CASE 2366 IH Axial – Flow Combine

      No Comments on CASE 2366 IH Axial – Flow Combine

CASE 2366 IH Axial – Flow Combine — parts list, part 2 of 8

Assemblies on this page: 03-08 FUEL TANK – SUPPORTS – BSN JJC0254999 … 04-39 STARTER – MOUNTING – BSN JJC0256399.

03-08 FUEL TANK – SUPPORTS – BSN JJC0254999

Pos Part no. Qty Description
1 197681A2 1 TANK, FUEL, Includes: Ref. 2
2 104781C1 1 CAP
3 217-87 1 PLUG, Hex Hd, 3/8″-18 NPTF, Brass
4 1308798C1 2 STRIP, 1829 mm (72 in.), Cut From 990541R1
5 192381C3 2 SUPPORT, Lower
6 1302029C1 2 SUPPORT, Front
7 1302031C1 2 STRAP
8 1302030C1 2 BRACKET
9 409-7520 2 BOLT, Hex Flg, 5/16″-18 x 1 1/4″, Serr, 5/16 x 1-1/4
10 495-81112 4 WASHER, .344″ x 3/4″ x .120″, 11/32 x 3/4 x 7/64
11 492-11031 4 WASHER, LOCK, 5/16″
12 425-105 4 NUT, 5/16″-18, G5
13 413-516 2 BOLT, Hex, 5/16″-18 x 1″, G5, Full Thd, 5/16 x 1
14 477-73112 22 BOLT, Slotted Tr Hd, 5/16″-18 x 3/4″
14 477-73120 1 SCREW, Sltd Serr Truss Hd, 5/16″-18 x 1 1/4″
15 231-5145 23 NUT, Flg, USR, 5/16″-18
16 198024C1 1 GAUGE, FUEL, Fuel Level
17 168515C1 1 GASKET
18 1310675C1 5 SCREW, LOCK, Sltd Truss Hd, #10-24 x 3/4″, w/nylon LW

03-08(01) FUEL TANK – ASN JJC0255000

Pos Part no. Qty Description
1 409767A1 1 TANK, FUEL, 130 Gal
2 257349A1 1 CAP, FILLER
4 356872A1 1 SENDER UNIT, Fuel Level
5 255095A1 1 GROMMET
8 392075A1 1 ELBOW, Elbow
9 394692A1 2 GROMMET
10 392076A1 1 TUBE
11 392077A1 1 ELBOW, Elbow
12 392078A1 1 TUBE
13 275800A1 1 VALVE STEM
14 255094A1 1 GROMMET
15 282708A1 1 FITTING
16 238-5214 1 O-RING, -214, 70 Duro, .984″ ID x .139″ Thk
17 282709A1 1 NUT
18 217-407 1 PLUG, Hex Hd, 3/8″-18
19 402929A1 1 TUBE, 1350 mm (53-5/32 in.), Cut From 74813C2, BSN JJC0255699
19 87403825 1 1760 mm (69-1/4 in), Cut From 74813C2, ASN JJC0255700
20 316078A2 1 BREATHER
21 515-23412 1 CLAMP, 1 5/8″, Insul, 3/8″ Bolt
22 495-11034 1 WASHER, 5/16″, SAE, (11/32 x 11/16 x 1/16″)
23 231-5145 1 NUT, Flg, USR, 5/16″-18
24 214-1704 2 CLAMP, HOSE, #4, 0.25/0.62 Type M Worm
25 516-23127 1 CLAMP, J, 9/16″ Insul, 3/8″ Bolt, 1/2

03-09 THROTTLE CONTROL

Pos Part no. Qty Description
1 134071A1 1 KNOB
2 116434A1 1 LEVER
3 814-10060 1 BOLT, Hex, M10 x 60, 8.8
7 116433A2 1 STOP
8 434-48 1 BOLT, CARRIAGE, Short NK, 1/4″-20 x 1/2″, G5, Full Thd
9 231-5144 1 NUT, Flg, USR, 1/4″-20
10 115396A1 1 CABLE
11 A75815 1 CLAMP
12 841-4410 2 SCREW, Hex Wash Hd, M4 x 10, M4 x 10; 4.8
13 895-11005 2 WASHER, M5 x 10 x 1
14 432-48 1 PIN, SPLIT (COTTER), 1/16″ x 1/2″
15 1977009C4 1 BALL JOINT, No. 10
16 197085A2 1 SUPPORT, No Longer Used, Order: 344951A1, Ref. 28; 344952A1, Ref. 29
17 857-10020 2 BOLT, Hex Flg, M10 x 20, 10.9
18 1977046C6 1 LEVER, No Longer Used, Order: 344951A1, Ref. 28; 344952A1, Ref. 29
19 615-6016 2 BOLT, Hex, M6 x 16, 8.8, Full Thd, M6 x 16
20 892-11006 2 WASHER, LOCK, M6
21 495-81006 2 WASHER, .266″ x 3/4″ x .060″, 17/64 x 3/4 x 1/16
22 515-23222 2 CLAMP, 7/8″, Insul, 3/8″ Bolt
23 119314A1 2 CLAMP
24 119328A1 1 GASKET
25 117067A1 2 SCREW, SELF TAPPING, Cross Pan Hd, #10-24 x 3/4″
26 231-51409 2 NUT, Flg, USR, #10-24
27 191216A1 2 SCREW, SELF TAPPING, Hex Wash Hd, #10-24 x 5/8″
28 344951A1 1 SUPPORT
29 344952A1 1 LEVER, Injection Pump
5 895-15010 1 WASHER, M11 x 24 x 2
6 829-1410 1 NUT, M10, Cl 10

