.6

06-20 POWER TAKEOFF – CLUTCH LUBRICATION, WITH POWER SHIFT TRANSMISSION

Pos Part no. Qty Description
1 700-101 2 CONNECTOR, HYD., 11/16″-16 ORFS x M14 x 1.5 ORB, Incl. 2, 3
2 238-6012 1 O-RING, -012, 90 Duro, .364″ ID x .070″ Thk
3 637-63113 1 O-RING, Cl 6, 11.3MM ID x 2.2 Thk
4 87436852 1 TUBE ASSY.
5 515-22127 1 CLAMP, 1/2″, Insul, 5/16″ Bolt
8 700-102 2 CONNECTOR, HYD., 13/16″-16 ORFS x M18 x 1.5 ORB, Inc. 9, 10
6 614-8020 1 BOLT, Hex, M8 x 20, 8.8
9 238-6014 1 O-RING, -014, 90 Duro, .489″ ID x .070″ Thk
7 829-1408 1 NUT, M8, Cl 10
10 637-63153 1 O-RING, Cl 6, 15.3MM ID x 2.2 Thk
11 828-10070 2 BOLT, Hex, M10 x 70, 10.9
12 413944A1 1 VALVE, Power Takeoff, See Figure: 06-21
13 238-5112 5 O-RING, -112, 70 Duro, .487″ ID x .103″ Thk
14 414550A1 1 TUBE ASSY.
15 414553A1 1 BRACKET
16 515-2295 1 CLAMP, 3/8″, Insul, 5/16″ Bolt

06-21 VALVE ASSEMBLY – POWER TAKE OFF

Pos Part no. Qty Description
2 221578A1 4 PLUG, Hex Soc, M18 x 1.5, ORB, Incl. 3
3 637-63153 4 O-RING, Cl 6, 15.3MM ID x 2.2 Thk
7 237-6008 1 O-RING, 8-1, 90 Duro, .644″ ID x .087″ Thk
8 238-5014 1 O-RING, -014, 70 Duro, .489″ ID x .070″ Thk
9 238-5013 1 O-RING, -013, 70 Duro, .426″ ID x .070″ Thk
11 238-6014 1 O-RING, -014, 90 Duro, .489″ ID x .070″ Thk
12 238-6013 1 O-RING, -012, 90 Duro, .364″ ID x .070″ Thk
13 237-6008 1 O-RING, 8-1, 90 Duro, .644″ ID x .087″ Thk
15 637-64236 1 O-RING, Cl 6, 23.6MM ID x 2.9 Thk
16 87697995 1 SLEEVE
17 319665A1 1 PISTON
18 319661A1 1 SPRING, Inner
19 319660A1 1 SPRING, Outer
20 221576A1 1 PLUG, Hex Soc, M14 x 1.5, ORB, Incl. 21
21 637-63113 1 O-RING, Cl 6, 11.3MM ID x 2.2 Thk
22 320036A1 1 SPOOL
23 322118A1 1 NUT
24 319659A1 1 SPRING

06-22 POWER TAKEOFF – LUBRICATION

Pos Part no. Qty Description
1 895-11010 4 WASHER, M10 x 20 x 2
2 627-10025 4 BOLT, Hex, M10 x 25, 10.9, Full Thd
3 86992408 1 FITTING, Flange
4 700-102 3 CONNECTOR, HYD., 13/16″-16 ORFS x M18 x 1.5 ORB, Inc. 14, 15
5 637-63153 1 O-RING, Cl 6, 15.3MM ID x 2.2 Thk
6 238-6014 1 O-RING, -014, 90 Duro, .489″ ID x .070″ Thk
7 86994525 1 HOSE ASSY., 3251 mm (128 in)
8 700-103 1 CONNECTOR, HYD., 1″-14 ORFS x M22 x 1.5 ORB, Incl. 9, 11
9 637-63133 1 O-RING, Cl 6, 13.3MM ID x 2.2 Thk
10 86994526 1 HOSE ASSY., 1270 mm (50 in), Rear Axle to PTO, With 450 Series Axles
10 87400234 1 HOSE ASSY., 1803 mm (71 in), Rear Axle to PTO, With 500 Series Axles
10 87400403 1 HOSE ASSY., 1563 mm (61-1/2 in), Rear Axle to PTO, QUADTRAC Tractor
11 238-6016 2 O-RING, -016, 90 Duro, .614″ ID x .070″ Thk
12 238-6018 1 O-RING, -018, 90 Duro, .739″ ID x .070″ Thk
13 515-23238 1 CLAMP, 15/16″, Insul, 3/8″ Bolt, , With 500 Series Axles

06-23 POWER TAKEOFF – DRIVE SHAFT MOUNTING

Pos Part no. Qty Description
1 404798A1 1 SHAFT, Articulation, See Figure: 06-24
2 L116943 8 SPIDER, U-JOINT
3 868-10020 16 SCREW, 12 Pt Hd, M10 x 20, 12.9
5 404604A1 1 BRACKET
6 827-16080 4 BOLT, Hex, M16 x 80, 10.9, , STX Wheel Tractor, With 450 Series Axles
6 827-16090 4 BOLT, Hex, M16 x 90, 10.9, , STX Wheel Tractor, With 500 Series Axles
6 827-16100 4 BOLT, Hex, M16 x 100, 10.9, , QUADTRAC Tractor
7 896-11016 4 WASHER, M17.5 x 30 x 4, HT
8 404799A1 1 SHAFT, DRIVE, Rear, See Figure: 06-24

06-24 POWER TAKEOFF – DRIVE SHAFT ASSEMBLIES

Pos Part no. Qty Description
1 404798A1 1 SHAFT, Articulation, Inc. 2 – 6
4 33-1001T1 1 RETAINER, SEAL
5 S300313 2 SPIDER ASSY., Inc. 6
6 S92378 4 SNAP RING
7 399447A1 1 HOUSING, BEARING
8 399446A1 1 SHAFT, PTO Hanger Bearing
9 90-1322T1 2 BEARING SET
10 90-1862T1 2 BEARING, CONE
11 435537A1 2 SEAL
12 398554A1 2 YOKE
13 19-5864 2 WASHER, 5/8 x 2-3/4 x 1/2
14 627-16040 2 BOLT, Hex, M16 x 40, 10.9
15 219-36 1 NIPPLE, LUBE, 45є, 1/8″ NPT x 7/8″ lg
16 404799A1 1 SHAFT, DRIVE, Rear, Inc. 17 – 21
19 33-1001T1 1 RETAINER, SEAL
20 S300313 2 SPIDER ASSY., Inc. 21
21 S92378 4 SNAP RING

06-25 POWER TAKEOFF – SAFETY SHIELDS

Pos Part no. Qty Description
1 403073A1 1 GEARBOX ASSY, See Figure: 06-26
2 405394A1 2 BRACE, Mounting, PTO Safety Shields
3 827-12055 4 BOLT, Hex, M12 x 55, 10.9, , Mating Male Quick Connect Adapter is P/n 86544945.
4 892-11012 4 WASHER, LOCK, M12
5 829-1412 4 NUT, M12, Cl 10
6 405396A1 1 COVER, Right-Hand
7 405395A1 1 COVER, Left-Hand
8 405397A1 1 SHIELD, Flip-up
9 896-11012 10 WASHER, M13.5 x 24.5 x 3, HT
10 627-12030 6 BOLT, Hex, M12 x 30, 10.9, , Mating Male Quick Connect Adapter is P/n 86544945.
10 627-12030 10 BOLT, Hex, M12 x 30, 10.9, , Without Three Point Hitch
11 365853A1 2 SPRING
12 895-15008 2 WASHER, M8 x 20 x 1.6
13 733-2012 2 PIN, SPLIT (COTTER), M2 x 12
14 327567A3 1 DECAL, PTO Safety Sheild
15 627-16025 2 BOLT, Hex, M16 x 25, 10.9, Full Thd
16 405398A1 1 BRACKET, Optional PTO, If Used
17 383716A1 1 SHIELD, PTO Shaft
18 627-10030 2 BOLT, Hex, M10 x 30, 10.9, Full Thd
19 896-11020 4 WASHER, M20 x 37.5 x 4, HT
20 827-20230 4 BOLT, Hex, M20 x 230, 10.9
21 259389A1 2 PLATE
22 70-5967T1 2 SPACER
23 896-11016 2 WASHER, M17.5 x 30 x 4, HT

