John Deere 9410 Maximaizer Combine
John Deere 9410 Maximaizer Combine — parts list, part 3 of 5
Assemblies on this page: SIX STACK SOLENOID CONTROL VALVE MODULE ASSEMBLY AND MOUNTINGS – CONTINUED … THRESHING AND SEPARATION.
SIX STACK SOLENOID CONTROL VALVE MODULE ASSEMBLY AND MOUNTINGS – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | R77175 | 1 | COVER |
| 2 | AH125760 | 1 | HYD. QUICK-CONNECT COUPLER |
| 3 | R26448 | 1 | O-RING |
| 6 | H149803 | 3 | TIE ROD |
| 7 | H139513 | 1 | BRACKET |
| 8 | AH131405 | 2 | SEAL |
| 9 | AH131326 | 10 | SEAL |
| 10 | AH147086 | 1 | VALVE |
| 11 | AH147086 | 1 | VALVE |
| 12 | AH147086 | 1 | VALVE |
| 13 | AH139060 | 1 | VALVE |
| 14 | AH147084 | 1 | VALVE |
| 15 | AH147097 | 1 | VALVE |
| 16 | H139512 | 1 | BRACKET |
| 17 | H135777 | 2 | ORIFICE |
| 18 | M71770 | 4 | SCREW |
| 20 | AH124731 | 11 | ELECTRICAL COIL |
| 21 | E62942 | 11 | COVER |
| 22 | H135898 | 1 | COVER |
| 26 | H139515 | 2 | MANIFOLD |
| 27 | AH134733 | 2 | SEAL |
| 28 | E62917 | 1 | ORIFICE |
| 29 | H145052 | 1 | APERTURE |
| 30 | H145051 | 1 | APERTURE |
| 31 | H150062 | 1 | COVER |
| 33 | H149804 | 2 | ORIFICE |
SOLENOID CONTROL VALVE BRACKETS
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 3 | H159291 | 1 | BRACKET |
| H166148 | 1 | BRACKET | |
| 5 | H158638 | 1 | BRACE |
MAIN HYDRAULIC PUMP – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| H135569 | 8 | CAP SCREW | |
| 2 | H131121 | 1 | GASKET |
| 9 | H116213 | 8 | DOWEL PIN |
| 10 | H80821 | 4 | O-RING |
| 12 | H125929 | 1 | SHAFT KEY |
| 20 | R26448 | 1 | O-RING |
| 21 | AH125760 | 1 | HYD. QUICK-CONNECT COUPLER |
| 22 | R77175 | 1 | COVER |
| 23 | M48869 | 2 | WASHER |
| 26 | AH131182 | 1 | HYDRAULIC PUMP |
| AH131183 | 1 | HYDRAULIC PUMP | |
| 28 | H121973 | 1 | SHAFT KEY |
REEL / BELT PICKUP DRIVE PUMP – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | E61791 | 8 | BOLT |
| 2 | M41029 | 1 | SNAP RING |
| 3 | AH131842 | 1 | SEAL |
| 4 | M48869 | 1 | WASHER |
| 10 | H116213 | 4 | DOWEL PIN |
| 11 | H80821 | 2 | O-RING |
| 12 | N34986 | 1 | SHAFT KEY |
| 13 | AH131304 | 1 | SHAFT |
| 17 | AH131178 | 1 | HYDRAULIC PUMP |
UNLOADING AUGER SWING CYLINDER LINES AND HOSES – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH128641 | 1 | HYDRAULIC LINE |
| 3 | T81029 | 2 | NUT |
| 4 | T77613 | 8 | O-RING |
| 5 | AH130581 | 2 | HYDRAULIC HOSE |
| 7 | R26448 | 2 | O-RING |
| 8 | R26375 | 2 | O-RING |
| 10 | H108745 | 3 | CLAMP |
| 11 | AH128642 | 1 | HYDRAULIC LINE |
| 12 | AH128855 | 1 | HYDRAULIC LINE |
| 13 | AH128854 | 1 | HYDRAULIC LINE |
GRAIN TANK UNLOADING DRIVE CYLINDER WITH MOUNTING AND HOSE – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H129588 | 1 | BRACKET |
| 3 | H98765 | 1 | PIN |
| 6 | T77613 | 2 | O-RING |
| 7 | AH120160 | 1 | HYDRAULIC HOSE |
| 8 | AH96317 | 1 | CLIP |
| 9 | AH116006 | 1 | HYDRAULIC CYLINDER |
| 10 | H133688 | 2 | STOP |
| 12 | H133690 | 1 | BRACKET |
| 13 | J16931 | 1 | SPRING LOCKING PIN |
| 14 | R26448 | 1 | O-RING |
| 15 | H148340 | 1 | PIN |
UNLOADING AUGER SWING CYLINDER AND MOUNTING – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H150926 | 1 | EYEBOLT |
| 13 | H150920 | 1 | ROD |
| 14 | L36230 | 1 | BALL |
| 19 | R56930 | 1 | PIN |
| 20 | AH146043 | 1 | KIT |
| 21 | AH145030 | 1 | HYDRAULIC CYLINDER |
TILT CYLINDER – CONTOUR MASTER
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH144482 | 1 | ROD |
| 2 | P45750 | 1 | O-RING |
| T22828 | 1 | O-RING | |
| 3 | H150411 | 1 | SEAL |
| 4 | R90565 | 1 | SNAP RING |
| 5 | H169509 | 1 | BACK-UP RING |
| 6 | H150412 | 1 | SEAL |
| 7 | R82571 | 1 | SNAP RING |
| 8 | H151629 | 1 | WEAR RING |
| 9 | R79117 | 1 | WASHER |
| 10 | H158942 | 1 | O-RING |
| 11 | H151694 | 1 | HYDR. CYLINDER ROD GUIDE |
| 12 | H144342 | 1 | PISTON RING |
| 13 | AH138200 | 1 | PISTON |
| 15 | AH144480 | 1 | HYDRAULIC CYLINDER BARREL |
| 16 | AH143322 | 1 | HYDRAULIC CYLINDER |
TILT CYLINDER HOSES AND FITTINGS – CONTOUR MASTER
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH143682 | 2 | HYDRAULIC HOSE |
| 5 | R56930 | 2 | PIN |
| 6 | R28782 | 1 | O-RING |
| 8 | T77814 | 1 | O-RING |
| 9 | R26448 | 1 | O-RING |
| 11 | T77613 | 1 | O-RING |
| 12 | AH143322 | 1 | HYDRAULIC CYLINDER |
WET CLUTCH OIL COOLER LINES AND HOSES – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H151585 | 2 | CLAMP |
| 2 | T77932 | 5 | O-RING |
| 4 | H112567 | 3 | PLATE |
| 5 | H150983 | 6 | CLAMP |
| 6 | AH145239 | 1 | HYDRAULIC HOSE |
| 7 | AH145241 | 1 | HYDRAULIC HOSE |
| 8 | H150980 | 3 | BRACKET |
| 11 | AH128780 | 1 | HYDRAULIC HOSE |
| 12 | AH128779 | 1 | HYDRAULIC HOSE |
| 13 | T77857 | 3 | O-RING |
| 15 | U12547 | 2 | O-RING |
OIL COOLER AND A/C CONDENSER – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH149588 | 1 | OIL COOLER |
| 4 | AH149618 | 1 | VAPOR CONDENSER |
| 7 | H162584 | 1 | BRACKET |
| 8 | H162585 | 1 | BRACKET |
| 9 | H158596 | 1 | STOP |
| 10 | T77932 | 2 | O-RING |
| 11 | T77858 | 2 | O-RING |
ENGINE GEARCASE OIL FILTER ASSEMBLY – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | R26906 | 1 | O-RING |
| 5 | AH128451 | 1 | VALVE |
| 9 | R26448 | 1 | O-RING |
| 10 | AH128450 | 1 | TOUCH SWITCH |
| 11 | AH128449 | 1 | HYDRAULIC FILTER |
| 12 | AH139434 | 1 | HYDRAULIC FILTER |
| 13 | H133675 | 1 | BRACKET |
ENGINE GEARCASE PRESSURE REGULATOR – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | R33138 | 1 | FITTING |
| 2 | R26375 | 4 | O-RING |
| 3 | H89241 | 1 | SPRING |
| 4 | R28776 | 2 | O-RING |
| 5 | R63980 | 3 | VALVE |
| 6 | R56782 | 1 | SPRING |
| 7 | H126026 | 1 | FITTING |
| 9 | AH116105 | 1 | SWITCH |
| R78059 | 1 | ELECTRICAL PLUG | |
| 10 | R26448 | 4 | O-RING |
| 11 | AH125760 | 1 | HYD. QUICK-CONNECT COUPLER |
| 12 | R77175 | 1 | COVER |
| 13 | R27218 | 2 | FITTING PLUG |
| 14 | R28782 | 1 | O-RING |
| 15 | AH135744 | 1 | SWITCH |
| RE12363 | 1 | CONNECTOR | |
| R78063 | 1 | TERMINAL NIPPLE | |
| R78060 | 1 | SOCKET CONTACT | |
| 17 | R26906 | 2 | O-RING |
| 19 | H132970 | 1 | HOUSING |
| 20 | H129328 | 1 | GASKET |
| 22 | H118906 | 1 | COVER |
| 23 | H129765 | 1 | GASKET |
| 24 | T77514 | 1 | PISTON |
| 26 | R47449 | 1 | SPRING |
| 27 | T45132 | 1 | SPRING |
| 28 | AH128655 | 2 | SOLENOID VALVE |
| 29 | U12547 | 1 | O-RING |
| 32 | T60314 | 1 | SPRING |
| 34 | H126028 | 1 | FITTING |
SOLENOID CONTROL VALVE FOR WET CLUTCH PRESSURE REGULATOR
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | R42926 | 1 | BACK-UP RING |
| 2 | T77857 | 1 | O-RING |
| 3 | R45187 | 1 | BACK-UP RING |
| 4 | R45638 | 1 | O-RING |
| 5 | R46701 | 1 | SNAP RING |
| 8 | N31772 | 1 | O-RING |
| 10 | R64698 | 1 | SPRING |
| 11 | U12547 | 1 | O-RING |
| 13 | M63707 | 1 | LOCK NUT |
| 14 | AH128654 | 1 | ELECTRICAL COIL |
| R78053 | 1 | PIN CONTACT CONNECTOR BODY | |
| R78059 | 1 | ELECTRICAL PLUG | |
| R78061 | 1 | PIN CONTACT | |
| 15 | AH130949 | 1 | SOLENOID VALVE |
| 16 | AH128655 | 1 | SOLENOID VALVE |
HYDRAULIC FLAT O-RING KIT – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | T77814 | 10 | O-RING |
| 2 | T77613 | 12 | O-RING |
| 3 | T77857 | 12 | O-RING |