04-01 HARNESS, FRONT

Pos Part no. Qty Description
1 276600A1 1 HARNESS, WIRE, Front, Inc. 2 – 4, BSN JJC0253999
1 388314A2 1 HARNESS, WIRE, Front, Inc. 2 – 4, ASN JJC0254000
2 127290A1 1 DIODE
3 187308A1 6 CAP, Not Illustrated
4 187309A1 6 BAR, Splice, Not Illustrated
6 245193C2 2 SENSOR, Rotor Speed, Feeder
7 425-1512 2 NUT, Jam, 3/4″-10, G5, 3/4 NF
8 122756A3 1 POTENTIOMETER, 1K, Feeder Position, For Mounting, See Figure 04-25
9 114856A3 1 VALVE, CONTROL, Reel Drive, See Figure 08-24
10 276035A1 1 VALVE, Control, Accumulator, See Figure 08-34, BSN JJC0252949
10 368154A1 1 VALVE, CONTROL, Control, Accumulator, See Figure 08-35, ASN JJC0252950
11 142570A1 1 HARNESS, WIRE, Header Lighting
12 142553A1 1 HARNESS, WIRE, Automatic Header Height Control
13 1331312C1 1 HARNESS, WIRE, Extension, Header Height Control, If Used
14 225290C1 1 DUST CAP, Header Height Control Harness
15 122756A3 1 POTENTIOMETER, 1K, Concave Position, For Mounting, See Figure 04-02
16 143239A2 1 MOTOR, ELECTRIC, Concave Control, For Mounting, See Figure 09B-13
17 1301387C2 1 CLIP, 2 in. ID
18 516-23127 5 CLAMP, J, 9/16″ Insul, 3/8″ Bolt
18 515-30222 3 CLAMP, 7/8″, 1/2″ Bolt
18 515-2395 1 CLAMP, 3/8″, Insul, 3/8″ Bolt
19 515-23254 1 CLAMP, 1″, Insul, 3/8″ Bolt
20 844-8025 1 BOLT, Hex Flg, M8 x 25, 8.8, Not Illustrated
21 825-2408 1 NUT, M8 x 1.25, Flg, Cl 8, Not Illustrated
22 142533A1 1 SUPPORT, Not Illustrated, With Accumulator, With Field Tracker
23 178148A1 1 COVER, , BSN JJC0253999
25 829-4410 1 NUT, Thin, M10 x 1.5, Cl 05, , BSN JJC0253999
26 492-11010 1 WASHER, LOCK, #10, , BSN JJC0253999
27 231-5145 2 NUT, Flg, USR, 5/16″-18
27 825-2405 1 NUT, M5 x .8, Flg, Cl 8, M5, Harness to Solenoid Terminal 50
28 892-11005 2 WASHER, LOCK, M5, Not Illustrated
29 L18331 2 STRAP, CABLE, 15 in., BSN JJC0253999
29 435437A1 5 STRAP, CABLE, 3/16″ x 7 1/4″
30 409-7512 1 BOLT, Hex Flg, 5/16″-18 x 3/4″, Serr
32 276-1458 1 SCREW, SELF TAPPING, Hex Hd, #10 x 1/2″, No. 10 x 1/2
33 492-11010 1 WASHER, LOCK, #10
34 225-14210 1 NUT, #10-32

04-02 POTENTIOMETER, CONCAVE POSITION – MOUNTING

Pos Part no. Qty Description
1 122756A3 1 POTENTIOMETER, Concave Position, 1K
2 181760A2 1 LEVER
3 463-11024 1 SCREW, Hex Hd, #10-24 x 1 1/2″, No. 10 x 1-1/2
4 230-42409 2 NUT, LOCK, #10-24, GA, No. 10
5 463-11010 1 SCREW, Hex Hd, #10-24 x 5/8″, No. 10 x 5/8
6 131175A1 1 ARM
7 483-1084 1 SET SCREW, Hex Soc, #8-32 x 1/4″, No. 8 x 1/4
8 142401A1 1 SUPPORT
9 409-7512 2 BOLT, Hex Flg, 5/16″-18 x 3/4″, Serr
10 231-5145 2 NUT, Flg, USR, 5/16″-18
11 198824C1 1 GROMMET

04-03 HARNESS, CENTER

Pos Part no. Qty Description
1 242037A2 1 HARNESS, WIRE, Center, Inc. 2, 3, BSN JJC0253999
1 386518A3 1 HARNESS, WIRE, Center, Inc. 2, 3, BTW JJC0254000 & JJC0255699
1 441974A1 1 HARNESS, WIRE, Center, Inc. 2, 3, ASN JJC0255700
2 187308A1 4 CAP, Not Illustrated
3 187309A1 4 BAR, Splice, Not Illustrated
4 127813A1 1 LAMP, Service, Reel, Inc. 5
5 P40556 1 BULB, 12V, Not Illustrated
6 122428A1 1 SWITCH, Hydraulic Oil Level
7 178149A1 1 SWITCH, SOLENOID, See Figure 04-01
8 276-1458 2 SCREW, SELF TAPPING, Hex Hd, #10 x 1/2″, No. 10 x 1/2
9 492-11031 2 WASHER, LOCK, 5/16″
10 425-105 2 NUT, 5/16″-18, G5
11 492-11010 1 WASHER, LOCK, #10
12 225-14210 1 NUT, #10-32
13 141944A1 1 SUPPORT
14 409-7412 2 BOLT, Hex Flg, 1/4″-20 x 3/4″, Serr, 1/4 x 3/4
15 492-11031 2 WASHER, LOCK, 5/16″, If used
16 231-5144 2 NUT, Flg, USR, 1/4″-20
17 141655A1 1 SWITCH, Unloader In
18 470-10620 2 SCREW, Slotted Pan Hd, #6-32 x 1 1/4″, No. 6 x 1-1/4
19 138526 2 WASHER, No. 6
20 225-14106 2 NUT, #6-32
21 131152A1 1 VALVE, CONTROL, Unloader Clutch, See Figure 08-31, BSN JJC0253999
21 384307A1 1 VALVE, SOLENOID, Unloader Clutch, See Figure 08-32, ASN JJC0254000
22 177678A1 1 SWITCH, Hydraulic Oil Temperature, Inc. 22A
23 131152A1 1 VALVE, CONTROL, Separator Clutch, See Figure 08-31, BSN JJC0253999
23 384307A1 1 VALVE, SOLENOID, Separator Clutch, See Figure 08-32, ASN JJC0254000
24 515-25476 2 CLAMP, 1 7/8″, Insul, 1/2″ Bolt
25 515-23381 5 CLAMP, 1 1/2″, Insul, 3/8″ Bolt
26 515-23222 3 CLAMP, 7/8″, Insul, 3/8″ Bolt
27 515-23190 2 CLAMP, 3/4″, Insul, 3/8″ Bolt
29 516-23127 4 CLAMP, J, 9/16″ Insul, 3/8″ Bolt
30 515-23254 1 CLAMP, 1″, Insul, 3/8″ Bolt
35 197514A2 1 SWITCH, Neutral Start, Not Illustrated, See Figure 06-11, Ref. 20
36 1988723C1 1 SUPPORT