06-26 POWER TAKEOFF – TRANSFER CASE ASSEMBLY

Pos Part no. Qty Description
1 375500A1 1 HOUSING, Rear
2 375501A1 1 HOUSING, Front
3 428183A1 5 BEARING
4 375502A1 1 GEAR, Input
5 375503A1 1 BEARING
7 375508A1 1 GEAR, Idler
9 375509A1 1 SHAFT, Output
10 S2240S00F 1 SNAP RING
11 375510A1 1 GEAR, Output
12 375511A1 1 SPACER
13 S8820S00F 1 SEAL, OIL
14 398447A1 1 YOKE
15 375512A1 1 O-RING
17 S8860S00F 1 WASHER, THRUST
18 514-1021 1 BOLT, Hex, M16 x 1.5 x 35, 10.9, Full Thd
19 375514A1 1 SEAL, OIL
20 427530A1 2 DOWEL
21 220066A1 3 PLUG, M18 x 1.5, ORB, Incl. 22
22 637-63153 3 O-RING, Cl 6, 15.3MM ID x 2.2 Thk
23 375515A1 4 PLUG
24 514-830 10 BOLT, Hex, M12 x 1.25 x 25, 8.8, Full Thd

06-27 POWER TAKEOFF – CLUTCH ASSEMBLY

Pos Part no. Qty Description
1 87601931 1 CLUTCH. PTO, Inc. 2 – 32
2 375550A1 1 HOUSING, Front Cover
3 87601932 1 HOUSING, Rear Cover
4 375552A1 1 HOUSING
5 375553A1 1 GASKET
6 637-63113 1 O-RING, Cl 6, 11.3MM ID x 2.2 Thk
8 S8860S00F 1 WASHER, THRUST
10 375512A1 1 O-RING
11 398447A1 1 YOKE
12 S8820S00F 1 SEAL, OIL
13 ST293 1 BEARING ASSY
14 375554A1 1 GEAR, Driven
15 375555A1 1 SHAFT, Output
16 375559A1 1 BEARING, BALL
17 375560A1 1 SNAP RING
18 375556A1 1 GASKET
19 427530A1 4 DOWEL
20 SM8124208 2 BOLT
21 514-846 4 BOLT, Hex, M12 x 1.25 x 90, 8.8
22 514-855 2 BOLT, Hex, M12 x 1.25 x 50, 8.8, Full Thd
23 614-8030 5 BOLT, Hex, M8 x 30, 8.8
24 514-1021 1 BOLT, Hex, M16 x 1.5 x 35, 10.9, Full Thd
25 514-847 2 BOLT, Hex, M12 x 1.25 x 50, 8.8
26 514-854 7 BOLT, Hex, M12 x 1.25 x 100, 8.8, Full Thd
27 428660A1 1 SLEEVE, , Used on Power Shift Models
28 800-2147 1 RING, SNAP, M47, Int, , Used on Power Shift Models
30 376972A1 1 TROUGH
31 614-6012 2 BOLT, Hex, M6 x 12, 8.8
32 86611704 9 PLUG, Inc. 6

06-28 POWER TAKEOFF – INPUT SHAFT ASSEMBLY

Pos Part no. Qty Description
1 87601933 1 SHAFT, PTO, Input, Inc. 1 – 31
2 S8730S00F 1 BEARING, ROLLER
3 375523A1 4 BOLT
4 375525A1 1 PLATE
5 375527A1 1 PLATE
6 375528A1 2 DISC, CLUTCH, Faced
7 S2080S00F 8 DISC, CLUTCH, 2,4 mm
8 375529A1 7 DISC, CLUTCH, Faced
9 375530A1 1 HUB
10 375531A1 16 SPRING, COIL, Brake Return
11 375532A1 16 PIN
12 375533A1 1 PISTON
13 352834A1 1 RING
14 375534A1 2 PLATE, BRAKE, Steel
15 375535A1 2 PLATE, BRAKE, Faced
16 375536A1 1 PLATE, BRAKE, Steel
17 375538A1 1 DRUM
18 S2240S00F 1 SNAP RING
19 S2220S00F 4 WASHER, THRUST, 2,4 mm
20 572182R1 2 BEARING, THRUST
21 S5510S00F 1 RING
22 375540A1 1 PINION, Drive
23 514-730 10 BOLT, Hex, M10 x 1.25 x 35, 8.8, Full Thd
24 375541A1 2 RETAINER, SEAL
25 87601935 1 SHAFT, PTO, Input
26 375543A1 1 BEARING
27 375544A1 1 RING, SNAP
28 375545A1 1 WASHER
29 375546A1 1 BEARING, CUP
29 186621A1 1 BEARING, CONE
31 S3070S00F 2 RING

06-29 TRANSMISSION MOUNTING, MANUAL SHIFT TRANSMISSION

Pos Part no. Qty Description
1 388851A1 1 PLATE, Transmission Mounting, LH
2 397581A1 1 PLATE, Transmission, RH
3 896-11022 4 WASHER, M22 x 44 x 4, HT
4 828-22190 4 BOLT, Hex, M22 x 190, 10.9
5 379611A1 8 WASHER
6 340967A1 4 MOUNT, RUBBER
7 829-1422 4 NUT, M22 x 2.5, Cl 10
8 627-20060 8 BOLT, Hex, M20 x 60, 10.9
9 827-20120 4 BOLT, Hex, M20 x 120, 10.9

06-30 TRANSMISSION MOUNTING, POWER SHIFT TRANSMISSION

Pos Part no. Qty Description
1 408706A1 1 PLATE, Transmission Mounting, LH
2 87335427 1 PLATE, MOUNTING, Transmission, RH
3 896-11022 4 WASHER, M22 x 44 x 4, HT
4 828-22190 4 BOLT, Hex, M22 x 190, 10.9
5 379611A1 8 WASHER
6 340967A1 4 MOUNT, RUBBER
7 829-1422 4 NUT, M22 x 2.5, Cl 10
8 627-20060 8 BOLT, Hex, M20 x 60, 10.9