| 4 | T77932 | 12 | O-RING |
| 5 | T77858 | 12 | O-RING |
| 6 | T76938 | 12 | O-RING |
| 7 | T78612 | 5 | O-RING |
| 8 | T78784 | 5 | O-RING |
| 9 | T78313 | 6 | O-RING |
| 10 | AT85197 | 1 | O-RING KIT |
CHARGE PRESSURE HOSE – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | R26448 | 4 | O-RING |
| 4 | T77613 | 2 | O-RING |
| 5 | AH128894 | 1 | HYDRAULIC HOSE |
| 6 | R27218 | 2 | FITTING PLUG |
| 7 | R26375 | 1 | O-RING |
| 8 | R39112 | 1 | FITTING |
| 9 | H139448 | 1 | FITTING |
| 10 | R26448 | 1 | O-RING |
| 11 | AH128929 | 1 | SWITCH |
SEPARATOR FRAME- CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H158749 | 2 | RETAINER |
| 4 | AH132361 | 2 | CROSSBAR |
| 8 | H132539 | 1 | COVER |
| 10 | H130349 | 2 | COVER |
| 13 | H89544 | 4 | DOOR |
| 17 | P47159 | 4 | CLAMP |
| 19 | H120379 | 4 | SPACER |
| 20 | H132926 | 4 | PLUG |
| 21 | H140866 | 1 | CLAMP |
| 22 | H148000 | 1 | PLUG |
| 23 | AH140485 | 1 | BRACKET |
| AH140484 | 1 | BRACKET | |
| 24 | H144715 | 1 | SHIELD |
| H144716 | 1 | SHIELD | |
| 25 | H144717 | 1 | SHIELD |
| 30 | H160265 | 2 | REINFORCEMENT |
HP4863 -UN-01JAN94
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH129452 | 1 | ECCENTRIC LOCKING COLLAR |
| 2 | E10018 | 2 | PRESSED FLANGED HOUSING |
| 3 | AH129451 | 1 | BALL BEARING |
| 4 | H102533 | 1 | SHIM |
HP4864 -UN-01JAN94
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H145700 | 1 | ANGLE |
| 3 | H146057 | 2 | REINFORCEMENT |
| 4 | AH139570 | 1 | REINFORCEMENT |
| 5 | AH139571 | 1 | REINFORCEMENT |
ENGINE ACCESS DOOR, HANDRAILS, AND RADIATOR DOOR – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH136163 | 1 | DOOR |
| 2 | AH126015 | 1 | PANEL |
| 3 | AH126016 | 1 | HANDRAIL |
| 5 | AH125686 | 1 | HANDRAIL |
| E64256 | 1 | LOCK NUT | |
| 10 | H132511 | 1 | STOP |
| 14 | H134072 | 1 | ANGLE |
| 15 | H134073 | 1 | STOP |
| 18 | H130246 | 2 | HINGE |
| 19 | AH125575 | 2 | PLATE |
| 23 | H133042 | 1 | PIN |
| 28 | H130967 | 1 | REINFORCEMENT |
| 29 | Z39238 | 2 | FOAM PAD |
| 33 | H132992 | 2 | PLATE |
| 34 | H134403 | 1 | REINFORCEMENT |
| 35 | H130968 | 3 | ANGLE |
RADIATOR SHELL AND SEALS – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH151333 | 1 | SHEET |
| AH156349 | 1 | SHEET | |
| 3 | H160360 | 1 | BRACKET |
| 4 | H116740 | 9 | PLUG |
| 5 | H154195 | 1 | SEAL |
| 6 | AH130515 | 1 | CHANNEL |
| AH139255 | 1 | CHANNEL | |
| AH139384 | 1 | CHANNEL | |
| 8 | AH96317 | 1 | CLIP |
| 10 | H162138 | 1 | BRACKET |
| 14 | H88769 | 1 | ISOLATOR |
| 16 | R62356 | 1 | GROMMET |
| R66718 | 1 | GROMMET | |
| R71351 | 1 | GROMMET | |
| 17 | H146260 | 1 | CHANNEL |
| 18 | H134520 | 1 | SEAL |
| 19 | AH140967 | 1 | ACOUSTICAL UPHOLSTERY |
| 20 | AH140967 | 2 | ACOUSTICAL UPHOLSTERY |
| 21 | H128502 | 1 | SEAL |
| 24 | AH131965 | 1 | ISOLATOR |
| 25 | H143465 | 1 | AIR DUCT |
| 26 | AH87272 | 1 | LATCH |
| 28 | H134527 | 1 | SHEET |
| 29 | H134913 | 2 | HINGE |
| 30 | AH131301 | 1 | BRACKET |
| 32 | H134915 | 1 | DOOR |
| 33 | H134917 | 1 | PIN |
| 34 | AH156168 | 1 | FRAME |
ENGINE COMPARTMENT – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H134106 | 1 | PANEL |
| 3 | H128744 | 1 | ANGLE |
| 5 | AH162073 | 1 | CHANNEL |
| 6 | AH136616 | 1 | BRACE |
| 8 | AH136455 | 1 | DOOR |
| 9 | H134738 | 1 | HINGE |
| 10 | H134930 | 1 | PIN |
| 14 | AH152323 | 1 | CHANNEL |
| 15 | H141836 | 2 | BUSHING |
| 16 | H135147 | 1 | TUBE |
| 17 | AH129228 | 1 | LADDER |
| 18 | AH130497 | 1 | PLATE |
| 19 | H134073 | 1 | STOP |
| 20 | H137267 | 1 | REINFORCEMENT |
| 21 | H135610 | 1 | DEFLECTOR |
| 22 | AH136046 | 1 | PANEL |
| 27 | H136577 | 1 | CLAMP |
| 1 | H131526 | 2 | ANGLE |
| 3 | H134102 | 1 | CHANNEL |
| 4 | H134108 | 1 | GUSSET |
| 6 | H135148 | 1 | HALF CLAMP |
| 7 | AH164364 | 1 | FRAME |
| 9 | H150317 | 1 | SHEET |
| 10 | AH122244 | 1 | ISOLATOR |
| 11 | H130057 | 1 | PIN |
| 12 | AH130506 | 1 | DOOR |
| 13 | H131743 | 2 | MAT |
| 14 | H134506 | 1 | HINGE |
| 15 | H137261 | 1 | SUPPORT |
| H165585 | 1 | SUPPORT | |
| 16 | H135393 | 1 | STRAP |
| 19 | AH136047 | 1 | PANEL |
| 20 | H135392 | 1 | STRAP |
| 21 | H140225 | 1 | SUPPORT |
| H165587 | 1 | SUPPORT | |
| 23 | H134107 | 2 | GUSSET |
| 24 | H135245 | 1 | HOOK |
| 25 | H134105 | 1 | GUSSET |
| 27 | H136015 | 1 | MAT |
| 28 | H136014 | 1 | MAT |
ENGINE ACCESS PLATFORM AND STEP – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H130424 | 1 | ANGLE |
| 3 | AH156186 | 1 | PLATFORM |
| 5 | H130432 | 1 | BRACE |
| 6 | H130431 | 1 | PANEL |
| 10 | H131526 | 1 | ANGLE |
| 11 | AH125685 | 1 | PANEL |
| 12 | H130425 | 1 | ANGLE |
| 13 | AH127837 | 1 | STEP |
| 14 | H134081 | 1 | SUPPORT |
REAR LADDER AND LANDING – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H130555 | 4 | STRIP |
| 3 | H141123 | 5 | NUT |
| 5 | H129885 | 1 | ANGLE |
| 6 | AH137254 | 1 | SUPPORT |
| 8 | AH120216 | 1 | ADJUSTER |
| 11 | AH139782 | 1 | LADDER |
| 13 | H120082 | 1 | LATCH |
| 15 | AH130193 | 1 | CHANNEL |
| 16 | AH125788 | 1 | BRACKET |
| 17 | AH135298 | 1 | PLATFORM |
| 18 | H142035 | 1 | CATCH |
| 19 | H133152 | 1 | BRACKET |
| 23 | H119411 | 2 | PIN |
| 24 | T40867 | 2 | BUSHING |
| 25 | Z39386 | 1 | WASHER |
| 27 | H129004 | 1 | ANGLE |
| 28 | A31867 | 1 | LOCK NUT |
REAR LADDER LANDING LATCH ARM – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H140881 | 1 | CATCH |
| 5 | H140872 | 1 | PIN |
| 7 | AH135300 | 1 | ARM |
REAR HOOD – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH158264 | 1 | HOOD |
| AH161521 | 1 | HOOD | |
| 5 | AH135479 | 1 | SHEET |
| AH135478 | 1 | SHEET | |
| 6 | H149096 | 2 | LABEL |
| 7 | H150749 | 1 | REINFORCEMENT |
| 9 | AH135482 | 1 | SHEET |
| H141088 | 1 | DEFLECTOR | |
| 12 | H171977 | 6 | SCREW |
| 13 | AH125793 | 4 | WEATHERSTRIP |
| 14 | AH158265 | 1 | PANEL |
| AH158266 | 1 | PANEL |
AUGER DRIVE SHIELDS (R.H. SIDE) – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H141772 | 1 | SHIELD |
| 4 | AH146783 | 1 | SHIELD |
| 5 | H141770 | 1 | SHIELD |
| 7 | H146756 | 1 | STRAP |
MUD AND FAN DRIVE SHIELDS (L.H. SIDE) – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | AH130941 | 1 | BRACKET |
| 3 | R46414 | 1 | CLAMP |
| 5 | AH130945 | 1 | BRACKET |
| 6 | AH130944 | 1 | BRACKET |
| 9 | AH125820 | 1 | SHIELD |
| 10 | H154757 | 1 | STUD |
| 12 | H85184 | 1 | HANDLE |
| 13 | H140300 | 1 | SHIELD |
| 14 | AH128914 | 1 | BRACKET |
| 15 | AH130197 | 1 | BRACKET |
| 16 | A15147 | 1 | SPRING LOCKING PIN |
DRIVE SHIELD (R.H. REAR) – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H141813 | 1 | BRACKET |
| 3 | H130930 | 1 | SPRING |
| 4 | AH146361 | 1 | SHIELD |
R.H. SERVICE ACCESS SHIELD- CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH166713 | 1 | CHANNEL |
| 4 | H125537 | 2 | PLATE |
| 5 | H139056 | 1 | BRACKET |
| 7 | AH128596 | 2 | GAS OPERATED CYLINDER |
| 8 | H135965 | 1 | STOP |
| 9 | AH151894 | 1 | DOOR |
| 10 | M68701 | 1 | GROMMET |
| 11 | H152048 | 1 | DEFLECTOR |
| 12 | H132822 | 2 | ANGLE |
| 13 | H143453 | 2 | FOAM PAD |
| 14 | H143454 | 2 | BRACKET |
| 16 | H129833 | 1 | BRACKET |
L.H. SERVICE ACCESS SHIELD- CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH166714 | 1 | CHANNEL |