04-04 HARNESSES – STEERING CONSOLE AND PLATFORM

Pos Part no. Qty Description
1 277603A1 1 HARNESS, WIRE, Steering Console
2 435437A1 2 STRAP, CABLE, 3/16″ x 7 1/4″
3 D71346 2 LAMP, TAIL, No. 168, Replaces 26069R1
4 282775A1 1 SWITCH, IGNITION, Inc. 5 & 6; Replaces D134737 Switch Which Used A77313 Metal Key Without
5 1964785C1 1 NUT, 1 in
6 1964831C2 1 SET OF 2 KEYS, Padded
7 1500137C2 1 SWITCH, FLASHER, Horn
8 614-4008 2 BOLT, Hex, M4 x 8, 8.8, Full Thd
9 D67872 1 SWITCH, Ether Injection
10 217-40 1 REDUCER, 1/4″-18 NPTF x 1/8″-27 Fem NPTF
11 3057542R91 1 HORN
12 614-6025 1 BOLT, Hex, M6 x 25, 8.8, Full Thd
13 892-11006 1 WASHER, LOCK, M6
14 829-1406 1 NUT, M6, Cl 10
15 127286A1 2 SWITCH, Emergency Brake
16 440-11012 8 SCREW, Cross Pan Hd, #10-24 x 3/4″
17 492-11010 8 WASHER, LOCK, #10
18 225-14110 8 NUT, #10-24
19 296466A1 2 BRACKET, Emergency Switch
20 184848A2 1 HARNESS, WIRE, PLATFORM, BSN JJC0254999
21 185117A1 2 HEADLIGHT, Aftercut, Inc. 22, BSN JJC0254999
22 139120A1 1 BULB, Type C-6, No. 894, Not Illustrated
23 515-23159 4 CLAMP, 5/8″, Insul, 3/8″ Bolt
24 296643A1 1 SUPPORT, Brake Switch
25 614-8025 4 BOLT, Hex, M8 x 25, 8.8
26 832-10408 4 NUT, LOCK, M8 x 1.25, Cl 8
27 183629A1 1 SUPPORT, Aftercut Lamp
28 409-7512 2 BOLT, Hex Flg, 5/16″-18 x 3/4″, Serr
29 231-5145 2 NUT, Flg, USR, 5/16″-18
30 493-11039 1 WASHER, LOCK, 3/8″, Int-Ext Tooth
31 197321A1 1 SENSOR, Solar, BSN JJC0252949
32 430506A1 2 LAMP, Aftercut, See Figure 04-46, ASN JJC0255000

04-05 HARNESS, ENGINE

Pos Part no. Qty Description
1 241938A3 1 HARNESS, WIRE, Engine, Inc. 2, BSN JJC0255699
1 436197A2 1 HARNESS, WIRE, Engine, Inc. 2, ASN JJC0255700
2 399470R1 2 BOOT
3 125849A1 1 ALTERNATOR, 135 amp, See Figure(s) 04-38, 04-40
4 1345488C3 1 SWITCH, TEMPERATURE, Coolant Temperature , BSN JJC0255699
4 430653A1 1 SWITCH, Coolant Temperature, 230 deg, ASN JJC0255700
5 232948A1 1 SWITCH, PRESSURE, High, Air Conditioning, BSN JJC0252949
6 279476A1 1 SENSOR, Coolant Level
7 492-11010 1 WASHER, LOCK, #10
8 225-14210 1 NUT, #10-32
9 1964960C1 1 SWITCH, PRESSURE, Engine Oil Pressure
10 217-9 1 ADAPTER, 1/8″-27 Fem NPTF x 1/8″-27 NPTF Male, , BSN JJC0255699
10 250838A2 1 CONNECTOR, ELEC, M10, Inc. 10A, ASN JJC0255700
11 178149A1 1 SWITCH, SOLENOID, See Figure 04-01
12 492-11031 2 WASHER, LOCK, 5/16″
13 425-105 2 NUT, 5/16″-18, G5
14 492-11010 1 WASHER, LOCK, #10
15 225-14210 1 NUT, #10-32
16 276-1458 2 SCREW, SELF TAPPING, Hex Hd, #10 x 1/2″, No. 10 x 1/2
17 121756C2 1 SENSOR, Coolant Temperature
18 87413500 1 MOTOR, STARTER, Case Branded, Replaces 193432A2, See Figure(s) 04-39, 04-41, BSN
19 86993462 1 COMPRESSOR, AIRCOND, Replaces 1999755C3, See Figure 09G-25
20 22-824 1 STRAP, CABLE, 3/16″ x 7 1/4″
20 L18337 8 STRAP, CABLE, 9.95″-12.1″ lg, 15 in
21 515-30222 4 CLAMP, 7/8″, 1/2″ Bolt
21 515-23190 1 CLAMP, 3/4″, Insul, 3/8″ Bolt
21 515-22127 1 CLAMP, 1/2″, Insul, 5/16″ Bolt
22 1345263C1 1 CLIP, 3/4 ID
23 279492A1 1 SWITCH, RESTRICTION, Air Restriction
24 80438R1 1 SPACER, 3/8″ Pipe x 3″
25 1317942C1 1 BRACKET
26 614-8020 2 BOLT, Hex, M8 x 20, 8.8
26 854-12100 1 BOLT, Hex Flg, M12 x 100, 10.9
27 496-21034 2 WASHER, 11/32″ x 11/16″ x 0.89″, HDN
28 854-12050 1 BOLT, Hex Flg, M12 x 50, 10.9
29 825-2408 1 NUT, M8 x 1.25, Flg, Cl 8
30 1317942C1 1 BRACKET
31 194346A1 1 SENSOR, Air To Air Temperature, BSN JJC0255699
31 87300499 1 SENSOR, Air to Air Temperature, ASN JJC0255700

04-06 HARNESS, CONSOLE

Pos Part no. Qty Description
1 276601A2 1 HARNESS, WIRE, Console
2 124098A1 1 SWITCH, Parking Brake
3 109821A1 1 SWITCH, Power Guide Axle, 4 Wheel Drive, Inc. 109826A1, 109833A1, 3141107R1
4 109822A1 1 SWITCH, Inc. 109826A1, 109834A1, 3141107R1, With Two Speed Motor
5 143503A1 1 SWITCH, Rotor Speed
6 143502A1 1 SWITCH, Fan Speed
7 143504A1 1 SWITCH, Concave Adjust
8 114551A1 1 POTENTIOMETER, Reel Speed, 2.5K
9 A186263 1 KNOB
10 114551A1 1 POTENTIOMETER, Raise Rate, 2.5K
11 A186263 1 KNOB
12 114551A1 1 POTENTIOMETER, Header Sensitivity, 2.5K
13 114550A1 1 POTENTIOMETER, Header Position, 1K
14 129237A1 1 SWITCH, Header Height
15 118780A1 3 KNOB
16 245634C2 1 SWITCH, Togggle, Feeder
17 245632C2 1 SWITCH, Toggle, Separator
18 114551A1 1 POTENTIOMETER, Lower Rate, 2.5K
19 A186263 1 KNOB
20 114551A1 1 POTENTIOMETER, Reel Ratio, 2.5K
21 118780A1 1 KNOB
22 109817A1 1 SWITCH, Reel Speed, Auto/Manual
23 515-23222 1 CLAMP, 7/8″, Insul, 3/8″ Bolt
26 353-4 1 PLUG, Cap, .366″ OD, 23/64, Without Automatic Height Control
27 L70872 1 SWITCH, Accumulator
28 A42561 1 NUT
29 280673A1 1 KNOB, Accumulator Switch
24 829-1410 1 NUT, M10, Cl 10