06-31 TRANSMISSION – LUBRICATION, WITH MANUAL SHIFT TRANSMISSION

Pos Part no. Qty Description
1 370546A1 1 PUMP, Oil
2 214-3140 2 CLAMP, HOSE, 1.25/2.625 HD Worm
3 427140A1 1 HOSE, Oil Pump to Transmission
4 418735A1 1 TUBE ASSY., Oil Pump to Transmission
5 238-6228 1 O-RING, -228, 90 Duro, 2.234″ ID x .139″ Thk
6 A14141 2 FLANGE
7 627-12035 4 BOLT, Hex, M12 x 35, 10.9
8 87340823 1 CONNECTOR, HYD., Transmission Fill, Inc. 9
9 637-64386 4 O-RING, Cl 6, 38.6MM ID x 2.9 Thk
10 214-1428 1 CLAMP, HOSE, #28, 1.31/2.25 Type F Worm
11 414480A2 1 TUBE ASSY., Transmission Fill
12 325737A1 1 CAP, Transmission Fill
13 700-105 1 CONNECTOR, HYD., 1 7/16″-12 ORFS x M22 x 2 ORB, Inc. 10, 15
14 416102A1 1 SUPPORT, Bracket
15 238-6021 5 O-RING, -021, 90 Duro, .926″ ID x .070″ Thk
16 700-105 2 CONNECTOR, HYD., 1 7/16″-12 ORFS x M22 x 2 ORB, Inc. 10, 15
17 87305825 1 TUBE ASSY., Transmission Pump to Filter
18 87338377 1 TUBE, HYD, Filter to Transmission Return
19 87305990 1 HOSE ASSY., 851 mm (33-1/2 in), Supply, Filter to Transmission
20 87305991 1 HOSE ASSY., 866 mm (34 in), Outlet, Oil Pump to Filter
21 700-105 2 CONNECTOR, HYD., 1 7/16″-12 ORFS x M22 x 2 ORB, Inc. 10, 15
22 515-23254 4 CLAMP, 1″, Insul, 3/8″ Bolt
23 438240A1 1 TUBE ASSY.
24 627-8020 2 BOLT, Hex, M8 x 20, 10.9
25 829-1410 2 NUT, M10, Cl 10
26 895-11010 2 WASHER, M10 x 20 x 2
27 515-24349 1 CLAMP, 1 3/8″, Insul, 7/16″ Bolt
28 829-1408 4 NUT, M8, Cl 10
29 895-11008 6 WASHER, M8 x 16 x 1.6
30 L116247 1 GAUGE, Sight, Inc. Hardware
31 S14701960 1 BALL
32 370551A1 1 TUBE ASSY.
33 514-721 2 BOLT, Hex, M10 x 1.25 x 30, Cl8.8, Full Thd
34 367930A1 1 ADAPTER
35 A164503 1 HEATER ASSY., 120 V, with Cord
35 387062A1 1 HEATER UNIT, 240 V, with Cord
36 22-824 5 STRAP, CABLE, 3/16″ x 7 1/4″
37 427516A1 1 SNAP RING
38 427523A1 1 ADAPTER
39 800-2150 1 RING, SNAP, M50, Int
40 427521A1 1 COUPLING
41 87597484 1 HOSE, Transmission Fill
42 895-11010 4 WASHER, M10 x 20 x 2
43 832-10410 2 NUT, LOCK, M10 x 1.5, Cl 8
44 827-10045 2 BOLT, Hex, M10 x 45, 10.9
45 214-1420 1 CLAMP, HOSE, #20, 0.81/1.75 Type F Worm

06-32 TRANSMISSION – LUBRICATION, WITH POWER SHIFT TRANSMISSION

Pos Part no. Qty Description
1 370546A1 1 PUMP, Oil
2 214-3140 2 CLAMP, HOSE, 1.25/2.625 HD Worm
3 31-2427 1 HOSE, 102 mm (4 in), Transmission to Oil Pump
4 408581A1 1 TUBE, Transmission to Oil Pump
5 238-6228 1 O-RING, -228, 90 Duro, 2.234″ ID x .139″ Thk
6 A14141 2 FLANGE
7 627-12035 4 BOLT, Hex, M12 x 35, 10.9
8 87340823 1 CONNECTOR, HYD., Transmission Fill, Inc. 9
9 637-64386 3 O-RING, Cl 6, 38.6MM ID x 2.9 Thk
10 214-1420 1 CLAMP, HOSE, #20, 0.81/1.75 Type F Worm
11 87597484 1 HOSE, Transmission Fill
12 325737A1 1 CAP, Transmission Fill
13 700-308 1 ELBOW, 90є, 1 7/16″-12 ORFS x M33 x 2 ORB, Inc. 10, 15
14 832-10410 2 NUT, LOCK, M10 x 1.5, Cl 8
15 238-6021 4 O-RING, -021, 90 Duro, .926″ ID x .070″ Thk
16 87305825 1 TUBE ASSY., Transmission Pump to Filter
17 87338377 1 TUBE, HYD, Filter to Transmission Return
18 515-23254 3 CLAMP, 1″, Insul, 3/8″ Bolt
19 87305833 1 HOSE ASSY., 775 mm (30-1/2 in), Supply, Filter to Tranmission
19 437255A1S 1 HOSE ASSY., 1811 mm (71-5/16″), Supply, Filter to Transmission, Arctic QUADTRAC Tractor
20 87305831 1 HOSE ASSY., 1399 mm (55 in), Outlet, Oil Pump to Filter
20 437254A1S 1 HOSE ASSY., Outlet, Oil Pump to Filter, Arctic QUADTRAC Tractor Application
21 700-105 3 CONNECTOR, HYD., 1 7/16″-12 ORFS x M22 x 2 ORB, Inc. 10, 15
22 827-10045 2 BOLT, Hex, M10 x 45, 10.9
23 895-11008 4 WASHER, M8 x 16 x 1.6
24 829-1408 3 NUT, M8, Cl 10
25 829-1410 2 NUT, M10, Cl 10
26 895-11010 4 WASHER, M10 x 20 x 2
27 515-22349 2 CLAMP, 1 3/8″, Insul, 5/16″ Bolt
28 832-10410 2 NUT, LOCK, M10 x 1.5, Cl 8
29 895-11008 3 WASHER, M8 x 16 x 1.6
30 L116247 1 GAUGE, Sight, Inc. Hardware
31 S14701960 1 BALL
32 370551A1 1 TUBE ASSY.
33 514-721 2 BOLT, Hex, M10 x 1.25 x 30, Cl8.8, Full Thd
34 367930A1 1 ADAPTER
35 A164503 1 HEATER ASSY., 120 W, with Cord Set
35 387062A1 1 HEATER UNIT, 240 V, with Cord Set
36 22-824 5 STRAP, CABLE, 3/16″ x 7 1/4″
37 432444A1 1 SPACER
38 214-1428 1 CLAMP, HOSE, #28, 1.31/2.25 Type F Worm
39 414480A2 1 TUBE ASSY., Fill
40 178889A1 1 FITTING, Diagnostic, Inc. 41 – 43
41 637-63113 1 O-RING, Cl 6, 11.3MM ID x 2.2 Thk
43 H434163 1 DUST CAP, Dust

06-33 MANUAL SHIFT TRANSMISSION – VALVE ASSEMBLY MOUNTING

Pos Part no. Qty Description
1 428114A1 1 VALVE, Hi / Low
2 428123A1 1 GASKET
3 814-8075 4 BOLT, Hex, M8 x 75, 8.8
4 428091A1 1 VALVE, Lockout, See Figure 06-46
5 427594A1 2 SCREW
6 427593A1 2 SCREW
7 428083A1 1 VALVE, Control, See Figure 06-45
8 514-729 2 BOLT, Hex, M10 x 90, 8.8
9 514-739 2 BOLT, Hex, M10 x 1.25 x 120, 8.8
10 427581A1 1 GASKET
11 428096A1 1 VALVE, Regulator, See Figure 06-47
12 614-8065 5 BOLT, Hex, M8 x 65, 8.8, Full Thd
13 614-8075 3 BOLT, Hex, M8 x 75, 8.8, Full Thd
14 S1150S02F 1 GASKET
16 370600A1 1 VALVE, SOLENOID, Pilot Assy.
17 371739A1 1 COIL