| 4 | H125537 | 2 | PLATE |
| 5 | H132008 | 1 | CHANNEL |
| 6 | AH127275 | 1 | CHANNEL |
| 8 | AH127704 | 1 | DOOR |
| 10 | AH128598 | 1 | GAS OPERATED CYLINDER |
| 11 | H135965 | 1 | STOP |
| 12 | AH128597 | 1 | GAS OPERATED CYLINDER |
| 13 | H127677 | 1 | BRACKET |
| 14 | M68701 | 1 | GROMMET |
| 15 | H152047 | 1 | DEFLECTOR |
| 16 | H132822 | 2 | ANGLE |
| 17 | H143453 | 3 | FOAM PAD |
| 18 | H143454 | 3 | BRACKET |
FRONT CORNER SHEET, RIGHT HAND – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH147092 | 1 | PANEL |
| 4 | H127410 | 1 | BRACE |
| 7 | H127408 | 1 | BRACE |
| 10 | H137447 | 2 | NUT |
REAR CORNER SHEET, LEFT HAND – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 4 | H132948 | 1 | BRACE |
| 6 | H131543 | 1 | BRACKET |
| 7 | H144029 | 1 | BRACKET |
| 8 | AH158487 | 1 | PANEL |
| 10 | H132949 | 1 | BRACE |
| 11 | AH126564 | 1 | BRACE |
| 12 | H137534 | 5 | STRAP |
| 15 | H126672 | 1 | BRACKET |
| 17 | AH128598 | 1 | GAS OPERATED CYLINDER |
| 18 | H164757 | 1 | PLUG |
LEFT – HAND FRONT CORNER SHEET AND DOOR – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH125641 | 1 | DOOR |
| 2 | AH141743 | 1 | PANEL |
| 3 | H130364 | 1 | ANGLE |
| 6 | H130363 | 1 | BRACKET |
| 7 | AH146041 | 2 | SAFETY CHAIN |
| 8 | H131628 | 1 | BRACKET |
| 11 | AH146041 | 2 | SAFETY CHAIN |
| 12 | B32630 | 2 | SPRING LOCKING PIN |
| 14 | H120499 | 2 | NUT |
| 15 | H121391 | 1 | KNOB |
| 16 | H64584 | 1 | RIVET |
| 17 | AH125644 | 1 | LATCH |
| 18 | H130362 | 1 | ANGLE |
MUD SHIELDS (R.H. SIDE) – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H85184 | 2 | HANDLE |
| 4 | H130636 | 2 | STUD |
| 7 | M72598 | 1 | QUICK LOCK PIN |
| 8 | H141979 | 1 | BRACKET |
| 11 | H127732 | 1 | GUIDE |
| 13 | H150746 | 1 | PIN |
| 17 | H127731 | 1 | GUIDE |
| H152135 | 1 | GUIDE | |
| 18 | AH136285 | 1 | BRACKET |
| 19 | H146757 | 1 | BRACKET |
| 21 | AH126352 | 1 | SHIELD |
| 22 | H131876 | 1 | BRACKET |
| 23 | AH155669 | 1 | BRACKET |
| 24 | AH126620 | 1 | SHIELD |
LEFT SIDE FRONT SHIELD – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH151344 | 1 | BRACKET |
| 2 | AH151346 | 1 | CHANNEL |
| 4 | AH151339 | 1 | BRACKET |
| 6 | H85184 | 1 | HANDLE |
| 7 | AH135290 | 3 | QUICK LOCK PIN |
| 8 | AH158151 | 1 | SHIELD |
| 9 | AH151340 | 1 | SHIELD |
| 11 | AH151338 | 1 | BRACKET |
| 12 | H164508 | 1 | ANGLE |
RIGHT SIDE SHIELD ASSEMBLY – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | AH151351 | 1 | SHIELD |
| 3 | AH151353 | 1 | CABLE |
| 4 | M93425 | 2 | SPACER |
| 7 | H158646 | 1 | SHIELD |
| 8 | AH159061 | 1 | SHIELD |
| 11 | AH154401 | 1 | SHIELD |
| 12 | AH135290 | 2 | QUICK LOCK PIN |
| 13 | H85184 | 2 | HANDLE |
| 14 | H165320 | 1 | SHIELD |
LEFT SIDE SHIELD ASSEMBLY – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H158614 | 1 | BRACKET |
| 3 | H158633 | 1 | SHIELD |
| 4 | AH151347 | 1 | SUPPORT |
| 6 | AH151342 | 1 | SHIELD |
| 8 | H160733 | 1 | STRIP |
| 9 | H158627 | 1 | CHANNEL |
| 11 | AH151343 | 1 | SHIELD |
| 12 | H158616 | 1 | SHIELD |
RIGHT SIDE FRONT SHIELD ASSEMBLY – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H160978 | 1 | SHIELD |
| 4 | AH151352 | 1 | BRACKET |
| 5 | AH151349 | 1 | SHIELD |
| 6 | H160187 | 1 | GUIDE |
| 8 | AH154567 | 1 | SHIELD |
CAB PANELS AND FLOOR MAT – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H131298 | 1 | PLATE |
| 2 | H131299 | 3 | PLATE |
| 5 | H133665 | 1 | SHEET |
| 6 | H124260 | 1 | PLATE |
| 7 | H133666 | 1 | SHEET |
| 10 | AH159079 | 1 | MAT |
| 11 | H131301 | 1 | SEAL |
| 13 | H131300 | 1 | GROMMET |
| 14 | AH89557 | 1 | CLIP |
| AH90990 | 1 | CLIP | |
| 15 | H141292 | 1 | PLATE |
CAB SOUND DEADENING, FOAM AND SEALS – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H125511 | 1 | FOAM PAD |
| 2 | AH127674 | 1 | BARRIER |
| 3 | H129606 | 2 | RETAINER |
| 4 | H114523 | 2 | SEAL |
| 5 | H114525 | 1 | GASKET |
| 7 | AH80335 | 1 | WEATHERSTRIP |
| 8 | AH149631 | 1 | BARRIER |
| 9 | AH149374 | 1 | BARRIER |
| AH149373 | 1 | BARRIER | |
| 10 | R50456 | 1 | GROMMET |
| 11 | H36221 | 1 | GROMMET |
CAB REAR AND SIDE SEALS – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H135614 | 2 | SEAL |
| 2 | H133391 | 1 | BRACKET |
| 4 | AH141774 | 1 | SEAL |
| 5 | H85233 | 16 | RIVET |
| 6 | H135615 | 2 | RETAINER |
CAB INTERIOR TRIM PANELS – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH153911 | 1 | HEADLINER |
| AH120887 | 1 | HEADLINER | |
| 2 | AH149883 | 1 | HEADLINER |
| 3 | H168431 | 1 | BEZEL |
| 4 | H119088 | 12 | SCREW |
| 5 | AH120891 | 1 | PANEL |
| 6 | AH146854 | 1 | PANEL |
| 7 | AH120890 | 1 | PANEL |
| 8 | AH152873 | 1 | HEADLINER |
| 9 | H124210 | 1 | COVER |
| 10 | H132452 | 2 | CAP SCREW |
| 11 | AH151123 | 1 | SUN VISOR |
CAB DOOR LATCH – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | RE35161 | 1 | HANDLE |
| 2 | H126082 | 1 | BEZEL |
| 3 | H126081 | 1 | BEZEL |
| 4 | H126083 | 1 | ISOLATOR |
| 5 | H133414 | 1 | SUPPORT |
| 9 | H134671 | 1 | EXTENSION SPRING |
| 10 | H150047 | 1 | HOUSING |
| 11 | H145893 | 1 | BUMPER |
| 12 | AH140838 | 1 | HANDLE |
| 13 | AH128585 | 1 | LATCH |
| 15 | H136589 | 1 | BOLT |
| 17 | H133219 | 1 | ADJUSTING STRAP |
| 18 | H107566 | 1 | ISOLATOR |
| 19 | H136056 | 1 | PIN |
| 20 | H136590 | 1 | DISK SPRING |
CAB GLASS AND DOOR – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | AH106010 | 1 | WEATHERSTRIP |
| 3 | H123794 | 1 | WINDOWPANE |
| 4 | H138297 | 1 | TIE BAND |
| 5 | H134535 | 1 | LABEL |
| 6 | H125769 | 1 | WINDOWPANE |
| 8 | AH154280 | 1 | DOOR |
| 9 | H131720 | 1 | RAIL |
| 12 | AH132819 | 2 | BRACKET |
| 13 | AH141412 | 1 | KIT |
| AH132117 | 1 | WINDSHIELD | |
| 14 | H145982 | 1 | LABEL |
| 15 | AH80335 | 1 | WEATHERSTRIP |
CAB FRAME AND SUPPORT – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 4 | AH141161 | 1 | SUPPORT |
| 6 | AH130594 | 1 | STEP |
| 8 | H96690 | 2 | SPACER |
| 11 | AH108299 | 4 | RUBBER MOUNT |
| 15 | AH132148 | 1 | SHIELD |
| 18 | H149480 | 1 | LABEL |
| 19 | H98111 | 8 | NUT |
| 21 | AH130595 | 1 | STEP |
| 23 | H162748 | 1 | SCREW |
CAB ROOF AND SUPPORTS – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH153796 | 1 | ROOF |
| 5 | H123991 | 2 | SEALING WASHER |
| 7 | H123995 | 27 | SCREW |
| 8 | H143460 | 1 | COVER |
| 9 | H144472 | 2 | SUPPORT |
| 10 | H130301 | 2 | COVER |
| 11 | AH124882 | 2 | WIRING LEAD |
| 12 | H114038 | 4 | SCREW |
| 13 | AH136557 | 1 | SUPPORT |
| AH154696 | 1 | SUPPORT | |
| 14 | H116188 | 4 | SCREW |
| 15 | H130303 | 1 | COVER |
| 16 | H123796 | 1 | GROMMET |
| 18 | H123740 | 4 | STUD |
OPERATOR’S PIVOTING PLATFORM AND HANDRAILS – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH148181 | 1 | HANDRAIL |
| AH148182 | 1 | HANDRAIL | |
| H136142 | 1 | HANDRAIL | |
| H167173 | 1 | HANDRAIL | |
| H136143 | 1 | HANDRAIL | |
| H167174 | 1 | HANDRAIL | |
| AH148170 | 1 | HANDRAIL | |
| AH148171 | 1 | HANDRAIL | |
| AH160474 | 1 | HANDRAIL | |
| AH131844 | 1 | HANDRAIL | |
| AH160472 | 1 | HANDRAIL | |
| AH131845 | 1 | HANDRAIL | |
| AH160473 | 1 | HANDRAIL | |
| 3 | AH148183 | 1 | HANDRAIL |