04-07 LEVER ASSY – PROPULSION CONTROLS

Pos Part no. Qty Description
1 113314A2 1 LEVER, CONTROL, Propulsion
5 124669A1 1 PLATE
6 144109A2 1 DECAL, Not Illustrated, See Figure 09H-24, Ref. 3
7 132001A1 1 SWITCH, Header Control
8 118680A1 1 SWITCH, Reel Control
9 118683A1 1 SWITCH, Unloader Swing
10 127597A1 1 SWITCH, Unloader Auger
11 260-54310 1 SCREW, SELF TAPPING, Cross Pan Hd, #6 x 5/8″
12 353-402 1 PLUG, Dome, .375″ hole, Nylon
13 116150A1 1 SUPPORT, Palm Rest, LH
14 116152A1 1 SUPPORT, Palm Rest, Right Hand
15 1343962C1 1 CLIP, ELECTRICAL
16 96860C1 1 KNOB, Palm Rest, BSN JJC0255699
16 86987885 1 KNOB, Palm Rest, ASN JJC0255700
17 425-104 1 NUT, 1/4″-20, G5
18 27-8343 1 PIN, CLEVIS, 1/2″ x 3 7/16′”, 1/2 x 3-7/16
19 128593A1 1 SPRING
20 432-816 1 PIN, SPLIT (COTTER), 1/8″ x 1″
21 225388C1 1 CONNECTOR, ELEC, Type NA
22 225390C1 1 WEDGE, Type NF, Not Illustrated
23 225350C1 1 CONNECTOR, ELEC, Type LY
24 225353C1 1 WEDGE, Type W6P, Not Illustrated
25 120344C1 1 CONDUIT, 184 mm (7-1/4 in.)

04-08 HARNESS – CAB, OVERHEAD

Pos Part no. Qty Description
1 276603A2 1 HARNESS, WIRE, Cab, See Figure(s) 04-10, 04-12, With Overhead Circuit Breaker Panel, BSN
2 113699A1 1 RECTIFIER, 2-5/8
3 83882C91 1 LAMP, Console Illumination, See Figure 04-33
4 440-10812 2 SCREW, Cross Pan Hd, #8-32 x 3/4″, No. 8 x 3/4
5 429726A1 2 DOME LIGHT, See Figure 04-33
6 182721A2 2 SPEAKER, 5-1/2, BSN JJC0253127
6 375389A1 2 SPEAKER, 5-1/2, ASN JJC0253128
7 276-13520 8 SCREW, SELF TAPPING, Hex Hd, #10 x 1 1/4″, No. 10 x 1-1/4
8 231-51409 8 NUT, Flg, USR, #10-24
9 114551A1 2 POTENTIOMETER, Air Conditioning, Fan Speed, Temperature, 2.5K, BSN JJC0252949
10 1977521C1 2 BUTTON
11 124535A1 1 SWITCH, Air Conditioning, Without Automatic Temperature Control, BSN JJC0252949
12 26069R1 4 BULB, No. 192, Not Illustrated
13 139718A1 1 CIRCUIT BREAKER, 10 Amp, Mini, Not Illustrated, Use with 276603A2
14 139719A1 2 CIRCUIT BREAKER, 15 Amp, Mini, Not Illustrated, Use with 276603A2
15 139720A1 3 CIRCUIT BREAKER, 20 Amp, Mini, Not Illustrated, Use with 276603A2
16 105849A1 5 RELAY, Continuous Duty, Mounted In Block, 20 amp
17 176854A1 1 SWITCH, WINDSHIELD WIPER, Wiper
18 124095A1 1 SWITCH, LIGHTS, Lamp, BSN JJC0253999
18 391065A1 1 SWITCH, Lamp, ASN JJC0254000
19 279263A1 1 SWITCH, FLASHER, Warning Lamp
20 143062A1 2 HARNESS, WIRE, Warning Lamp
21 130882C91 2 LIGHT, INTERIOR, See Figure 04-33
22 137838A1 1 WIPER MOTOR, See Figure 04-43
23 391066A1 1 RELAY, Time Delay, ASN JJC0254000
24 97080C1 1 ANTENNA
25 R54547 1 GROMMET
26 893-11008 1 WASHER, LOCK, Ext Tooth, M8
27 825-5148 1 NUT, M8, Flg Ser
28 1983341C1 1 SWITCH, JAM Door
31 825-51410 1 NUT, M10, Flg Ser
32 493-11039 1 WASHER, LOCK, 3/8″, Int-Ext Tooth
33 308910A2 1 DISPLAY, Air Conditioning Display, ASN JJC0252950

04-09 RADIO

Pos Part no. Qty Description
1 ZAE1001 1 RADIO, AM-FM Stereo, Order From Ship Direct, Also Order: 321658A1 Harness For Combines P.I.N.
2 ZAE3001 1 RADIO, AM-FM Stereo, With Cassette Tape Player, Order From Ship Direct Also Order: 321658A1
3 321658A1 1 HARNESS, WIRE, ADAPTER
4 253772A1 1 RADIO, Delco, AM-FM Stereo, Also Order: 245770A1 Harness For Combines Prior To P.I.N.
5 253773A1 1 RADIO, Delco, AM-FM Stereo, Also Order: 245770A1 Harness For Combines Prior To P.I.N.
6 245770A1 1 HARNESS, WIRE, ADAPTER
7 366631A2 1 RADIO, Delco, AM-FM Stereo, ASN JJC0253128
8 355623A1 1 RADIO, Delco, AM-FM Stereo, With Cassette Tape Player, ASN JJC0253128
9 366526A1 1 HARNESS, WIRE, ADAPTER, BTW JJC0253128 & JJC0253999