06-34 MANUAL SHIFT TRANSMISSION – COVERS AND YOKES

Pos Part no. Qty Description
1 427538A1 1 HOUSING, Rear
2 427588A1 1 HOUSING, Front
3 427539A1 1 PLATE, RETAINING
5 428162A1 1 O-RING
6 373136A1 1 COUPLING FLANGE, 8C, Input, With 450 Series Axles
6 362563A1 1 COUPLING FLANGE, 8,5C, Input, With 500 Series Axles
7 428159A1 1 SEAL, OIL
8 428098A1 1 RETAINER, Input
9 428099A1 1 GASKET, Input
11 362566A1 1 ADAPTER, Pump
12 800-2128 1 RING, SNAP, M28, Int
13 362567A1 1 COUPLING
14 800-2150 1 RING, SNAP, M50, Int
15 428126A1 1 RETAINER, Second Shaft
16 428100A1 1 GASKET, Second Shaft
17 427592A1 1 PLATE, RETAINING
18 427591A1 1 GASKET
19 427557A1 1 RETAINER, Third Shaft
20 427582A1 1 GASKET, Third shaft
21 514-721 12 BOLT, Hex, M10 x 1.25 x 30, Cl8.8, Full Thd
22 427569A1 1 WASHER
23 514-834 4 BOLT, Hex, M12 x 1.25 x 30, 8.8, Full Thd
24 427559A1 2 SCREW
25 428149A1 1 O-RING
26 427586A1 1 PLATE ASSY., Ditch
27 427583A1 1 GASKET, Ditch Plate
28 427556A1 1 RETAINER, Fourth Shaft
29 514-718 5 BOLT, Hex, M10 x 1.25 x 40, 8.8, Full Thd
30 220066A1 1 PLUG, M18 x 1.5, ORB, Incl. 31
31 637-63153 1 O-RING, Cl 6, 15.3MM ID x 2.2 Thk
32 800-2116 1 RING, SNAP, M16, Int
33 427515A1 2 PLATE, RETAINING
35 428165A1 2 O-RING
36 427551A1 1 YOKE, 8C, Output, With 450 Series Axles
36 427550A1 1 YOKE, 8,5C, Output, With 500 Series Axles
37 427549A1 1 RING
38 427514A1 2 SEAL, OIL
39 427563A1 1 RETAINER, Output
40 427547A1 1 GASKET, Output
41 373138A1 1 COUPLING FLANGE, 8C, Output, With 450 Series Axles
41 362604A1 1 COUPLING FLANGE, 8,5C, Output, With 500 Series Axles
42 427558A1 1 COVER, Power Takeoff
43 303493A1 2 PLUG, Hex Soc, M42 x 2, ORB, M42, Inc. 44
44 637-64386 2 O-RING, Cl 6, 38.6MM ID x 2.9 Thk
45 375456A1 1 PLUG, DRAIN, M42, Inc. 46
46 637-64386 1 O-RING, Cl 6, 38.6MM ID x 2.9 Thk
47 220064A1 3 PLUG, M14 x 1.5, ORB, Incl. 48
48 637-63113 1 O-RING, Cl 6, 11.3MM ID x 2.2 Thk
49 428181A1 3 BOLT, M14 x 35; CL8.8
50 428180A1 6 BOLT, M10 x 35
51 514-841 1 BOLT, Hex, M12 x 1.25 x 20, 8.8, Full Thd
52 514-738 2 BOLT, Hex, M10 x 1.25 x 45, 8.8, Full Thd
53 514-720 4 BOLT, Hex, M10 x 1.25 x 50, 8.8, Full Thd
54 614-8016 2 BOLT, Hex, M8 x 16, 8.8
55 514-832 6 BOLT, Hex, M12 x 1.25 x 35, 8.8, Full Thd
56 514-842 4 BOLT, Hex, M12 x 1.25 x 25, 8.8, Full Thd
57 H434163 1 DUST CAP, Dust
59 637-63113 1 O-RING, Cl 6, 11.3MM ID x 2.2 Thk

06-35 MANUAL SHIFT TRANSMISSION – REAR HOUSING

Pos Part no. Qty Description
1 427666A1 7 SCREW
2 428151A1 2 DOWEL
3 427664A1 1 SHAFT, Reverse Idler
4 427662A1 2 BEARING, ROLLER, TAPERED
5 427659A1 1 GEAR, IDLER, Reverse
7 427661A1 1 WASHER, Retaining
8 514-1021 1 BOLT, Hex, M16 x 1.5 x 35, 10.9, Full Thd
9 614-6012 7 BOLT, Hex, M6 x 12, 8.8
10 427578A1 1 TROUGH
11 427616A1 1 PLATE, SUPPORT
12 428172A1 12 WASHER
13 514-832 12 BOLT, Hex, M12 x 1.25 x 35, 8.8, Full Thd
14 427553A1 1 SCREW
15 427554A1 1 WASHER
16 514-730 3 BOLT, Hex, M10 x 1.25 x 35, 8.8, Full Thd
17 427576A1 1 TROUGH
18 427538A1 1 HOUSING
19 838-5518 1 PIN, LOCK, M5 x 18, Slotted
20 427579A1 1 TROUGH, First Gear
21 427580A1 1 TROUGH, Second Gear
22 428157A1 1 O-RING
23 427615A1 1 SHAFT, Idler
24 427613A1 2 BEARING, ROLLER, TAPERED
25 427614A1 1 GEAR, IDLER
27 428152A1 2 DOWEL
28 428144A1 1 LEVER, 1-R Gears
29 428146A1 1 LEVER, A-B Range
30 428140A1 1 SUPPORT, Lever, 1-R Gears
31 514-712 4 BOLT, Hex, M10 x 1.25 x 25, 8.8, Full Thd
32 SM831050 3 PIN
33 428128A1 4 BEARING, NEEDLE
34 428129A1 2 SEAL, OIL
35 428127A1 2 LEVER, Range Shifter
36 428142A1 1 SUPPORT, Lever, A-B Range
37 427546A1 1 BAFFLE
38 514-703 2 BOLT, Hex, M10 x 1.25 x 20, 8.8, Full Thd
39 SM8915440 2 WASHER
40 514-842 2 BOLT, Hex, M12 x 1.25 x 25, 8.8, Full Thd
41 427548A1 1 STRAP, Left-Hand
42 825-11410 2 NUT, M10 x 1.25, Cl 8
43 427545A1 1 STRAP, Right-Hand

06-36 MAUAL SHIFT TRANSMISSION – FRONT HOUSING

Pos Part no. Qty Description
1 614-6012 7 BOLT, Hex, M6 x 12, 8.8
2 427575A1 1 BAFFLE
3 427574A1 1 GASKET
4 428156A1 1 PLUG
5 427524A1 1 BREATHER
6 370632A1 1 TUBE, Breather
7 428145A1 1 LEVER, 2-3 Gears
8 428147A1 1 LEVER, C-D Range
9 428127A1 2 LEVER, Range Shift
10 SM831050 2 PIN
11 514-712 4 BOLT, Hex, M10 x 1.25 x 25, 8.8, Full Thd
12 428141A1 1 SUPPORT, Lever, 2-3 Gears
13 428129A1 2 SEAL, OIL
14 428128A1 1 BEARING, NEEDLE
15 428143A1 1 SUPPORT, Lever, C-D Range
16 427588A1 1 HOUSING, Front