| H131626 | 1 | HANDRAIL | |
| AH160469 | 1 | HANDRAIL | |
| 6 | H129610 | 2 | BUSHING |
| 7 | H111478 | 2 | SLEEVE |
| 8 | AH133498 | 1 | EXTENSION |
| AH159185 | 1 | EXTENSION | |
| AH133499 | 1 | EXTENSION | |
| AH133500 | 1 | EXTENSION | |
| AH159187 | 1 | EXTENSION | |
| AH157029 | 1 | EXTENSION | |
| AH159186 | 1 | EXTENSION |
OPERATOR’S PLATFORM LADDER AND LATCH – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H137360 | 2 | EXTENSION SPRING |
| 4 | H129761 | 1 | BUSHING |
| 5 | H129760 | 1 | PIN |
| 8 | R60730 | 1 | SPRING |
| 10 | H129763 | 2 | BRACKET |
| 13 | H133514 | 1 | LEVER |
| 15 | AH128610 | 1 | LATCH |
| 16 | AH165990 | 1 | LADDER |
| 17 | H136011 | 1 | STEP |
| 19 | H136127 | 4 | PLATE |
| 21 | H136126 | 2 | HANGER |
TOOL BOX – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AT22070 | 1 | TOOLBOX |
| 2 | T23027 | 1 | PIN |
| 3 | AT22073 | 1 | HOLDER |
| 6 | T23033 | 1 | BRACKET |
| 8 | AH145157 | 1 | BRACKET |
| 10 | H150951 | 2 | BRACE |
CAB LEFT-HAND LANDING AND MIRROR – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH141804 | 1 | RAIL |
| AH160115 | 1 | HANDRAIL | |
| 2 | AZ49140 | 1 | REAR VIEW MIRROR |
| 3 | AH122099 | 1 | BUMPER |
| 7 | H130362 | 1 | ANGLE |
| 9 | AH141812 | 1 | PLATFORM |
| 12 | H172944 | 1 | PLATE |
| 14 | H136110 | 4 | ISOLATOR |
| 15 | H161289 | 4 | CLAMP |
| 22 | AH142404 | 1 | REAR VIEW MIRROR |
CAB LANDING AND MIRROR (R.H.) – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 4 | AZ42315 | 1 | REAR VIEW MIRROR |
| AH142404 | 1 | REAR VIEW MIRROR | |
| 9 | H137447 | 3 | NUT |
| 10 | H134724 | 1 | SUPPORT |
| 11 | AH137725 | 1 | SUPPORT |
| 12 | H134536 | 1 | RAIL |
| H134537 | 1 | RAIL | |
| 14 | AH130586 | 1 | SHIELD |
| 21 | AH142404 | 1 | REAR VIEW MIRROR |
| 22 | H120659 | 1 | ANGLE |
CAB AIR FILTER AND HOUSING
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH115833 | 1 | AIR FILTER |
| 2 | AH132783 | 1 | NUT |
| 3 | R58806 | 1 | SNAP RING |
| 4 | AH120419 | 1 | DOOR |
| 5 | AH120446 | 1 | KNOB |
AIR CONDITIONING AND HEATER DUCTS
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H168429 | 1 | HOUSING |
| 2 | AH161926 | 6 | GRILLE |
| 6 | H130515 | 1 | AIR DUCT |
| H168430 | 1 | HOUSING |
FEEDER HOUSE REVERSER FOOT CONTROL – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | R65569 | 1 | PIN |
| 4 | H134489 | 1 | BEZEL |
| H153480 | 1 | BEZEL | |
| 5 | H134488 | 1 | PEDAL |
| H153479 | 1 | PEDAL | |
| 7 | H133210 | 1 | SEAL |
| 8 | T16193 | 1 | PIN |
| 9 | H130646 | 1 | YOKE |
| 11 | H133208 | 1 | SUPPORT |
| 12 | AH128452 | 1 | PUSH PULL CABLE |
| 13 | R73384 | 1 | CLAMP |
| 14 | AH127383 | 1 | YOKE |
| 16 | H84948 | 1 | SPRING |
| 17 | H127749 | 1 | BOLT |
| 18 | AE23791 | 1 | CHAIN LINK |
| 19 | H140836 | 1 | BELLCRANK |
| 2 | R65569 | 1 | PIN |
| 4 | H134489 | 1 | BEZEL |
| 5 | H134488 | 1 | PEDAL |
| 7 | H133210 | 1 | SEAL |
| 8 | T16193 | 1 | PIN |
| 9 | H130646 | 1 | YOKE |
| 11 | H133208 | 1 | SUPPORT |
| 12 | AH128452 | 1 | PUSH PULL CABLE |
| 13 | R73384 | 1 | CLAMP |
| 14 | AH127383 | 1 | YOKE |
| 16 | H84948 | 1 | SPRING |
| 17 | H127749 | 1 | BOLT |
| 18 | AE23791 | 1 | CHAIN LINK |
| 19 | H140836 | 1 | BELLCRANK |
SEAT SHROUDS AND PASSENGER SEAT – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH134724 | 1 | BOX |
| 2 | AH161928 | 1 | CONSOLE |
| AH156642 | 1 | CONSOLE | |
| 3 | H165691 | 10 | SCREW |
| 4 | H168433 | 1 | CONTAINER |
| 5 | H160596 | 1 | COVER |
| H167912 | 1 | SPINDLE | |
| 7 | AH147066 | 1 | SEAT |
| 8 | AH138111 | 1 | SEAT |
| 9 | H168781 | 6 | STUD |
| 11 | H132451 | 3 | CAP SCREW |
| 12 | H137823 | 1 | PANEL |
| 13 | H161091 | 1 | BEZEL |
| H168432 | 1 | BEZEL |
OPERATOR’S SEAT AND BACKREST – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AR71107 | 1 | CUSHION |
| 2 | R59019 | 2 | SCREW |
| 4 | R89143 | 1 | SUPPORT |
| 5 | R59015 | 4 | GANG BOLT |
| 6 | N10215 | 8 | LOCK NUT |
| 7 | AH145065 | 1 | SEAT |
| 8 | AH127662 | 1 | SWITCH |
| 9 | R60458 | 1 | KNOB |
| 10 | R89142 | 1 | SUPPORT |
| 11 | R59009 | 1 | REINFORCEMENT |
| 12 | R59012 | 1 | WELD STUD |
| 13 | R105581 | 1 | ADJUSTER |
| 14 | R59018 | 1 | BUSHING |
| 15 | R31890 | 2 | SPRING |
| 16 | R59011 | 1 | PLATE |
| 18 | AR71108 | 1 | PLATE |
| 19 | AR71109 | 1 | PLATE |
| 20 | H99923 | 2 | LOCK NUT |
| 21 | R53665 | 2 | WASHER |
| 24 | RE13541 | 1 | KIT |
| 25 | R78053 | 1 | PIN CONTACT CONNECTOR BODY |
| R78063 | 1 | TERMINAL NIPPLE | |
| R78058 | 1 | PIN CONTACT |
OPERATOR’S SEAT SEATBELT
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH146742 | 1 | SEAT BELT |
| 3 | AH147030 | 1 | BRACKET |
TRAINING SEAT SEATBELT
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH147153 | 1 | SEAT BELT |
SEAT ADJUST FORE AND AFT – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH116313 | 1 | PLATE |
| 2 | AH110674 | 2 | BRACKET |
| 7 | H96391 | 1 | PIN |
| 8 | AH122648 | 2 | ADJUSTER |
| 9 | H115987 | 1 | PLATE |
| 11 | H83055 | 1 | KNOB |
| 12 | H141289 | 1 | LEVER |
| 13 | H144274 | 1 | BUMPER |
CAB SEAT HEIGHT ADJUSTER ( VERTICAL CONTROL ) – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | T62828 | 1 | SPRING |
| 4 | H137417 | 2 | LEAF SPRING |
| 5 | H132452 | 2 | CAP SCREW |
| 9 | H137418 | 4 | BOLT |
| 10 | H137421 | 2 | WASHER |
| 11 | H137420 | 2 | HALF SLEEVE |
| 12 | T55201 | 1 | GRIP |
| 13 | AH113301 | 1 | ADJUSTER |
| AH161927 | 1 | ADJUSTER |
AIR SEAT SUSPENSION – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH144778 | 1 | PANEL |
| 3 | AH157491 | 1 | SEAT SUSPENSION |
| 4 | AH146032 | 1 | WIRING HARNESS |
AIR SEAT SUSPENSION KITS – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH146234 | 1 | KIT |
| 2 | AH136937 | 1 | KIT |
| 3 | RE65695 | 1 | SEAT SHOCK ABSORBER KIT |
| 4 | RE52553 | 1 | SEAT SHOCK ABSORBER KIT |
| 1 | RE65693 | 1 | COMPRESSOR FILTER KIT |
| 2 | AH136929 | 1 | KIT |
| 3 | RE65694 | 1 | AIR SPRING SEAT KIT |
| 4 | AH136930 | 1 | KIT |
| 1 | AH157634 | 1 | KIT |
| 2 | AH136935 | 1 | KIT |
| 3 | AH157557 | 1 | KIT |
| 1 | RE52555 | 1 | SEAT SUSPENSION BOOT KIT |
| 2 | RE63832 | 1 | SEAT BEARING ROLLER KIT |
| 3 | AH136936 | 1 | KIT |
ARMREST WITH GLOVE BOX (R.H.) – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH117067 | 1 | COVER |
| AH161925 | 1 | PANEL | |
| 2 | H123995 | 2 | SCREW |
| 3 | H111706 | 2 | SCREW |
| 4 | H145082 | 1 | PANEL |
| 6 | AH139119 | 1 | DRAWER SLIDE |
| 8 | AH163708 | 1 | NEUTRAL START SWITCH |
| 10 | H168425 | 1 | CONSOLE |
| 11 | H77358 | 1 | CLIP |
| 12 | H111705 | 4 | SCREW |
| 13 | AH124857 | 1 | WIRING LEAD |
| 15 | H146315 | 1 | LABEL |
| 16 | AH156402 | 1 | INSTRUCTION PLATE |
ARMREST ADJUSTING MECHANISM (R.H.) -CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H137854 | 1 | SUPPORT |
| 2 | H96455 | 2 | BUSHING |
| 3 | H137858 | 4 | WASHER |
| 4 | H137856 | 2 | SPACER |
| 5 | H137857 | 2 | BOLT |
| H137859 | 2 | FLANGE NUT | |
| 6 | H137855 | 1 | SUPPORT |
| 8 | H143439 | 1 | COVER |
ARMREST (L.H.) – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | R59070 | 1 | SHAFT KEY |
| 2 | R59028 | 1 | BUSHING |
| 4 | R59029 | 1 | KNOB |
| 5 | H120099 | 1 | CUSHION |
| H168434 | 1 | PANEL | |