04-10 HARNESS – CAB, LOWER REAR – BSN JJC0252949

Pos Part no. Qty Description
1 276603A2 1 HARNESS, WIRE, Cab, See Figure(s) 04-10, 04-12, With Overhead Circuit Breaker Panel, BSN
2 A187874 3 DIODE, Unloader Auger, Concave Clearance Request, Brake Solenoid
3 127290A1 1 DIODE, Rotor/Fan Speed Request
4 191216A1 4 SCREW, SELF TAPPING, Hex Wash Hd, #10-24 x 5/8″, Bulkhead Connector
8 825-51410 2 NUT, M10, Flg Ser
9 493-11039 2 WASHER, LOCK, 3/8″, Int-Ext Tooth
10 440-10610 4 SCREW, Cross Pan Hd, #6-32 x 5/8″, No. 6 x 5/8
11 231-14106 4 NUT, LOCK, #6-32, GB, No. 6
12 303717A1 2 JUNCTION BLOCK, Junction, Switched, B+, Replaces 20-1451T1
13 425-106 2 NUT, 3/8″-16, G5
14 113-235 2 BOLT, Hex, 3/8″-16 x 1 3/4″, G5, Full Thd
15 239938A5 1 CONTROL, Header
16 191216A1 2 SCREW, SELF TAPPING, Hex Wash Hd, #10-24 x 5/8″
17 239951A2 1 CASE, Air Conditioning Control
18 184720A2 1 SENSOR, Temperature, Evaporator
19 371831A1 1 LIGHTER, CIGARETTE
20 141336A2 1 VALVE, CONTROL, Heater
21 122579A1 1 SWITCH, PRESSURE, Low, Air Conditioning
22 175435A3 1 BLOWER, Pressurizer
23 242306A2 1 SWITCH, Seat
24 180601A1 1 HARNESS, WIRE, Operator Presence
25 355190A1 1 BLOWER, Cab
26 277019A1 1 CABLE, Cab Power
28 236586A1 1 CONDUIT, 990 mm (39 in.)
33 187103A1 1 CONNECTOR, ELEC, Auxiliary Power
34 225257C1 1 PLUG, Blower Motor
35 83822C1 2 TAPE, ADHESIVE, 610 mm (24 in.), Cut From 1954475A1, Not Illustrated
36 197321A1 2 SENSOR, Solar
37 277424A1 1 CONNECTOR, Not Illustrated
38 277431A1 1 CONNECTOR, Not Illustrated
39 311905A1 1 TOOL, Not Illustrated

04-11 HARNESS – CAB, LOWER REAR – ASN JJC0252949

Pos Part no. Qty Description
1 370779A1 1 HARNESS, WIRE, Cab, See Figure(s) 04-11, 04-12, BSN JJC0253999
1 388671A3 1 HARNESS, WIRE, Cab, See Figure(s) 04-11, 04-12, ASN JJC0254000
2 A187874 2 DIODE, Cab, See Figure(s) 04-10, 04-12, Not Illustrated
3 127290A1 1 DIODE, Rotor/Fan Speed Request
4 191216A1 4 SCREW, SELF TAPPING, Hex Wash Hd, #10-24 x 5/8″, Bulkhead Connector
8 825-51410 2 NUT, M10, Flg Ser
9 493-11039 2 WASHER, LOCK, 3/8″, Int-Ext Tooth
10 440-10610 4 SCREW, Cross Pan Hd, #6-32 x 5/8″, No. 6 x 5/8
11 231-14106 4 NUT, LOCK, #6-32, GB, No. 6
12 303717A1 2 JUNCTION BLOCK, Junction, Switched, B+, Replaces 20-1451T1
13 425-106 2 NUT, 3/8″-16, G5
14 113-235 2 BOLT, Hex, 3/8″-16 x 1 3/4″, G5, Full Thd
15 239938A3 1 CASE, Header Control, BSN JJC0254399
15 239938A5 1 CONTROL, Header Control, ASN JJC0254400
16 191216A1 2 SCREW, SELF TAPPING, Hex Wash Hd, #10-24 x 5/8″
17 377537A1 1 HARNESS, WIRE, Heating and Air Conditioning, Component Of 366852A1, See Figure 09G-20 (01)
17 431091A1 1 HARNESS, WIRE, Heating and Air Conditioning, See Figure 09G-20 (02), ASN JJC0255000
19 1964773C1 1 LIGHTER, CIGARETTE, 12V, BSN JJC0253999
26 277019A2 1 CABLE, Power, Inc. 29
28 236586A1 1 CONDUIT, 990 mm (39 in.)
29 399470R1 1 BOOT, , ASN JJC0254000
33 187103A1 1 CONNECTOR, ELEC, Auxiliary Power, See Note (1)
35 83822C1 2 TAPE, ADHESIVE, 610 mm (24 in.), Cut From 1954475C1, Not Illustrated
37 277424A1 1 CONNECTOR, Not Illustrated
38 277431A1 1 CONNECTOR, Not Illustrated
39 311905A1 1 TOOL, Not Illustrated

04-12 HARNESS – CAB, RELAY AND FUSE

Pos Part no. Qty Description
1 276603A2 1 HARNESS, WIRE, Cab, See Figure(s) 04-10, 04-12, With Overhead Circuit Breaker Panel, BSN
2 284421A1 1 CONTROL UNIT, Low Coolant
3 191216A1 2 SCREW, SELF TAPPING, Hex Wash Hd, #10-24 x 5/8″
4 92389C2 1 UNIT, FLASHER, Hazard, BSN JJC0253999
4 309001A1 1 FLASHER UNIT, Hazard, ASN JJC0254000
5 191216A1 1 SCREW, SELF TAPPING, Hex Wash Hd, #10-24 x 5/8″
6 1987452C1 1 RELAY, Cab Power, 12V, 70 amp
7 191216A1 1 SCREW, SELF TAPPING, Hex Wash Hd, #10-24 x 5/8″
8 1502351C1 1 RELAY, 12V, Unloader Circuit, Optional with 87413245 Below
9 191216A1 1 SCREW, SELF TAPPING, Hex Wash Hd, #10-24 x 5/8″, Used with 1502351C1
9 87033643 1 SCREW, SELF TAPPING, Hex Wash Hd, #10 x 1 1/2″, No. 10 x 1-1/2, Used with 87413221
10 105849A1 19 RELAY, Continuous Duty, 20 amp
11 123116A1 1 PANEL, Fuse and Relay
12 191216A1 3 SCREW, SELF TAPPING, Hex Wash Hd, #10-24 x 5/8″
13 1327979C1 1 MOLDING, 152 mm (6 in.), Cut From 196707C1
20 702093C1 2 STRAP, CABLE
21 60-6515T1 1 SWITCH, 3rd Gear Lockout
22 463-10412 2 SCREW, Hex Hd, #4-40 x 3/4″, No. 4 x 3/4
23 495-31022 2 WASHER, #10
24 225-14104 2 NUT, #4-40
25 440-10616 2 SCREW, Cross Pan Hd, #6-32 x 1″
26 231-14106 2 NUT, LOCK, #6-32, GB, No. 6

04-13 CAB – TEMPERATURE, AUTO – BSN JJC0252949

Pos Part no. Qty Description
1 184720A2 1 SENSOR, Evaporator Temperature
2 197321A1 3 SENSOR, Solar
3 238748A1 1 SUPPORT
4 614-6020 2 BOLT, Hex, M6 x 20, 8.8
5 825-5146 2 NUT, M6, Flg Ser
6 241002A1 1 COVER
7 261-1456 1 SCREW, SELF TAPPING, Cross Pan Hd, #10 x 3/8″
8 259832A2 1 DECAL, Not Illustrated, See Figure 09H-24, Ref. 18
9 234998A2 1 SWITCH, Automatic Temperature
10 117067A1 4 SCREW, SELF TAPPING, Cross Pan Hd, #10-24 x 3/4″
11 222037A1 4 PLATE
12 515-2132 2 CLAMP, 1/8″, Insul, 1/4″ Bolt, (M3.2 ID)
13 224089A1 4 SPACER
14 D71346 4 LAMP, TAIL, No. 168
15 231-51409 4 NUT, Flg, USR, #10-24
16 297523A1 1 SUPPORT, Temperature Probe
17 297573A1 1 SEAL, Temperature Probe
18 191216A1 4 SCREW, SELF TAPPING, Hex Wash Hd, #10-24 x 5/8″
19 131-648 4 NUT, Tinn, U, #10-24, No. 10