06-37 MANUAL SHIFT TRANSMISSION – SHAFT ASSEMBLIES AND SHIFTER FORKS

Pos Part no. Qty Description
1 514-843 13 BOLT, Hex, M12 x 1.25 x 60, 8.8, Full Thd
2 427530A1 2 DOWEL
3 614-6012 2 BOLT, Hex, M6 x 12, 8.8
4 427577A1 1 TROUGH, Reverse Idler
5 428120A1 1 SHAFT ASSY., Input, See Figure: 06-39 & 06-40
6 427681A1 1 SHAFT ASSY., Fourth, See Figure: 06-43
7 427647A1 1 SHAFT ASSY., Third, See Figure: 06-42
8 427690A1 1 SHAFT ASSY., Fifth, See Figure: 06-44
9 514-703 2 BOLT, Hex, M10 x 1.25 x 20, 8.8, Full Thd
10 428138A1 1 PLATE
11 427588A1 1 HOUSING, Front
12 514-830 16 BOLT, Hex, M12 x 1.25 x 25, 8.8, Full Thd
13 428121A1 1 SHAFT ASSY., Second, See Figure: 06-41
14 427538A1 1 HOUSING, Rear
15 428130A1 1 FORK, SHIFTER, 1-R Gears, See Figure: 06-38
15 428131A1 1 FORK, SHIFTER, 2-3 Gears, See Figure: 06-38
15 428133A1 1 FORK, SHIFTER, C-D Range, See Figure: 06-38
15 428132A1 1 FORK, SHIFTER, A-B Range, See Figure: 06-38

06-38 MANUAL SHIFT TRANSMISSION – SHIFTER FORKS

Pos Part no. Qty Description
1 428130A1 1 FORK, SHIFTER, 1-R Gears
2 428155A1 4 BALL
3 428139A1 4 SPRING
4 428154A1 4 PLUG
5 428135A1 1 ROD, Speed Shaft
6 428134A1 1 PLATE, Interlock
7 838-5860 2 PIN, LOCK, M8 x 60, Slotted
8 428150A1 2 BALL
9 428137A1 2 O-RING
10 428131A1 1 FORK, SHIFTER, 2-3 Gears
11 428133A1 1 FORK, SHIFTER, C-D Range
12 428132A1 1 FORK, SHIFTER, A-B Range
13 428136A1 1 ROD, Range Shaft

06-39 MANUAL SHIFT TRANSMISSION – INPUT SHAFT ASSEMBLY

Pos Part no. Qty Description
2 427613A1 1 BEARING, ROLLER, TAPERED
3 427620A1 2 WASHER, THRUST
4 427617A1 1 BEARING, THRUST
5 427619A1 1 COLLAR
6 427610A1 1 GEAR, Input
7 427608A1 1 SNAP RING
8 427612A1 2 BEARING, NEEDLE
9 S5040S00F 3 RING
10 S5230S00F 1 WASHER, THRUST
11 A75158 1 BEARING, THRUST
12 427618A1 2 WASHER, THRUST
13 S14701960 1 BALL
14 428101A1 1 SHAFT, High / Low Input
16 428112A1 2 BEARING ASSY
17 514-721 10 BOLT, Hex, M10 x 1.25 x 30, Cl8.8, Full Thd
18 427595A1 1 COVER
20 427601A1 8 DISC, CLUTCH, Faced
21 427606A1 32 SPRING, Clutch Separator
22 S4410S00F 3 RING, Seal
23 427600A1 1 SEALRING
24 427599A1 1 SEALRING
25 427605A1 12 GUIDE
26 427607A1 1 DRUM, Clutch
27 427596A1 12 SPRING
28 427604A1 1 PISTON, Clutch
29 427597A1 4 GUIDE
30 428119A1 1 GEAR, High
31 514-718 12 BOLT, Hex, M10 x 1.25 x 40, 8.8, Full Thd

06-40 MANUAL SHIFT TRANSMISSION – INPUT SHAFT ASSEMBLY

Pos Part no. Qty Description
1 428108A1 1 SNAP RING
2 428104A1 1 PLATE
3 428110A1 2 DISC, CLUTCH, Faced
5 427534A1 3 DISC, CLUTCH, Faced
6 428109A1 1 PLATE, Spring return
7 S2640S00F 12 SPRING
8 428111A1 1 PISTON, Clutch
9 S2630S00F 1 RING, Seal
10 428106A1 1 DRUM, High / Low clutch
11 428163A1 1 SNAP RING
12 428107A1 1 O-RING
13 428105A1 1 GEAR, Drive
14 428103A1 2 BEARING, ROLLER, TAPERED
16 428102A1 5 RING, SNAP
17 514-721 10 BOLT, Hex, M10 x 1.25 x 30, Cl8.8, Full Thd
18 S5040S00F 1 RING, Snap
19 S4410S00F 1 RING, Locking

06-41 MANUAL SHIFT TRANSMISSION – SECOND SHAFT ASSEMBLY

Pos Part no. Qty Description
1 428183A1 1 BEARING
2 428163A1 1 SNAP RING
3 428115A1 1 WASHER
4 428116A1 1 GEAR, High Clutch
5 428125A1 2 BEARING, NEEDLE
6 428124A1 2 SNAP RING
7 428117A1 1 WASHER
8 S5040S00F 1 RING
9 428108A1 1 SNAP RING
10 428104A1 1 PLATE, Ctutch End
11 428110A1 2 DISC, CLUTCH, Faced
13 427534A1 3 DISC, CLUTCH, Faced
14 428109A1 1 PLATE, Spring Return
15 S2640S00F 12 SPRING
16 428111A1 1 PISTON, Clutch
17 S2630S00F 1 RING
18 S4410S00F 1 RING
19 428153A1 1 BALL
20 428118A1 1 NEEDLE
21 428113A1 1 SHAFT ASSY.
22 428107A1 1 O-RING
23 428106A1 1 DRUM
24 428122A1 1 GEAR, Input
25 428103A1 1 BEARING, ROLLER, TAPERED
26 S3070S00F 3 RING
27 428178A1 10 BOLT

06-42 MANUAL SHIFT TRANSMISSION – THIRD SHAFT ASSEMBLY

Pos Part no. Qty Description
2 428074A1 1 BEARING, ROLLER, TAPERED
3 427656A1 1 GEAR, Drive
4 S5040S00F 2 RING
5 372071A1 1 GEAR, First
6 427663A1 4 DISC, Synchro Speed
7 427654A1 4 SNAP RING
8 SM832508 16 PIN
9 427653A1 1 SNAP RING
10 S5070S00F 1 BEARING, NEEDLE
11 427667A1 2 SLEEVE ASSY, Synchro Speed
12 S5090S00F 4 SNAP RING
13 427655A1 2 HUB, Clutch
14 427657A1 1 GEAR, Reverse
15 427660A1 1 BEARING, NEEDLE
16 427648A1 1 SHAFT, Speed
17 372072A1 1 GEAR, Second
18 427658A1 1 GEAR, Third
19 427651A1 1 SPACER
20 427649A1 1 BEARING, ROLLER, TAPERED

06-43 MANUAL SHIFT TRANSMISSION – FOURTH SHAFT ASSEMBLY

Pos Part no. Qty Description
2 427649A1 2 BEARING, ROLLER, TAPERED
3 427684A1 1 GEAR, A Range
4 427685A1 1 GEAR, First
5 427682A1 1 SHAFT, Center
6 427686A1 1 GEAR, B Range
7 427687A1 1 GEAR, Second
8 S5090S00F 1 SNAP RING
9 S5040S00F 1 RING
10 427688A1 1 GEAR, Third
11 427689A1 1 GEAR, D Range