| 6 | R58816 | 1 | ARMREST |
| 7 | R59021 | 1 | PIN |
| 8 | R59023 | 1 | PIN |
| 9 | R61862 | 1 | PLATE |
| 10 | R59020 | 1 | LINK |
| 11 | N10215 | 1 | LOCK NUT |
| 12 | R59015 | 1 | GANG BOLT |
| 13 | R59022 | 2 | SCREW |
| 14 | R59013 | 1 | LINK |
| 16 | H99923 | 2 | LOCK NUT |
| 17 | R53665 | 2 | WASHER |
| 18 | R27441 | 2 | WASHER |
OPERATOR’S STATION
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H151166 | 2 | SCREW |
| 2 | AH145616 | 1 | HOLDER |
AIR CONDITIONING AND HEATER HOUSING AND FILTERS – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H161021 | 1 | HOUSING |
| 3 | H158830 | 1 | CLIP |
| 4 | H163397 | 1 | SEAL |
| 5 | H157566 | 1 | AIR DUCT |
| 6 | H153438 | 1 | SEAL |
| 7 | R46414 | 2 | CLAMP |
| 8 | AH115836 | 1 | AIR FILTER |
| 9 | H115031 | 1 | COVER |
| 10 | AH120546 | 1 | HOUSING |
| 11 | H114142 | 2 | PRESCREENER |
| 12 | H118619 | 1 | SEAL |
| 13 | AH138601 | 1 | HOUSING |
| 14 | H127978 | 1 | DUST SHIELD |
| 16 | AH134884 | 1 | SUPPORT |
| 17 | H119362 | 5 | BUSHING |
| 19 | AH120547 | 1 | FILTER |
| 20 | H126589 | 1 | AIR DUCT |
| 21 | H158525 | 1 | HOUSING |
| 22 | H126590 | 1 | COVER |
| 23 | H130091 | 1 | SHIELD |
| 24 | AH125505 | 1 | RESISTOR |
| 26 | H118872 | 1 | LINE |
| 28 | H118871 | 1 | LINE |
| 29 | H146429 | 1 | FITTING |
| 30 | H159636 | 1 | TUBE |
| 31 | H150385 | 1 | CHECK VALVE |
| 33 | H137326 | 1 | SUPPORT |
| 34 | AH144020 | 1 | THERMOSTAT |
| 35 | H123998 | 2 | SCREW |
| 37 | H159743 | 1 | FOAM PAD |
| 38 | AH138601 | 1 | HOUSING |
PRESSURIZER FAN AND AIR CONDITIONING / HEATER FAN – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H115521 | 2 | ISOLATOR |
| 2 | AH128926 | 1 | MOTOR |
| 3 | H114046 | 1 | BLOWER FAN |
| 6 | AH128925 | 1 | MOTOR |
| H129887 | 1 | ISOLATOR | |
| 7 | H124185 | 1 | FAN |
| 8 | T28586 | 1 | CONNECTOR |
AIR CONDITIONING SYSTEM – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH132264 | 1 | EVAPORATOR |
| 2 | R33259 | 1 | O-RING |
| 3 | R113050 | 1 | RING |
| 4 | AH137702 | 1 | VALVE |
| 5 | R10093 | 1 | O-RING |
| 6 | AH127684 | 1 | HOSE |
| 7 | AH127685 | 1 | HOSE |
| 8 | AH144084 | 1 | SWITCH |
| 9 | AH77869 | 1 | CLIP |
| 10 | AH96317 | 1 | CLIP |
| 12 | H132662 | 1 | BRACKET |
| 13 | AH77724 | 1 | CLIP |
| 14 | H136541 | 1 | HOSE SUPPORT |
| 15 | AH137486 | 1 | RECEIVER-DRYER |
| 16 | R60172 | 1 | NUT |
| 17 | R124578 | 1 | VALVE |
| 18 | TY22474 | 1 | CLAMP |
| 19 | AH159026 | 1 | REFRIGERANT HOSE |
| 20 | AH153405 | 1 | LINE |
| AH158180 | 1 | HOSE | |
| 21 | H132538 | 1 | HOSE SUPPORT |
AIR CONDITIONING SYSTEM (FOR R134A REFRIGERANT) – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | P51212 | 1 | O-RING |
| 2 | AH142106 | 1 | REFRIGERANT HOSE |
| AH159078 | 1 | REFRIGERANT HOSE | |
| 3 | R10093 | 1 | O-RING |
| 4 | AH142103 | 1 | HOSE |
| AH159026 | 1 | REFRIGERANT HOSE | |
| 5 | RE24307 | 1 | HIGH PRESSURE SWITCH |
| 6 | AH149618 | 1 | VAPOR CONDENSER |
| 7 | P45458 | 1 | BALL |
| 9 | H145987 | 1 | HOOK BOLT |
| 10 | H145986 | 1 | ARM |
| 15 | H80896 | 1 | BELT |
| 16 | RE46609 | 1 | COMPRESSOR |
| TY6764 | 1 | COMPRESSOR |
AIR CONDITIONING COMPRESSOR (FOR R134A REFRIGERANT)
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | RE52454 | 1 | COMPRESSOR |
| 2 | RE51052 | 1 | MANIFOLD |
AIR CONDITIONING COMPRESSOR HOSE
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH159078 | 1 | REFRIGERANT HOSE |
COMPRESSOR CLUTCH/STATOR/DUST COVER (FOR R134A REFRIGERANT)
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | RE52506 | 1 | VALVE |
| 2 | RE52510 | 1 | STATOR |
| 3 | RE52508 | 4 | KIT |
| 4 | R115743 | 1 | COVER |
COMPRESSOR HARDWARE SET (FOR R134A REFRIGERANT)
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | RE52507 | 1 | KIT |
COMPRESSOR PARTS (FOR 134A REFRIGERANT)
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | RE52509 | 1 | SEAL KIT |
HEATER SYSTEM – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 3 | TY22465 | 7 | HOSE CLAMP |
| 4 | R45847 | 3 | HOSE |
| 5 | TY22328 | 1 | BULK HOSE |
| 6 | H23196 | 1 | FITTING |
| 10 | H117952 | 4 | CLAMP |
| 11 | H132922 | 1 | COTTER PIN |
| 12 | H134655 | 1 | PIN |
| 14 | AH130610 | 1 | BALL JOINT |
| 15 | AH127974 | 1 | CONTROL VALVE |
| 18 | AH132264 | 1 | EVAPORATOR |
| 19 | R50456 | 1 | GROMMET |
| 20 | H36221 | 1 | GROMMET |
| 21 | H153721 | 1 | COUPLING |
| 22 | H153722 | 1 | COUPLING |
| 24 | H132662 | 1 | BRACKET |
| 26 | AH90990 | 1 | CLIP |
CAB HARDWARE KIT – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H110842 | 10 | SCREW |
| 2 | H111364 | 10 | SCREW |
| 3 | H111705 | 10 | SCREW |
| 4 | H111706 | 10 | SCREW |
| 5 | H114038 | 5 | SCREW |
| 6 | H119088 | 10 | SCREW |
| 7 | H123995 | 10 | SCREW |
| 8 | H128859 | 5 | SCREW |
| 9 | H165693 | 5 | SCREW |
| 10 | H130194 | 10 | CAP SCREW |
| 11 | H158579 | 4 | SCREW |
| H168424 | 4 | SCREW | |
| 12 | H130298 | 3 | SCREW |
| 13 | H165691 | 10 | SCREW |
| 15 | H131424 | 3 | BOLT |
| 16 | H132899 | 5 | SCREW |
| 17 | AH133088 | 1 | KIT |
FRONT VARIABLE DRIVE SHEAVE AND MOUNTING – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 3 | H170645 | 1 | SPACER |
| 5 | H155459 | 1 | RETAINER |
| 7 | H168126 | 1 | SHEAVE |
| 10 | H110922 | 1 | BALL |
| 12 | H161648 | 1 | BELT |
| 13 | JD7798 | 2 | LUBRICATION FITTING |
| 14 | AH157933 | 1 | SHEAVE |
| 15 | H110728 | 1 | RETAINER |
| 16 | H97308 | 1 | SNAP RING |
| 17 | AH108161 | 1 | SEAL |
| 20 | H169604 | 1 | COMPRESSION SPRING |
| 21 | AH96345 | 1 | SEAL |
| 23 | P50456 | 2 | WASHER |
| 24 | H80197 | 2 | BUSHING |
| H148132 | 2 | BUSHING | |
| 25 | H148133 | 2 | RETAINER |
| 26 | T55761 | 1 | SUPPORT |
| 27 | R20136 | 1 | WASHER |
| 29 | H148134 | 1 | SPACER |
| 30 | AH97642 | 1 | SHAFT |
| AH136873 | 1 | SHAFT | |
| AH152937 | 1 | SHAFT | |
| 31 | AH144099 | 1 | SUPPORT |
| 32 | H95417 | 1 | SPACER |
| 33 | H97410 | 1 | WASHER |
| 34 | R62502 | 1 | SUPPORT |
REVERSER GEAR BOX – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | R66197 | 6 | THRUST WASHER |
| 2 | AH106618 | 3 | PINION |
| 3 | R33079 | 3 | PIN |
| 5 | R33088 | 3 | WASHER |
| 6 | H89617 | 3 | SPACER |
| 8 | R33058 | 186 | NEEDLE ROLLER |
| 9 | AH150686 | 1 | NEEDLE BEARING |
| 11 | H166216 | 1 | GEAR |
| 12 | E53699 | 1 | SEAL |
| 14 | H168125 | 1 | COVER |
| 15 | JD10010 | 1 | BALL BEARING |
| 16 | R39081 | 1 | SNAP RING |
| 17 | AH144715 | 1 | SEAL |
| 18 | H146585 | 1 | BEARING HOUSING W/O BEARING |
| 19 | H150662 | 1 | BEARING HOUSING W/O BEARING |
| AH140185 | 1 | SEAL | |
| 20 | N71922 | 1 | SNAP RING |
| 21 | JD10011 | 1 | BALL BEARING |
| 22 | BP13620 | 1 | SNAP RING |
| 23 | AH105040 | 1 | GEAR |
| 24 | H132328 | 1 | SHIFT COLLAR |
| 25 | H106073 | 1 | GEAR |
| 29 | AN113330 | 1 | SEAL |
| 30 | R26375 | 2 | O-RING |
| 31 | AH140615 | 1 | INDICATOR LIGHT |
| 32 | H140195 | 1 | SPACER |
| 33 | R26906 | 1 | O-RING |
| 34 | H158860 | 1 | HOUSING |
| 35 | AH93110 | 1 | SHIFTER |
| 37 | R27218 | 1 | FITTING PLUG |
| 39 | R26448 | 1 | O-RING |
| 40 | R39112 | 1 | FITTING |
| 41 | JD8819 | 1 | NEEDLE BEARING |
FRONT SHAFT WITH REVERSER (VARIABLE) – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AN102383 | 2 | LINK CHAIN |