04-14 INSTRUMENT PANEL ASSY

Pos Part no. Qty Description
2 238210A1 1 DECAL, Gauge and Warning, See Figure 09H-24, Ref. 1
3 123716A1 1 DECAL, Instrument Panel
5 121615A1 6 SOCKET, LAMP, Includes Bulb, Not Illustrated
6 142825A1 1 GAUGE, FUEL
7 142824A1 1 GAUGE, Coolant Temperature
8 142828A1 1 VOLTMETER, Voltmeter
9 110862A1 1 MONITOR, CONTROL, Grain Scan, Inc. 10
11 123715A1 1 DISPLAY, Height Display, Inc. 12
12 121615A1 2 SOCKET, LAMP, Includes Bulb, Not Illustrated
13 R53000 2 NUT
14 260-13524 2 SCREW, SELF TAPPING, Cross Pan Hd, #10 x 1 1/2″
15 200720002 3 KNOB, Control Monitor (Not Shown)

04-15 HARNESS, LOWER

Pos Part no. Qty Description
1 243187A1 1 HARNESS, WIRE, Lower, Inc. 2, 3
2 187308A1 2 CAP, Not Illustrated
3 187309A1 2 BAR, Splice, Not Illustrated
4 129010A4 1 VALVE, CONTROL, Parking Brake and Feeder Clutch, See Figure 08-20
5 245193C2 2 SENSOR, Ground, Fan Speed
6 425-1512 2 NUT, Jam, 3/4″-10, G5, 3/4 NF
7 1345482C3 1 TRANSMITTER, Clean Grain Speed
8 106666A1 1 NUT, 3/8
9 122761A1 1 SENSOR, Header Float Pressure, See Figure 08-13
15 92386C1 3 CLAMP, 7/8″, Insul, 7/16″ Bolt
16 516-23127 6 CLAMP, J, 9/16″ Insul, 3/8″ Bolt
17 844-8025 2 BOLT, Hex Flg, M8 x 25, 8.8, Not Illustrated
18 825-2408 3 NUT, M8 x 1.25, Flg, Cl 8, Not Illustrated
19 435437A1 1 STRAP, CABLE, 3/16″ x 7 1/4″, Not Illustrated

04-16 HARNESS, LEFT HAND SIDE

Pos Part no. Qty Description
1 276602A1 1 HARNESS, WIRE, Left Hand Side, Inc.. 2 & 3, BSN JJC0253999
2 187308A1 3 CAP, Not Illustrated
3 187309A1 3 BAR, Splice, Not Illustrated
4 1252494C2 1 TRANSMITTER, Engine RPM
5 425-1512 2 NUT, Jam, 3/4″-10, G5, 3/4 NF
7 245364C1 1 SWITCH, Monitor Control, Shoe Speed
8 840-1410 2 SCREW, Cross Pan Hd, M4 x 10, 4.8
9 187996C1 1 MAGNET, Shoe Sensor
10 187998C3 1 BRACKET, Sensor
11 434-58 2 BOLT, CARRIAGE, Short NK, 5/16″-18 x 1/2″, G5, Full Thd
12 231-5145 2 NUT, Flg, USR, 5/16″-18
13 1345485C3 1 TRANSMITTER, Beater
14 1345482C3 1 TRANSMITTER, Tailings Elevator Speed
15 470-1086 4 SCREW, Slotted Pan Hd, #8-32 x 3/8″, No. 8 x 3/8
16 492-11008 4 WASHER, LOCK, #8
18 455102R21 1 COLLAR, Includes Setscrew
19 280-1478 1 SCREW, SELF TAPPING, Hex Wash Hd, 1/4″ x 1/2″, 1/4 x 1/2
20 116892A1 1 CHANNEL
21 477-73112 3 BOLT, Slotted Tr Hd, 5/16″-18 x 3/4″
22 231-5145 3 NUT, Flg, USR, 5/16″-18
23 495-11034 1 WASHER, 5/16″, SAE, (11/32 x 11/16 x 1/16″)
24 1301560C1 1 SUPPORT
25 413-512 1 BOLT, Hex, 5/16″-18 x 3/4″, G5, Full Thd
26 492-11031 1 WASHER, LOCK, 5/16″
27 425-105 1 NUT, 5/16″-18, G5
28 127813A1 1 LAMP, Service, Left Hand, Inc. 29
29 H40556 1 BULB, 12V, Not Illustrated
30 139049A2 1 SUPPORT, LH
31 276-1458 3 SCREW, SELF TAPPING, Hex Hd, #10 x 1/2″, No. 10 x 1/2
32 825-5148 4 NUT, M8, Flg Ser
33 515-23222 3 CLAMP, 7/8″, Insul, 3/8″ Bolt
34 515-23254 2 CLAMP, 1″, Insul, 3/8″ Bolt
35 435437A1 2 STRAP, CABLE, 3/16″ x 7 1/4″
36 1301387C2 3 CLIP, 2 in. ID, Square
37 844-8025 3 BOLT, Hex Flg, M8 x 25, 8.8, Not Illustrated
38 825-2408 3 NUT, M8 x 1.25, Flg, Cl 8, Not Illustrated
39 245410C1 1 TRANSMITTER, Straw Chopper
40 178799C1 1 CLAMP, Sensor, Use with 245410C1
41 144706A4 1 SUPPORT, , With Straw Chopper
42 425-148 2 NUT, Jam, 1/2″-13, G5
43 362666R1 2 CLIP
44 402850A1 1 LAMP, WORK, Separator, See Figure 04-35, ASN JJC0254000
45 391064A2 1 BRACKET, , ASN JJC0254000
46 231-5346 1 NUT, LOCK, Flg, 3/8″-16, , ASN JJC0254000
47 391062A1 1 SWITCH, , ASN JJC0254000
50 470375C1 1 CLAMP
51 409-7512 1 BOLT, Hex Flg, 5/16″-18 x 3/4″, Serr
52 231-5145 1 NUT, Flg, USR, 5/16″-18