06-44 MANUAL SHIFT TRANSMISSION – FIFTH SHAFT ASSEMBLY

Pos Part no. Qty Description
1 428074A1 1 BEARING, ROLLER, TAPERED
2 S5230S00F 2 WASHER, THRUST
3 A75158 1 BEARING, THRUST
4 S5070S00F 2 BEARING, NEEDLE
5 428076A1 1 GEAR, A Range
6 428081A1 4 DISC, Sycnhro Range
7 427654A1 8 SNAP RING
8 SM832508 16 PIN
9 428082A1 2 SLEEVE ASSY, Sycnhro Range
10 S5090S00F 4 SNAP RING
11 428075A1 2 HUB, Clutch Range
12 428077A1 1 GEAR, B Range
13 427691A1 1 SHAFT, Output
14 428079A1 1 GEAR, C Range
15 428080A1 1 GEAR, D Range
16 427649A1 1 BEARING, ROLLER, TAPERED
17 427683A1 1 RING
18 S4150S00F 2 RING, Seal

06-45 MANUAL SHIFT TRANSMISSION – CONTROL VALVE ASSEMBLY

Pos Part no. Qty Description
1 S6170S00F 1 PLUG, Inc. 2
2 S6180S00F 1 O-RING
3 S6260S00F 8 SCREW
4 S6010S00F 1 SPOOL, Reducing
5 S6220S00F 11 PLUG
6 S6020S00F 1 COVER, Modulator Valve
7 S6030S00F 1 GASKET, Modulator Valve Cover
8 S6040S00F 1 SPOOL, Modulator
9 S6160S00F 1 PIN
10 S6240S00F 1 ORIFICE
11 S6230S00F 1 ORIFICE
12 428084A1 1 BODY, VALVE, Modulator
13 S6060S00F 1 SEAT, SPRING
14 S6210S00F 1 SPRING, Extension
15 S6080S00F 1 LINK, CONNECTING
16 S6150S00F 1 SPRING
18 S6200S00F 1 SPACER, Valve
19 S6130S00F 1 PIN, ROLL
20 S6100S00F 1 HOUSING, Control Stem
21 427537A1 1 GASKET, Control Stem Cover
22 428085A1 1 COVER, Control Stem
23 S6120S00F 1 O-RING
24 S6110S00F 1 SEAL, Oil

06-46 MANUAL SHIFT TRANSMISSION – LOCKOUT VALVE ASSEMBLY

Pos Part no. Qty Description
1 428090A1 1 PLUG
2 428086A1 1 O-RING
3 428094A1 1 PLUG
4 428089A1 1 SPOOL, Lockout
5 428088A1 1 SPRING, Lockout
6 428092A1 1 BODY, VALVE, Lockout
7 428087A1 1 PLUG
8 428093A1 5 O-RING
9 428095A1 1 ORIFICE

06-47 MANUAL SHIFT TRANSMISSION – REGULATOR VALVE ASSEMBLY

Pos Part no. Qty Description
1 428097A1 1 BODY, Regulator Valve
2 220064A1 2 PLUG, M14 x 1.5, ORB, Incl. 3
3 637-63113 2 O-RING, Cl 6, 11.3MM ID x 2.2 Thk
4 S7090S00F 1 GASKET, Regulator Valve Cover
5 S7110S00F 1 COVER, Regulator Valve
6 614-8020 5 BOLT, Hex, M8 x 20, 8.8
7 S7030S01F 1 VALVE, Pressure Regulator
9 S7120S00F 1 SPRING, Compression
10 S7050S00F 2 SPRING, Compression
11 S7020S00F 1 STEM, Pressure Regulator
13 S7060S00F 2 VALVE, Lube
14 S7070S00F 1 SPRING, Compression

06-48 POWER SHIFT TRANSMISSION – VALVE AND PUMP MOUNTING

Pos Part no. Qty Description
1 87351408 1 GASKET, Regulator
2 87350388 1 VALVE, Regulator, See Figure: 06-60
3 514-739 5 BOLT, Hex, M10 x 1.25 x 120, 8.8
4 614-8080 3 BOLT, Hex, M8 x 80, 8.8, Full Thd
5 87362227 10 BOLT
6 87350421 1 VALVE, Range Selector, See Figure: 06-61
7 87335429 1 COVER, Solenoid

06-49 POWER SHIFT TRANSMISSION – COVERS AND YOKES

Pos Part no. Qty Description
1 87350466 1 TRANSMISSION HOUSING, Rear
2 87350479 1 HOUSING, Transmision, Front
3 427539A1 1 PLATE, RETAINING
5 428162A1 1 O-RING
6 373136A1 1 COUPLING FLANGE, 8C, Input, With 450 Series Axles
6 362563A1 1 COUPLING FLANGE, 8,5C, Input, With 500 Series Axles
7 428159A1 1 SEAL, OIL
8 362564A1 1 RETAINER, Input
9 362565A1 1 GASKET, Input Retainer
11 362566A1 1 ADAPTER
12 800-2128 1 RING, SNAP, M28, Int
13 362567A1 1 COUPLING
14 428681A1 1 SNAP RING
15 87542516 1 RETAINER, Second Shaft
16 362569A1 1 GASKET, Second Shaft
17 87351326 1 PLATE, Valve
18 87351331 1 GASKET, Valve
19 87351392 1 PLATE, Ditch
20 87351393 1 GASKET, Third Shaft
21 362574A1 1 O-RING
23 87362252 1 RETAINER, Third Shaft
25 100-2156 1 RING, SNAP, 0.562″, Int, #56
26 87351399 1 MANIFOLD VALVE, Clutch
27 362580A1 1 GASKET, Clutch Manifold Valve
29 514-842 4 BOLT, Hex, M12 x 1.25 x 25, 8.8, Full Thd
30 87351325 1 SEAL, OIL, Oil
31 614-8020 2 BOLT, Hex, M8 x 20, 8.8
32 87351402 1 PLATE, Valve Retainer
33 427515A1 2 PLATE, RETAINING
35 428165A1 2 O-RING
36 373137A1 1 COUPLING FLANGE, 8C, Output, With 450 Series Axles
36 362598A1 1 COUPLING FLANGE, 8,5C, Output, With 500 Series Axles
37 362601A1 1 RING, Speed Pick-up
38 427514A1 2 SEAL, OIL
39 362602A1 1 RETAINER, Output
40 362603A1 1 GASKET, Output Retainer
41 87351323 1 YOKE, 8C, Output, With 450 Series Axles
41 87351322 1 YOKE, 8,5C, Output, With 500 Series Axles
42 427558A1 1 COVER, Power Takeoff
43 303493A1 2 PLUG, Hex Soc, M42 x 2, ORB, Inc. 44
44 637-64386 3 O-RING, Cl 6, 38.6MM ID x 2.9 Thk
45 375456A1 1 PLUG, DRAIN, M42 orb x 2, Inc. 46
46 87350436 1 VALVE, CHECK, 4,45 mm
47 220064A1 14 PLUG, M14 x 1.5, ORB, Incl. 48
48 637-63113 1 O-RING, Cl 6, 11.3MM ID x 2.2 Thk
49 514-915 2 BOLT, Hex, M14 x 1.5 x 35, 8.8, Full Thd
50 514-730 24 BOLT, Hex, M10 x 1.25 x 35, 8.8, Full Thd
51 892-11010 6 WASHER, LOCK, M10
52 514-712 2 BOLT, Hex, M10 x 1.25 x 25, 8.8, Full Thd
53 514-723 4 BOLT, Hex, M10 x 1.25 x 60, 8.8
54 614-8040 2 BOLT, Hex, M8 x 40, 8.8, Full Thd
55 514-853 6 BOLT, Hex, M12 x 1.25 x 35, 10.9, Full Thd
56 H434163 1 DUST CAP, Dust
58 637-63113 1 O-RING, Cl 6, 11.3MM ID x 2.2 Thk
59 427559A1 2 SCREW
61 87014033 1 O-RING, -019, Cl 7, .801″ ID x .070″ Thk
62 238-7016 1 O-RING, -016, Cl 7, .614″ ID x .070″ Thk
63 238-7015 1 O-RING, -015, Cl 7, .551″ ID x .070″ Thk