| 2 | H80926 | 2 | SNAP RING |
| 3 | AN102382 | 2 | CHAIN SPROCKET |
| 4 | H128118 | 2 | SPRING |
| 5 | H148818 | 2 | QUICK COUPLER |
| 6 | E62951 | 4 | UNIVERSAL JOINT BEARING |
| 7 | H25360 | 2 | SNAP RING |
| 8 | H28865 | 1 | SNAP RING |
| 9 | H127604 | 1 | TUBE |
| 10 | AH122495 | 1 | SHIELD |
| 11 | M73000 | 1 | SHAFT KEY |
| 12 | H138435 | 2 | SET SCREW |
| 14 | AH125782 | 1 | CHAIN SPROCKET |
| 15 | JD9201 | 1 | ECCENTRIC LOCKING COLLAR |
| 17 | H93927 | 1 | HOUSING |
| 19 | JD9202 | 1 | BALL BEARING |
| 20 | H127603 | 1 | TUBE |
VARIABLE SPEED DRIVE TIGHTENER – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H126371 | 1 | BRACE |
| 6 | AH139295 | 1 | BRACKET |
| 9 | H113892 | 1 | SHIFT COLLAR |
| 10 | H161648 | 1 | BELT |
| 11 | AH94450 | 1 | IDLER |
| 14 | AH154961 | 1 | STRAP |
| 21 | H166971 | 1 | STRAP |
| 24 | AH142407 | 1 | BRACE |
| 27 | H136336 | 1 | HOSE CLAMP |
FIXED SPEED FEEDER HOUSE DRIVE TIGHTENER – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | AH97340 | 1 | ARM |
| 6 | H89297 | 1 | BUSHING |
| 7 | H132825 | 1 | PIVOT |
| 9 | A31867 | 1 | LOCK NUT |
| 10 | AH94450 | 2 | IDLER |
| 11 | H126345 | 1 | BELT |
| 15 | A25695 | 1 | SPRING |
| 16 | H95499 | 1 | GAUGE |
| 19 | H126346 | 1 | BOLT |
| 21 | AH139295 | 1 | BRACKET |
| 24 | H126371 | 1 | BRACE |
| 25 | H126370 | 1 | REINFORCEMENT |
| 27 | H98655 | 2 | BUSHING |
FEEDER HOUSE DRIVE SHIELDS AND SAFETY STOP – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH160053 | 1 | SHIELD |
| AH160054 | 1 | SHIELD | |
| 2 | AH156406 | 1 | SHIELD |
| 3 | AH156066 | 1 | SHIELD |
| 4 | AH157306 | 1 | STOP |
| AH157492 | 1 | STOP | |
| 6 | H150055 | 1 | SUPPORT |
| 9 | H150054 | 2 | BUSHING |
| 10 | H140122 | 2 | CLIP |
| 13 | H134085 | 1 | BRACKET |
| 15 | M93425 | 2 | SPACER |
| 16 | AH89486 | 1 | CLIP |
| 17 | AH158142 | 1 | BRACKET |
| 19 | M72598 | 4 | QUICK LOCK PIN |
| 20 | H146766 | 1 | POWERSHAFT SHIELD |
| 23 | AH135290 | 2 | QUICK LOCK PIN |
| 24 | H137939 | 1 | LABEL |
| 25 | H126397 | 1 | LABEL |
| 27 | AH134121 | 2 | CABLE |
| 29 | H164537 | 1 | SIGN |
FEEDER HOUSE DRIVE SHIELDS AND SAFETY STOP – CONTOUR MASTER – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH160054 | 1 | SHIELD |
| 2 | AH156374 | 1 | SHIELD |
| 3 | AH156066 | 1 | SHIELD |
| 4 | AH157306 | 1 | STOP |
| 6 | H150055 | 1 | SUPPORT |
| 9 | H150054 | 2 | BUSHING |
| 10 | H140122 | 2 | CLIP |
| 13 | H134085 | 1 | BRACKET |
| 16 | H127781 | 1 | SPRING |
| 17 | AH158142 | 1 | BRACKET |
| 20 | H146766 | 1 | POWERSHAFT SHIELD |
| 23 | AH135290 | 3 | QUICK LOCK PIN |
| 24 | H137939 | 1 | LABEL |
| 25 | H126397 | 1 | LABEL |
| 27 | AH134121 | 1 | CABLE |
| 29 | M93425 | 2 | SPACER |
| 30 | H151757 | 2 | SHIELD |
| 33 | H164537 | 2 | SIGN |
| 34 | H150434 | 2 | LABEL |
| 35 | H141549 | 2 | CLAMP |
| 36 | A44990 | 2 | LATCH |
| 38 | H149063 | 2 | LABEL |
FEEDER HOUSE FRAME – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H159975 | 1 | BLOCK CLAMP |
| 3 | H131743 | 1 | MAT |
| 4 | H175703 | 4 | SHIM |
| 5 | H141835 | 2 | REINFORCEMENT |
| 6 | H136015 | 4 | MAT |
| 7 | AH155675 | 1 | FRAME |
| AH158144 | 1 | FRAME | |
| 9 | H134896 | 2 | ANGLE |
| 11 | H159533 | 1 | DEFLECTOR |
| 12 | H158951 | 1 | STRIPPER |
| 16 | H134140 | 2 | BOLT |
| 17 | H130826 | 2 | PIN |
| 19 | H159534 | 1 | DEFLECTOR |
| 20 | H143407 | 2 | WEAR PLATE |
| 21 | H123638 | 2 | EXTENSION |
| 22 | H149063 | 2 | LABEL |
| 24 | H123633 | 1 | SHIELD |
| 25 | H136336 | 1 | HOSE CLAMP |
| 26 | H144052 | 1 | WEAR PLATE |
| 30 | AH126417 | 1 | DOOR |
| 32 | H133989 | 1 | HINGE |
| 33 | H152062 | 1 | DOOR |
FEEDER HOUSE SHELL, WEAR PLATES AND SEALS – CONTOUR MASTER – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH155678 | 1 | FRAME |
| AH158148 | 1 | FRAME | |
| 2 | H149461 | 2 | WEAR PLATE |
| 4 | H144825 | 1 | PIPE |
| 5 | H148998 | 1 | SEAL |
| 6 | A15147 | 2 | SPRING LOCKING PIN |
| 7 | H149459 | 1 | WEAR PLATE |
| 8 | H149460 | 1 | WEAR PLATE |
| 9 | H142861 | 1 | PLATE |
FEEDER HOUSE FRAME, TILT BEAM AND CLOSURE PLATES – CONTOUR MASTER – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 5 | H151607 | 4 | SIGN |
| 6 | H149518 | 1 | STRAP |
| 7 | H149517 | 1 | PIN |
| 9 | E81185 | 2 | WASHER |
| 13 | AH143361 | 1 | SHIELD |
| 14 | AH143362 | 1 | SHIELD |
| 15 | H142869 | 1 | WEATHER ENCLOSURE |
| 16 | AH145282 | 1 | FRAME |
| AH162724 | 1 | FRAME | |
| 18 | H130040 | 2 | PIN |
| 19 | H149523 | 2 | BOLT |
| T43514 | 1 | GASKET | |
| T43514 | 1 | GASKET | |
| 22 | AH145281 | 1 | FRAME |
| 24 | H142870 | 1 | BUSHING |
| 26 | H159975 | 1 | BLOCK CLAMP |
LOCKOUT ASSEMBLY – CONTOUR MASTER (OPTIONAL) – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH145762 | 1 | BRACKET |
| 2 | AH145763 | 1 | PIN |
(BELT PICK-UP PLATFORM AND 4-ROW CORNHEADS ONLY)
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H80926 | 1 | SNAP RING |
| 2 | AH143069 | 1 | DRIVE SPROCKET |
| 3 | H148818 | 1 | QUICK COUPLER |
| 4 | H128118 | 1 | SPRING |
| 5 | E62951 | 2 | UNIVERSAL JOINT BEARING |
| 6 | AN102383 | 1 | LINK CHAIN |
| 7 | H127603 | 1 | TUBE |
| 8 | AH142560 | 1 | INTERNAL HALF COUPLER |
FEEDER HOUSE SLIP CLUTCH – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H119710 | 1 | PLANET PINION CARRIER |
| 3 | A31871 | 1 | LOCK NUT |
| A31870 | 1 | LOCK NUT | |
| 5 | R90521 | 1 | WASHER |
| 6 | H129659 | 1 | SPACER |
| 7 | H109855 | 1 | SPRING |
| 8 | H101677 | 1 | JAW |
| 9 | H105590 | 1 | HUB |
| 10 | H99303 | 1 | WASHER |
| 11 | H119709 | 1 | CHAIN SPROCKET |
| 15 | H105584 | 1 | BUSHING |
| 16 | AH116232 | 1 | CHAIN SPROCKET |
FEEDER HOUSE FRAME AND UPPER SHAFT
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H143354 | 1 | SPACER |
| 2 | JD10020 | 1 | BALL BEARING |
| 3 | H147593 | 2 | HOUSING |
| 5 | H156580 | 6 | SET SCREW |
| 6 | H159613 | 2 | CHAIN SPROCKET |
| 7 | JD9373 | 1 | BALL BEARING |
| 10 | H147482 | 2 | BRACKET |
| 11 | H156578 | 2 | SHAFT KEY |
| 12 | H156576 | 1 | SHAFT |
| 13 | H159614 | 1 | CHAIN SPROCKET |
| 14 | H156579 | 1 | SHAFT KEY |
| 19 | AH141399 | 1 | TUBE |
FEEDER HOUSE FLOOR – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH137733 | 1 | FLOOR |
| AH159703 | 1 | FLOOR | |
| 3 | H131452 | 1 | SEAL |
| 9 | AH141780 | 1 | SUPPORT |
| 10 | AH141782 | 1 | ARM |
| 11 | AH141781 | 1 | ARM |
| 12 | H97322 | 1 | CAM |
| 15 | AH131303 | 1 | PAN |
| 19 | AH89557 | 1 | CLIP |
| AH77279 | 1 | CLIP |
FEEDER CONVEYOR IDLER SHAFT, DRUM AND CHAIN – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH137845 | 1 | CONVEYOR |
| AH138187 | 1 | CONVEYOR | |
| 3 | H134002 | 49 | SLAT |
| 4 | H84026 | 6 | HOOK |
| 5 | AH137630 | 5 | CHAIN LINK |
| 9 | AH137631 | 3 | CHAIN LINK |
| 10 | H150588 | 1 | LABEL |
| 11 | AH126091 | 2 | ARM |
| 13 | H131087 | 2 | BUSHING |
| 15 | H131088 | 2 | EYEBOLT |
| 16 | AH158635 | 1 | CHAIN LINK |
| 17 | H97322 | 2 | CAM |
| 18 | H84942 | 2 | PLATE |
| 19 | H139098 | 2 | BOLT |
| 21 | H144201 | 2 | ADJUSTING STRAP |
| 22 | H154331 | 2 | BOLT |
| 27 | JD8551 | 2 | ECCENTRIC LOCKING COLLAR |
| 28 | H138753 | 2 | HOUSING |