04-17 HARNESS, REAR – BSN JJC0253999

Pos Part no. Qty Description
1 184748A4 1 HARNESS, WIRE, Rear, Inc. 2, 3
2 187308A1 1 CAP, Not Illustrated
3 187309A1 1 BAR, Splice, Not Illustrated
4 127813A1 1 LAMP, Service Right Hand, Inc. 5
5 H40556 1 BULB, 12V, Not Illustrated
6 139049A2 1 SUPPORT
7 905-8020 4 BOLT, Hex Serr Flg, M8 x 20, M8 x 20
8 825-5148 4 NUT, M8, Flg Ser
9 141730A1 1 HARNESS, WIRE, Ether Injection
10 185552A2 1 SOLENOID, 12V, Ether Injection, See Figure 02-08, Inc. 10A
11 1345485C3 1 TRANSMITTER, Rotary Air Screen
12 185116A1 2 HEADLIGHT, Rear Flood, Inc. 13
13 139120A1 1 BULB, Type C-6, No. 894, Not Illustrated
14 130882C91 2 LIGHT, INTERIOR, See Figure 04-33
15 92260C1 2 LAMP, Stop, Tail, See Figure 04-33
16 198024C1 1 GAUGE, FUEL, Fuel Level
17 245193C2 1 SENSOR, Straw Spreader Speed
18 515-23175 8 CLAMP, 11/16″, Insul, 3/8″ Bolt, 7/8 ID
19 516-23127 3 CLAMP, J, 9/16″ Insul, 3/8″ Bolt
20 195804C1 2 GROMMET
21 22-824 1 STRAP, CABLE, 3/16″ x 7 1/4″
22 825-2408 8 NUT, M8 x 1.25, Flg, Cl 8
23 516-23127 1 CLAMP, J, 9/16″ Insul, 3/8″ Bolt
24 87300599 1 KIT, KIT Brake Lights, Australian Production Machines, Inc. 25 – 30, Not Illustrated
25 87300500 1 HARNESS, HARNESS Brake Light
26 296462A1 1 SUPPORT, Brake Light Mounting
27 1983341C1 2 SWITCH
28 614-6020 2 BOLT, Hex, M6 x 20, 8.8
29 87300521 1 ADAPTER, HARNESS Rear Brake
30 L18331 23 STRAP, CABLE, 15 in

04-18 HARNESS, REAR – ASN JJC0254000

Pos Part no. Qty Description
1 388318A5 1 HARNESS, WIRE, Rear, Inc. 2, 3, BTW JJC0254000 & JJC0255699
1 441972A2 1 HARNESS, WIRE, Rear, Inc. 2, 3, ASN JJC0255700
2 187308A1 1 CAP, Not Illustrated
3 187309A1 1 BAR, Splice, Not Illustrated
4 127813A1 1 LAMP, Service, Right Hand, Inc. 5
5 H40556 1 BULB, 12V, Not Illustrated
6 139049A2 1 SUPPORT
7 276-1458 3 SCREW, SELF TAPPING, Hex Hd, #10 x 1/2″, No. 10 x 1/2
7 905-8020 4 BOLT, Hex Serr Flg, M8 x 20, M8 x 20
8 825-5148 4 NUT, M8, Flg Ser
9 141730A1 1 HARNESS, WIRE, Ether Injection
10 185552A2 1 SOLENOID, 12V, Ether Injection, See Figure 02-08, Inc. 10A
11 1345485C3 1 TRANSMITTER, Rotary Air Screen
12 185116A1 2 HEADLIGHT, Rear, Flood, Inc. 13, BSN JJC0254999
13 139120A1 1 BULB, Type C-6, No. 894, Not Illustrated, BSN JJC0254999
14 130882C91 2 LIGHT, INTERIOR, See Figure(s) 4-33
15 92260C1 2 LAMP, Stop, Tail, See Figure(s) 4-33
16 356872A1 1 SENDER UNIT, Fuel Level
17 245193C2 1 SENSOR, Straw Spreader Speed
18 515-23175 3 CLAMP, 11/16″, Insul, 3/8″ Bolt, 11/16 ID
18 515-23190 7 CLAMP, 3/4″, Insul, 3/8″ Bolt
18 515-23222 4 CLAMP, 7/8″, Insul, 3/8″ Bolt
19 516-23127 4 CLAMP, J, 9/16″ Insul, 3/8″ Bolt
20 195804C1 2 GROMMET
21 435437A1 1 STRAP, CABLE, 3/16″ x 7 1/4″
22 231-5145 7 NUT, Flg, USR, 5/16″-18
23 516-23127 1 CLAMP, J, 9/16″ Insul, 3/8″ Bolt
24 515-2163 1 CLAMP, 1/8″, Insul, 1/4″ Bolt, 1/4 ID
25 231-5144 1 NUT, Flg, USR, 1/4″-20
26 409-748 1 BOLT, Hex Flg, 1/4″-20 x 1/2″, Serr
27 86561136 1 MODULE, Flasher
28 393955A1 1 BRACKET
29 409-7416 2 BOLT, Hex Flg, 1/4″-20 x 1″, Serr
30 495-11028 2 WASHER, 1/4″, SAE, (9/32 x 5/8 x 1/16″)
31 231-4144 2 NUT, LOCK, 1/4″-20, GB
32 231-5145 2 NUT, Flg, USR, 5/16″-18
33 396377A1 1 CONNECTOR, ELEC, Pin, 6
34 430505A1 2 LAMP, 35W, See Figure 04-46, ASN JJC0255000
35 260-13524 2 SCREW, SELF TAPPING, Cross Pan Hd, #10 x 1 1/2″
36 362120R1 1 CLAMP
37 409-7520 1 BOLT, Hex Flg, 5/16″-18 x 1 1/4″, Serr, 5/16 X 1-1/4
38 231-5145 1 NUT, Flg, USR, 5/16″-18
39 87300598 1 KIT, KIT Brake Lights, Australian Production Machines, Inc. 33 – 37, Not Illustrated
40 87300500 1 HARNESS, HARNESS Brake Light
41 296462A1 1 SUPPORT, Brake Light Mounting
42 1983341C1 2 SWITCH
43 614-6020 2 BOLT, Hex, M6 x 20, 8.8
44 L18331 15 STRAP, CABLE, 15 in