06-50 POWER SHIFT TRANSMISSION – REAR HOUSING

Pos Part no. Qty Description
1 428156A1 1 PLUG
2 427524A1 1 BREATHER
3 370632A1 1 TUBE, Breather
4 838-51040 2 PIN, LOCK, M10 x 40, Slotted
5 87350473 1 GUTTER, Oil
6 514-842 2 BOLT, Hex, M12 x 1.25 x 25, 8.8, Full Thd
7 370634A1 1 TROUGH, Second
8 614-6012 9 BOLT, Hex, M6 x 12, 8.8
9 370635A2 1 BAFFLE, Air
10 87350466 1 TRANSMISSION HOUSING, Rear
11 825-11410 2 NUT, M10 x 1.25, Cl 8
12 370637A1 2 BRACKET, Mounting, Oil Baffle
13 87350496 1 BAFFLE, Transmission Oil
14 895-11010 2 WASHER, M10 x 20 x 2
15 514-703 2 BOLT, Hex, M10 x 1.25 x 20, 8.8, Full Thd
16 87350470 1 RETAINER, Rear, Output
17 838-51045 6 PIN, LOCK, M10 x 45, Slotted
18 87350468 1 COVER, Rear, Fourth
19 514-730 6 BOLT, Hex, M10 x 1.25 x 35, 8.8, Full Thd

06-51 POWER SHIFT TRANSMISSION – HOUSING AND CLUTCHES

Pos Part no. Qty Description
1 87350479 1 HOUSING, Front
2 87350228 1 SHAFT, CLUTCH INPUT, Input, 8C, (8″ Yoke) See Figure 06-52 & 06-53, BSN Z6F105039
2 87552053 1 SHAFT, CLUTCH INPUT, Input, 8C, (8″ Yoke) See Figure 06-52 & 06-53, ASN Z6F105039
2 87350227 1 SHAFT, CLUTCH INPUT, Input, 8,5C, (8.5″ Yoke) See Figure 06-52 & 06-53, BSN Z6F105039
2 87552050 1 SHAFT, CLUTCH INPUT, Input, 8,5C, (8.5″ Yoke) See Figure 06-52 & 06-53, ASN Z6F105039
3 87350268 1 SHAFT, CLUTCH INPUT, Second, 8C, (8″ Yoke) See Figure 06-54
3 87350264 1 SHAFT, CLUTCH INPUT, Second, 8,5C, (8.5″ Yoke)See Figure 06-54
5 87350312 1 SHAFT, CLUTCH INPUT, Fourth, 8C, (8″ Yoke) See Figure 06-56 & 06-57
5 87350309 1 SHAFT, CLUTCH INPUT, Fourth, 8,5C, (8.5″ Yoke) See Figure 06-56 & 06-57
6 87350349 1 SHAFT, CLUTCH INPUT, Fifth, 8C, (8″ Yoke) See Figure 06-58 & 06-59
6 87350342 1 SHAFT, CLUTCH INPUT, Fifth, 8,5C, (8.5″ Yoke) See Figure 06-58 & 06-59
7 427530A1 2 DOWEL
8 87350466 1 TRANSMISSION HOUSING, Rear
9 838-1318 4 PIN, LOCK, M3 x 18, Slotted
10 800-2112 4 RING, SNAP, M12, Int
11 895-11005 4 WASHER, M5 x 10 x 1
12 370542A1 4 SHIM
13 370543A1 4 SPRING, Valve Check
14 370544A1 4 SPOOL, Drain
15 370545A1 4 CAP, Press
16 514-831 25 BOLT, Hex, M12 x 1.25 x 45, 8.8, Full Thd

06-52 POWER SHIFT TRANSMISSION – INPUT SHAFT ASSEMBLY

Pos Part no. Qty Description
1 87350228 1 SHAFT, CLUTCH INPUT, Input, 8C, (8″ Yoke) Inc. 2 – 28, Also See Figure 06-53, BSN Z6F105039
1 87350227 1 SHAFT, CLUTCH INPUT, Input, 8,5C, (8.5″ Yoke) Inc. 2 – 28, Also See Figure 06-53, BSN Z6F105039
3 428183A1 1 BEARING
4 352817A1 4 BEARING
6 352825A1 1 SPACER
7 87350229 1 GEAR, 1R
8 87350230 2 PLATE, Retainer Springs
9 362616A1 32 SPRING, Return
10 352829A1 2 SNAP RING
11 87350231 2 PLATE, Clutch End, 8C
11 87431390 2 PLATE, Clutch End, 8,5C
12 352831A1 4 DISC, CLUTCH, Faced
15 87350236 2 PISTON, 7″
16 87431391 2 RING, Seal
17 S2610S00F 2 RING
18 87350255 1 SHAFT, Drum Assy., 8C
18 87350251 1 SHAFT, Drum Assy., 8,5C
19 428163A1 1 SNAP RING
20 353059A1 1 WASHER, THRUST
21 87640391 2 BEARING, NEEDLE
22 87350258 1 GEAR, 1M
23 87350260 1 BEARING, NEEDLE
24 358866A1 1 SNAP RING
25 358867A1 1 SPACER
26 358908A1 1 WASHER, THRUST
27 S14701960 1 BALL
28 87431394 2 RING, Seal

06-53 POWER SHIFT TRANSMISSION – INPUT SHAFT ASSEMBLY

Pos Part no. Qty Description
1 87350228 1 SHAFT, CLUTCH INPUT, Input, 8C, (8″ Yoke) Inc. 2 – 25, Also See Figure 06-52, BSN Z6F105039
1 87552053 1 SHAFT, CLUTCH INPUT, Input, 8C, (8″ Yoke) Inc. 2 – 25, Also See Figure 06-52, ASN Z6F105039
1 87350227 1 SHAFT, CLUTCH INPUT, Input, 8,5C, (8.5″ Yoke) Inc. 2 – 25, Also See Figure 06-52, BSN Z6F105039
1 87552050 1 SHAFT, CLUTCH INPUT, Input, 8,5C, (8.5″ Yoke) Inc. 2 – 25, Also See Figure 06-52, ASN Z6F105039
2 358918A1 1 DRUM, 1F, Clutch, BSN Z6F105039
2 87552054 1 DRUM, 1F, Clutch, ASN Z6F105039
3 800-2116 1 RING, SNAP, M16, Int, , BSN Z6F105039
4 S3220S00F 1 SHIM, 0,70 mm (0,028 in), BSN Z6F105039
5 S3210S00F 1 SPRING, , BSN Z6F105039
6 S3200S00F 1 VALVE, DRAIN, , BSN Z6F105039
7 87431393 1 RING, Seal, BSN Z6F105039
7 87431391 1 RING, Seal, ASN Z6F105039
8 358970A1 1 PISTON, Clutch, BSN Z6F105039
8 87552055 1 PISTON, Clutch, ASN Z6F105039
9 S5510S00F 1 RING
10 358971A1 12 SPRING, Return, BSN Z6F105039
10 358971A1 20 SPRING, Return, ASN Z6F105039
11 358972A1 1 PLATE, Spring, BSN Z6F105039
11 87552056 1 SPRING, Plate, ASN Z6F105039
12 370555A1 2 DISC, CLUTCH, Faced
14 370556A1 4 DISC, CLUTCH, Faced
15 442803A1 1 PLATE, End
16 428108A1 1 SNAP RING
17 359203A1 1 SPACER, 1F Bearing
18 359204A1 1 GEAR, 1F
19 87350261 1 GEAR, DRIVING
20 359206A1 1 BEARING, ROLLER, TAPERED
21 359207A1 1 CARRIER, Seal
22 S4150S00F 5 RING, Seal
23 352817A1 2 BEARING, Roller