| 29 | JD8552 | 2 | BALL BEARING |
| 30 | H123734 | 1 | SHAFT |
| AH142394 | 1 | DRUM | |
| 33 | W39621 | 2 | NUT |
| 34 | AH158328 | 1 | LINK |
FEEDER CONVEYOR DRIVE CHAIN, TIGHTENER AND GUIDES – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H162325 | 2 | BRACKET |
| 4 | A50743 | 2 | BOLT |
| 6 | H135772 | 1 | WHEEL |
| 7 | H162326 | 1 | PLATE |
| 9 | AH155739 | 1 | BRACKET |
| 10 | H130530 | 2 | GUIDE |
| 12 | AH145029 | 1 | LINK CHAIN |
| 13 | AH155659 | 1 | PLATE |
| 14 | H172177 | 1 | FINGER |
| 15 | H171318 | 1 | COVER |
| 16 | H149063 | 1 | LABEL |
| 17 | H164537 | 1 | SIGN |
FEEDER CONVEYOR DRIVE CHAIN IDLER BRACKET – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H141500 | 1 | BRACKET |
| 4 | H130529 | 2 | SPACER |
| 5 | AE27909 | 1 | CHAIN SPROCKET |
| 9 | H143489 | 1 | BUSHING |
FEED PLATE LATCH HANDLE – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H136144 | 2 | ADJUSTING STRAP |
| 5 | H133060 | 1 | SLEEVE |
| 6 | H132988 | 1 | BUSHING |
| 8 | H132986 | 1 | HANDLE |
VARIABLE DRIVE UPPER COUNTERSHAFT, SHEAVES AND SUPPORTS – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH154961 | 1 | STRAP |
| 2 | R31378 | 1 | O-RING |
| 4 | JD10018 | 2 | BEARING |
| 5 | H97378 | 1 | HUB |
| 6 | AH157934 | 1 | SHEAVE |
| 7 | H151952 | 1 | BELT |
| 8 | AH136497 | 1 | SEAL |
| 9 | H160869 | 1 | HALF SHEAVE |
| 10 | JD7759 | 2 | LUBRICATION FITTING |
| 13 | H93084 | 1 | BOOT |
| 14 | H77698 | 1 | TIE BAND |
| 15 | H161388 | 1 | WASHER |
| 16 | H166971 | 1 | STRAP |
| 19 | H100247 | 1 | SEAL |
| 20 | H161544 | 1 | PISTON |
| 21 | H100246 | 1 | SEAL |
| 22 | H100245 | 1 | HYDRAULIC CYLINDER BARREL |
| 23 | AH154960 | 1 | CYLINDER |
| 26 | H162288 | 1 | BUSHING |
| 27 | H162269 | 1 | EYEBOLT |
FEEDER HOUSE RETURN FLOOR – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH155650 | 2 | FLOOR |
| 3 | AH139243 | 2 | RUNNER |
| 4 | H148187 | 3 | ANGLE |
| 5 | AH141861 | 1 | SUPPORT |
| 6 | AH157942 | 1 | RUNNER |
| 9 | H143358 | 1 | CHANNEL |
| 10 | H146457 | 2 | NUT |
| 13 | H150458 | 3 | STRAP |
| 15 | H145464 | 3 | STRIPPER |
| 19 | AH159053 | 1 | SCOOP |
| AH159054 | 1 | SCOOP | |
| H168278 | 2 | SCOOP | |
| 20 | H164391 | 2 | STRIPPER |
| 21 | H165318 | 2 | SCREW |
| 24 | H144962 | 4 | SCREW |
LH SIDE FEEDER HOUSE DUST FAN – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH155657 | 1 | PLATE |
| 2 | H134417 | 1 | BRACKET |
| 3 | AH155707 | 1 | SHEAVE |
| 4 | H138435 | 1 | SET SCREW |
| 6 | AH155703 | 1 | BRACKET |
| 7 | R66626 | 2 | GROMMET |
| 9 | H164537 | 1 | SIGN |
| 10 | H164222 | 1 | EYEBOLT |
| 13 | H163994 | 1 | SPACER |
| AH159054 | 1 | SCOOP | |
| 15 | AZ19427 | 1 | BALL BEARING |
| 16 | AH157168 | 1 | BEARING |
| 18 | AH157415 | 1 | FAN |
| 20 | H162211 | 1 | ADJUSTING STRAP |
| 22 | H163175 | 1 | BOLT |
| 23 | H172177 | 1 | FINGER |
| 25 | H162278 | 1 | BRACE |
| 26 | AH155833 | 1 | COVER |
| 27 | H171318 | 1 | COVER |
| 31 | H164009 | 1 | BRACKET |
| 36 | H149063 | 1 | LABEL |
| 40 | H164018 | 2 | LIMIT CURTAIN |
| 42 | H165317 | 4 | SCREW |
| 43 | H165318 | 2 | SCREW |
| 44 | H164391 | 2 | STRIPPER |
| 46 | H144962 | 4 | SCREW |
| 47 | H164411 | 1 | SHAFT |
| 48 | AH133191 | 1 | ECCENTRIC LOCKING COLLAR |
LH FEEDER HOUSE DUST FAN BELT – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 3 | AH156975 | 1 | BRACKET |
| 5 | P46874 | 1 | SNAP RING |
| 6 | AN142665 | 2 | BALL BEARING |
| 7 | AH155715 | 1 | SHEAVE |
| 10 | H161648 | 1 | BELT |
| 11 | H164452 | 1 | BELT |
| 13 | AH155348 | 1 | TIGHTENER |
| 14 | H138435 | 2 | SET SCREW |
| 16 | AH155707 | 1 | SHEAVE |
INTAKE SHIELD – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH155275 | 1 | FITTING |
| 7 | H164494 | 1 | SHIELD |
UPPER DRIVE SHAFT, SHEAVE AND MOUNTINGS – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 3 | AH125454 | 1 | SHAFT |
| 4 | JD9301 | 1 | BALL BEARING |
| 5 | P46874 | 1 | SNAP RING |
| 6 | H126261 | 1 | SHEAVE |
| 7 | JD9356 | 1 | BALL BEARING |
| 8 | JD8576 | 1 | ECCENTRIC LOCKING COLLAR |
| 10 | H172142 | 1 | STRAP |
| 11 | H126302 | 1 | SCRAPER |
| 12 | H126345 | 1 | BELT |
FEEDER HOUSE
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H164775 | 1 | UNIVERSAL JOINT YOKE |
| 2 | JD7760 | 2 | LUBRICATION FITTING |
| 3 | BP12946 | 2 | SNAP RING |
| 4 | AE23516 | 2 | CROSS AND BEARING ASSEMBLY |
| 5 | AH156360 | 1 | YOKE |
| 7 | E82514 | 1 | LABEL |
| 8 | AH156362 | 1 | GUARD |
| 9 | AH156363 | 1 | GUARD |
| 10 | W43141 | 1 | LABEL |
| 11 | AH156361 | 1 | YOKE |
| 12 | H164774 | 1 | YOKE |
| 14 | AH154328 | 1 | UNIVERSAL JOINT, WITH SHAFT |
| H163010 | 1 | LABEL |
FRONT DRIVE SHAFT, SHEAVE AND MOUNTINGS – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H110922 | 1 | BALL |
| 3 | H126345 | 1 | BELT |
| 4 | H108889 | 1 | SHEAVE |
| 7 | P50456 | 2 | WASHER |
| 8 | H148132 | 2 | BUSHING |
| 9 | H148133 | 2 | RETAINER |
| 10 | T55761 | 1 | SUPPORT |
| 11 | R20136 | 1 | WASHER |
| 13 | H148134 | 1 | SPACER |
| 14 | R62502 | 1 | SUPPORT |
| 15 | H97410 | 1 | WASHER |
| 16 | H95417 | 1 | SPACER |
| 18 | AH144099 | 1 | SUPPORT |
| 19 | AH97642 | 1 | SHAFT |
| AH136873 | 1 | SHAFT | |
| AH152937 | 1 | SHAFT | |
| 22 | M73000 | 1 | SHAFT KEY |
| 23 | H138435 | 2 | SET SCREW |
| 25 | AH125782 | 1 | CHAIN SPROCKET |
| AH149349 | 1 | DRIVE SPROCKET | |
| 26 | JD9201 | 1 | ECCENTRIC LOCKING COLLAR |
| 27 | H93927 | 1 | HOUSING |
| 28 | JD9202 | 1 | BALL BEARING |
(FOR ALL HEADERS EXCEPT 444 CORNHEAD, 914 BPU)
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AE49773 | 1 | KIT |
| 2 | AH144523 | 1 | UNIVERSAL JOINT YOKE |
| 3 | JD7760 | 2 | LUBRICATION FITTING |
| 4 | BP12946 | 4 | SNAP RING |
| 5 | AE23516 | 2 | CROSS AND BEARING ASSEMBLY |
| 6 | AH145203 | 1 | YOKE, WITH SHAFT |
| 7 | AH143512 | 2 | KIT |
| 10 | AH154742 | 1 | POWERSHAFT SHIELD |
| 11 | AH154740 | 1 | PTO POWR-GARD SHIELD |
| 12 | JD7842 | 1 | LUBRICATION FITTING |
| 13 | AH145205 | 1 | YOKE, WITH TUBE |
| 14 | AH141248 | 1 | UNIVERSAL JOINT YOKE |
| AH155077 | 1 | UNIVERSAL DRIVESHAFT |
THRESHING CYLINDER COVER – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H147845 | 1 | COVER |
| 4 | H134168 | 1 | SEAL |
SEPARATOR / FEEDER HOUSE SEAL, STONE TRAP AND DOOR – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH120502 | 1 | PLATE |
| 2 | H148021 | 1 | HINGE |
| 3 | H148019 | 2 | REINFORCEMENT |
| 4 | H148018 | 2 | SUPPORT |
| 7 | H146730 | 1 | STOP |
| 9 | H151067 | 1 | DEFLECTOR |
| 10 | H134335 | 1 | DOOR |
| 11 | H148925 | 2 | PIN |
| 14 | H134339 | 2 | BRACKET |
| 16 | H134338 | 1 | ROD |
| 19 | H151068 | 2 | SHIELD |
| 20 | H148023 | 1 | ANGLE |
CYLINDER DOOR – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H150128 | 1 | HINGE |
| 2 | AH144104 | 1 | DEFLECTOR |
| H150134 | 1 | SEAL | |
| 3 | H150130 | 1 | SUPPORT |
| 5 | H150133 | 1 | SEAL |
| 11 | E50096 | 2 | BUSHING |
| 14 | AH130202 | 1 | DOOR |
| 15 | H148058 | 4 | SPRING |
| 16 | H148066 | 1 | STRIP |
| 19 | H150131 | 2 | U-BOLT |
| 20 | H134654 | 2 | HANDLE |
CORN CYLINDER DOOR – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | AH144777 | 1 | STOP |
| 4 | AH144599 | 1 | DOOR |