06-54 POWER SHIFT TRANSMISSION – SECOND SHAFT ASSEMBLY

Pos Part no. Qty Description
1 87350268 1 SHAFT, CLUTCH INPUT, Second, 8C, Inc. 2 – 26
1 87350264 1 SHAFT, CLUTCH INPUT, Second, 8,5C, Inc. 2 – 26
2 428673A1 1 COUPLING, SPLINED
3 428674A1 1 DOWEL
5 428183A1 1 BEARING
6 352817A1 4 BEARING
8 87350273 1 SPACER, 2R Bearing
9 87350277 1 GEAR, 2R
10 87350230 2 PLATE, Retaining Spring
11 362616A1 32 SPRING, Return
12 352829A1 2 SNAP RING
13 87350231 2 PLATE, Clutch End, 8C
13 87431390 2 PLATE, Clutch End, 8,5C
14 352831A1 4 DISC, CLUTCH, Faced
17 87350236 2 PISTON, 7″
18 87431391 2 RING, Seal
19 S2610S00F 2 RING
20 87350301 1 SHAFT, Drum, 8C
20 87350293 1 SHAFT, Drum, 8,5C
21 87350305 1 SPACER, Bearing
22 87350306 1 GEAR, 2M
23 87350307 1 GEAR, DRIVEN, Driven
24 359206A1 1 BEARING, ROLLER, TAPERED
25 S3070S00F 4 RING, Seal
26 87431394 2 RING, Seal

06-55 POWER SHIFT TRANSMISSION – THIRD SHAFT ASSEMBLY

Pos Part no. Qty Description
1 87431397 2 BEARING, Roller
2 87350476 1 SHAFT, GEAR, Third

06-56 POWER SHIFT TRANSMISSION – FOURTH SHAFT ASSEMBLY

Pos Part no. Qty Description
1 87350312 1 SHAFT, CLUTCH INPUT, Fourth, 8C, Inc.2 – 23, Also See Figure: 06-57
1 87350309 1 SHAFT, CLUTCH INPUT, Fourth, 8,5C, Inc. 2 – 23, Also See Figure: 06-57
3 428675A1 2 BEARING, 4R Drive
4 87350315 1 GEAR, DRIVING, 4R
5 S5040S00F 4 RING, Retaining
6 362611A1 3 SPACER, Needle Bearing
7 87640391 4 BEARING, NEEDLE
8 87350316 1 GEAR, DRIVEN
9 87350319 1 BEARING, NEEDLE
10 87350321 1 WASHER, THRUST
11 362615A1 1 PLATE, Spring Retainer
12 362616A1 16 SPRING, Return
13 359235A1 2 SNAP RING
14 87350325 2 PLATE, END, Clutch End, 8C
14 362617A1 2 PLATE, Clutch End, 8,5C
15 362618A1 19 DISC, CLUTCH
17 364822A1 1 PISTON, 9″ RR Clutch
18 87431400 2 RING, Seal
19 S4410S00F 2 RING, Seal
20 87350328 1 SHAFT, Drum, 8C
20 87350326 1 SHAFT, Drum, 8,5C
21 364825A1 1 PISTON, 9″ FR Clutch
22 S14701960 2 BALL
23 392073A1 2 SEALRING

06-57 POWER SHIFT TRANSMISSION – FOURTH SHAFT ASSEMBLY

Pos Part no. Qty Description
1 87350312 1 SHAFT, CLUTCH INPUT, Fourth, 8C, Inc. 2 – 13, Also See Figure: 06-56
1 87350309 1 SHAFT, CLUTCH INPUT, Fourth, 8,5C, Inc. 2 – 13, Also See Figure: 06-56
3 428675A1 2 BEARING, Roller
4 S5040S00F 4 RING, Retaining
5 362611A1 3 SPACER, Needle Bearing
6 87640391 4 BEARING, NEEDLE
7 364826A1 6 PLATE, Spring
8 87350331 1 WASHER, THRUST
9 S5070S00F 2 BEARING, NEEDLE
10 87350334 1 GEAR, DRIVEN, 4F
11 87350339 1 GEAR, DRIVING, 4F
12 87431401 4 RING, Seal
13 392073A1 1 SEALRING

06-58 POWER SHIFT TRANSMISSION – FIFTH SHAFT ASSEMBLY

Pos Part no. Qty Description
1 87350349 1 SHAFT, CLUTCH INPUT, Fifth, 8C, Inc. 2 – 22, Also See Figure: 06-59
1 87350342 1 SHAFT, CLUTCH INPUT, Fifth, 8,5C, Inc. 2 – 22, Also See Figure: 06-59
2 428675A1 2 BEARING, Taper
3 364831A1 2 WASHER, THRUST
4 87640391 4 BEARING, NEEDLE
5 358908A1 2 WASHER, THRUST
6 87350355 1 GEAR, DRIVEN, 5R
7 S5070S00F 4 BEARING, NEEDLE
8 87350321 1 WASHER, THRUST
9 S5040S00F 4 RING, Retaining
10 362615A1 1 PLATE, Spring Retaining
11 364833A1 16 SPRING, Return
12 428108A1 2 SNAP RING
13 87350360 2 PLATE, 8C
13 370554A1 2 DISC, CLUTCH, 8,5C
14 370555A1 4 DISC, CLUTCH, Faced
16 370556A1 25 DISC, CLUTCH, Faced
17 370558A1 1 PISTON, 8″ RR Clutch
18 87431400 2 RING, Seal
19 S4410S00F 2 RING, Seal
20 87350368 1 SHAFT, Drum, 8C
20 87350363 1 SHAFT, Drum, 8,5C
21 370562A1 1 PISTON, 8″ FR Clutch
22 S14701960 2 BALL

06-59 POWER SHIFT TRANSMISSION – FIFTH SHAFT ASSEMBLY

Pos Part no. Qty Description
1 87350349 1 SHAFT, CLUTCH INPUT, Fifth, 8C, Inc. 2 – 13, Also See Figure: 06-58
1 87350342 1 SHAFT, CLUTCH INPUT, Fifth, 8,5C, Inc. 2 – 13, Also See Figure: 06-58
2 428675A1 1 BEARING, Roller
3 364831A1 1 WASHER, THRUST
4 87640391 2 BEARING, NEEDLE
5 358908A1 1 WASHER, THRUST
6 S5070S00F 1 BEARING, NEEDLE
7 S5040S00F 4 RING, Retaining
8 362611A1 1 SPACER, Needle Bearing
9 364826A1 8 PLATE, Spring
10 87350331 1 WASHER, THRUST
11 87350374 1 GEAR, DRIVEN, 5F
12 370568A1 1 CARRIER, Piston
13 S4150S00F 4 RING, Seal
Pages: 1 2 3 4 5

Leave a Reply

Your email address will not be published. Required fields are marked *