| 5 | H150746 | 2 | PIN |
| 10 | H150514 | 1 | DEFLECTOR |
| 12 | AH144776 | 1 | STOP |
| 15 | H134654 | 2 | HANDLE |
| 16 | H150134 | 2 | SEAL |
| 18 | H151048 | 1 | ANGLE |
| 19 | H151476 | 1 | SEAL |
| 20 | AH144601 | 1 | PANEL |
| 21 | H148058 | 4 | SPRING |
| 22 | H150682 | 4 | STRAP |
| 24 | H151527 | 1 | SEAL |
CYLINDER SHEAR BAR – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH141618 | 1 | STRIPPER |
| 5 | H77514 | 1 | STRAP |
| 6 | H77512 | 1 | SEAL |
| 7 | AH126295 | 1 | TIE BAR |
RASP BAR THRESHING CYLINDER – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H140043 | 1 | SHAFT |
| H145970 | 1 | SHAFT | |
| 3 | H99149 | 2 | HOUSING |
| 7 | JD10342 | 2 | ECCENTRIC LOCKING COLLAR |
| 8 | JD10343 | 2 | BALL BEARING |
| 9 | JD7845 | 2 | ELBOW FITTING |
| 10 | AH121009 | 2 | HOSE |
| 11 | JD7759 | 2 | LUBRICATION FITTING |
| 12 | AH126720 | 2 | THRESHING CYLINDER HEAD |
| 13 | AH126719 | 2 | THRESHING CYLINDER HEAD |
| 14 | H131878 | 2 | THRESHING CYLINDER HEAD |
| 17 | AH134145 | 1 | RASP BAR |
| AH134144 | 1 | RASP BAR | |
| AH139768 | 1 | RASP BAR | |
| AH161400 | 1 | RASP BAR | |
| AH161405 | 1 | RASP BAR | |
| AH161407 | 1 | RASP BAR | |
| AH161409 | 1 | RASP BAR | |
| AH161410 | 1 | RASP BAR | |
| 24 | H150837 | 10 | DEFLECTOR |
| 25 | H145773 | 35 | SELF-LOCKING SCREW AR M10 X |
| 26 | AH140131 | 1 | RASP-BAR CYLINDER |
| AH162821 | 1 | RASP-BAR CYLINDER | |
| AH162827 | 1 | RASP-BAR CYLINDER | |
| AH162797 | 1 | RASP-BAR CYLINDER | |
| 27 | H146457 | 10 | NUT AR |
RASP BAR CONCAVE AND GRATE – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 5 | H140804 | 2 | BEAM |
| 8 | AH151121 | 1 | GRATE |
| 9 | H140803 | 1 | PIN |
| 10 | H144742 | 2 | EYEBOLT |
| 12 | H143610 | 2 | EYEBOLT |
| 16 | H137203 | 2 | BOLT |
| 17 | H137204 | 2 | BUSHING |
| 18 | H131989 | 1 | COVER |
| 19 | H151484 | 2 | LINK |
| 20 | H164222 | 1 | EYEBOLT |
| 1 | AH133156 | 1 | CAM |
| 2 | H132541 | 1 | SCREW |
| 4 | H146318 | 1 | ADJUSTING STRAP |
| 5 | H134418 | 1 | COVER |
| 6 | H134420 | 1 | RETAINER |
| 8 | H131988 | 1 | COVER |
| 10 | AH151119 | 1 | ANGLE |
| 12 | AH136605 | 1 | CONCAVE |
| AH150497 | 1 | CONCAVE | |
| 13 | H145639 | 1 | SHAFT |
| 15 | E47782 | 6 | SPACER |
| 16 | AH133157 | 2 | CAM |
| 17 | H147468 | 1 | ROD |
| 18 | H139098 | 6 | BOLT |
| 19 | AH153688 | 1 | INSERT |
| AH144868 | 1 | INSERT | |
| 21 | A31867 | 1 | LOCK NUT |
| 22 | AH151121 | 1 | GRATE |
BEATER GRATE CURTAIN – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H148301 | 1 | ANGLE |
| 3 | H148305 | 4 | LIMIT CURTAIN |
| 4 | H148302 | 2 | ANGLE |
| 6 | H148304 | 4 | SUPPORT |
| 7 | H156360 | 4 | NUT |
CONCAVE ASSEMBLY AND BEATER GRATE – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH150497 | 1 | CONCAVE |
| AH136605 | 1 | CONCAVE | |
| 2 | H157967 | 50 | NAIL |
| 3 | H140803 | 1 | PIN |
| 5 | AH151121 | 1 | GRATE |
| 6 | H144742 | 2 | EYEBOLT |
| 7 | H135891 | 2 | LOCK NUT |
| 8 | AH151119 | 1 | ANGLE |
| 9 | H139098 | 6 | BOLT |
| 10 | E47782 | 6 | SPACER |
| 12 | H145639 | 1 | SHAFT |
| 13 | AH153688 | 16 | INSERT |
SPIKE TOOTH THRESHING CYLINDER (OPTIONAL) – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 2 | H140043 | 1 | SHAFT |
| H145970 | 1 | SHAFT | |
| 3 | H99149 | 2 | HOUSING |
| 6 | JD10342 | 2 | ECCENTRIC LOCKING COLLAR |
| 7 | JD10343 | 2 | BALL BEARING |
| 8 | JD7845 | 2 | ELBOW FITTING |
| 9 | AH121009 | 2 | HOSE |
| 10 | JD7759 | 2 | LUBRICATION FITTING |
| 11 | H132057 | 312 | TOOTH |
| 16 | AH134662 | 1 | SPIKE-TOOTH CYLINDER |
| AH135826 | 1 | SPIKE-TOOTH CYLINDER |
SPIKE-TOOTH CONCAVE – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH135647 | 1 | CONCAVE |
| 2 | H145639 | 1 | SHAFT |
| 3 | AH131331 | 1 | GRATE |
| 5 | H145257 | 1 | ANGLE |
| 9 | AH126880 | 1 | CONCAVE |
| 11 | AH153688 | 4 | INSERT |
SPIKE TOOTH CONCAVE – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H132541 | 1 | SCREW |
| 4 | H143610 | 2 | EYEBOLT |
| 5 | H146318 | 1 | ADJUSTING STRAP |
| 6 | AH135240 | 1 | CAM |
| 8 | H134816 | 1 | SPACER |
| 10 | H133633 | 2 | SEAL |
| 12 | H137204 | 4 | BUSHING |
| 13 | AH127829 | 2 | LINK |
| 14 | H131986 | 1 | COVER |
| 15 | H137203 | 2 | BOLT |
| 16 | H131987 | 1 | COVER |
| 17 | H164222 | 1 | EYEBOLT |
| 18 | AH133157 | 1 | CAM |
SPIKE-TOOTH FINGER GRATE – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 3 | M44269 | 2 | BUSHING |
| 7 | AH130906 | 1 | SUPPORT |
| 8 | H135158 | 1 | COVER |
| 10 | H134757 | 1 | PIN |
| 14 | H144742 | 2 | EYEBOLT |
SPIKE TOOTH INDICATOR – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H156936 | 1 | BRACKET |
| 2 | R41076 | 1 | GROMMET |
| 3 | R111692 | 1 | SHAFT |
| 4 | R26871 | 1 | SNAP RING |
| 5 | R112679 | 1 | SEAL |
| 6 | R40915 | 1 | LEVER |
| 7 | R34404 | 2 | O-RING |
| 8 | R86457 | 1 | SUPPORT |
| 9 | RE56165 | 1 | SENSOR |
| 13 | AH150499 | 1 | BALL JOINT |
CONCAVE INDICATOR, CABLE AND BRACKETS – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H128999 | 1 | HOUSING |
| 2 | AH141030 | 1 | LENS |
| 3 | H118166 | 2 | SCREW |
| 4 | AH114882 | 1 | BULB |
| 5 | H129179 | 1 | GAUGE |
| 6 | H120801 | 2 | STRAP |
| 7 | H120800 | 2 | CLAMP |
| 9 | AH124573 | 1 | CABLE |
| 10 | M47566 | 1 | CLIP |
| 13 | AH129272 | 1 | BALL JOINT |
| 14 | H132541 | 1 | SCREW |
| 18 | H132540 | 1 | BRACKET |
CORN AND SMALL GRAIN CONCAVE INDICATOR – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | H156936 | 1 | BRACKET |
| 2 | R41076 | 1 | GROMMET |
| 3 | R111692 | 1 | SHAFT |
| 4 | R26871 | 1 | SNAP RING |
| 5 | R112679 | 1 | SEAL |
| 6 | R40915 | 1 | LEVER |
| 7 | R34404 | 2 | O-RING |
| 8 | R86457 | 1 | SUPPORT |
| 9 | RE56165 | 1 | SENSOR |
| 13 | AH150498 | 1 | BALL JOINT |
BEATER, SHAFT AND DRIVE BELT – CONTINUED
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 3 | H147789 | 8 | BLADE |
| 7 | AH128360 | 2 | BEATER HEAD |
| 9 | AH128361 | 1 | BEATER HEAD |
| 10 | H126941 | 1 | SHAFT |
| 12 | AH139436 | 1 | BELT SET |
| AH163931 | 1 | BELT | |
| 14 | JD9201 | 2 | ECCENTRIC LOCKING COLLAR |
| 15 | H113625 | 2 | PRESSED FLANGED HOUSING |
| 16 | JD9434 | 2 | BEARING |
| 17 | H113626 | 2 | PRESSED FLANGED HOUSING |
| 18 | H125558 | 1 | SHEAVE |
| H135850 | 1 | SHEAVE | |
| 19 | JD7845 | 2 | ELBOW FITTING |
| 20 | H143731 | 8 | NUT |
| 21 | AH121009 | 2 | HOSE |
| 22 | E12379 | 2 | NUT |
| 23 | JD7759 | 2 | LUBRICATION FITTING |
| 25 | H130572 | 4 | SEAL |
| 29 | JD7788 | 1 | LUBRICATION FITTING |
THRESHING AND SEPARATION
| Pos | Part no. | Qty | Description |
|---|---|---|---|
| 1 | AH121997 | 1 | COVER |
| 1 | AH149701 | 1 | FRAME |
| 2 | H133288 | 2 | SEAL |
| 3 | AH133091 | 2 | SEAL |
| AH159365 | 2 | SEAL | |
| 4 | H133287 | 2 | SEAL |
| 7 | AH138232 | 2 | LINK |
| 8 | AH138230 | 2 | LINK |
| 2 | AH138230 | 2 | LINK |
| 3 | AH125200 | 6 | BUSHING |
| AH125969 | 6 | ARM | |
| AH125970 | 6 | ARM | |
| 5 | H175590 | 2 | SEAL |
| 9 | H133789 | 1 | SEAL |
| 12 | AH125970 | 1 | ARM |
| AH125969 | 1 | ARM | |
| 13 | AH128909 | 1 | GRAIN PAN |
| 1 | A15147 | 2 | SPRING LOCKING PIN |
| 2 | H76863 | 1 | PIN |
| 3 | H145516 | 1 | DEFLECTOR |
| 4 | T20217 | 2 | WASHER |