04-19 HARNESS – GRAIN TANK AND UNLOADER LAMP

Pos Part no. Qty Description
1 184737A2 1 HARNESS, WIRE, Grain Tank, Inc. 2, 3
2 187308A1 2 CAP, Not Illustrated
3 187309A1 2 BAR, Splice, Not Illustrated, BSN JJC0254999
4 185118A1 2 HEADLIGHT, Flood, Left and Right Hand, Inc. 5
5 139119A1 1 BULB, #886, 12V, 50W , Not Illustrated, BSN JJC0254999
6 1987377C1 1 SWITCH, Grain Tank Level
7 409-7512 2 BOLT, Hex Flg, 5/16″-18 x 3/4″, Serr
9 231-5145 2 NUT, Flg, USR, 5/16″-18
10 185119A1 1 HEADLIGHT, Grain Tank, See Figure 04-34
11 537641R2 1 SWITCH, Unloader Out
12 490-1108 2 SCREW, Cross Pan Hd, #10-32 x 1/2″, No. 10 NF x 1/2
14 1338003C1 1 BRACKET
15 1338004C2 1 BRACKET
16 86976974 1 GROMMET, 3/4 ID
16 198823C1 2 GROMMET, 3/8 ID
17 362126R1 3 CLIP
18 370383R1 6 CLIP, 3/4 ID
19 184740A2 1 HARNESS, WIRE, Unloader Lamp
20 185116A1 1 HEADLIGHT, Unloader, Inc. 21
21 139120A1 1 BULB, Type C-6, No. 894, Not Illustrated
22 515-23127 3 CLAMP, 1/2″, Insul, 3/8″ Bolt
23 844-8025 4 BOLT, Hex Flg, M8 x 25, 8.8
24 825-2408 4 NUT, M8 x 1.25, Flg, Cl 8
13 493-81000 2 WASHER, LOCK, Ext-Int Tooth, #10, 3/16
25 363660R1 1 CLIP
26 435437A1 7 STRAP, CABLE, 3/16″ x 7 1/4″
27 197991A1 2 CLIP, ELECTRICAL, Grain Tank Switch
28 409-7524 1 BOLT, Hex Flg, 5/16″-18 x 1 1/2″, Serr, 5/16 x 1-1/2
29 231-5145 1 NUT, Flg, USR, 5/16″-18
30 516-23127 1 CLAMP, J, 9/16″ Insul, 3/8″ Bolt
31 477-73112 1 BOLT, Slotted Tr Hd, 5/16″-18 x 3/4″
32 231-5145 1 NUT, Flg, USR, 5/16″-18
33 300433A1 1 SUPPORT, Unloader Lamp
34 430504A1 2 LAMP, 55W, See Figure 04-46, ASN JJC0255000
35 430505A1 1 LAMP, 35W, See Figure 04-46, ASN JJC0255000

04-20 HARNESS – ROTOR LIMIT SWITCH

Pos Part no. Qty Description
1 245240C1 1 HARNESS, WIRE, Rotor Limit Switch
2 128298A2 2 SWITCH, Rotor
3 470-10620 4 SCREW, Slotted Pan Hd, #6-32 x 1 1/4″, No. 6 x 1-1/4
4 495-81006 2 WASHER, .266″ x 3/4″ x .060″, 17/64 x 3/4 x 1/16
5 495-31016 2 WASHER, #6
6 138526 4 WASHER, No. 6
7 225-14106 4 NUT, #6-32
8 516-23127 2 CLAMP, J, 9/16″ Insul, 3/8″ Bolt
9 477-73812 1 SCREW, Sltd Serr Truss Hd, 3/8″ x 3/4″, 3/8 x 3/4
10 231-5146 1 NUT, Flg, USR, 3/8″-16
11 370383R1 1 CLIP, Not Illustrated
12 435437A1 1 STRAP, CABLE, 3/16″ x 7 1/4″, Not Illustrated

04-21 HARNESS – FAN AND ROTOR SPEED

Pos Part no. Qty Description
1 184397A2 1 HARNESS, Fan Speed, Rotor
2 111787A2 1 MOTOR, ELECTRIC, Rotor Speed
3 111787A2 1 MOTOR, ELECTRIC, Fan Speed
4 515-23190 2 CLAMP, 3/4″, Insul, 3/8″ Bolt
5 516-23127 7 CLAMP, J, 9/16″ Insul, 3/8″ Bolt
6 434-512 3 BOLT, CARRIAGE, Short NK, 5/16″-18 x 3/4″, G5, Full Thd, Not Illustrated
7 231-5145 3 NUT, Flg, USR, 5/16″-18, Not Illustrated

04-22 HARNESS – TAILINGS MONITOR

Pos Part no. Qty Description
2 38-31636 1 PIN, 1/4″ x 2 1/4″, Coiled, 1/4″ x 2 1/4″, Coiled
3 103-3431 1 RING, LOCKING, #31, Ext, E-Type
5 239246A1 1 BEARING, NEEDLE
6 247223A1 1 BEARING, NEEDLE
7 221847A1 1 SENSOR, Tailings
8 238-5115 1 O-RING, -115, 70 Duro, .674″ ID x .103″ Thk
9 463-11024 2 SCREW, Hex Hd, #10-24 x 1 1/2″, No. 10 x 1-1/2, Replaces 276-13520
10 495-31022 2 WASHER, #10
11 239809A1 1 WASHER
12 225384A4 1 HARNESS, WIRE, Tailings Monitor
13 516-2395 2 CLAMP, J, 7/16″ Insul, 3/8″ Bolt
14 409-7512 2 BOLT, Hex Flg, 5/16″-18 x 3/4″, Serr
15 425-285 2 NUT, Flg, 5/16″-18, G5

04-23 HARNESS – FEEDER REVERSER – BSN JJC0253999

Pos Part no. Qty Description
1 178149A1 1 SWITCH, SOLENOID, See Figure 04-01
2 261-1478 2 SCREW, SELF TAPPING, Cross Pan Hd, 1/4″ x 1/2″, 1/4 x 1/2
3 231322A1 1 CABLE, Reverser Relay, Inc. 4
4 399470R1 1 BOOT
5 231400A1 1 CABLE, Feeder Reverser
6 245927C93 1 MOTOR, STARTER, Feeder Reverser, See Figure 04-42
7 413-636 3 BOLT, Hex, 3/8″-16 x 2 1/4″, G5
8 231-5146 3 NUT, Flg, USR, 3/8″-16
9 232263A1 1 CABLE, Feeder Reverser Motor
11 515-25317 2 CLAMP, 1 1/4″, Insul, 1/2″ Bolt
12 515-23286 2 CLAMP, 1 1/8″, Insul, 3/8″ Bolt
13 516-23127 2 CLAMP, J, 9/16″ Insul, 3/8″ Bolt
14 477-73112 2 BOLT, Slotted Tr Hd, 5/16″-18 x 3/4″
15 231-5145 2 NUT, Flg, USR, 5/16″-18

04-24 HARNESS – FEEDER REVERSER – ASN JJC0254000

Pos Part no. Qty Description
1 393904A1 1 VALVE, Feeder Reverser, See Figure 08-41
2 390754A2 1 HARNESS, WIRE, Feeder Reverser
3 515-2395 1 CLAMP, 3/8″, Insul, 3/8″ Bolt
4 409-7512 1 BOLT, Hex Flg, 5/16″-18 x 3/4″, Serr
5 231-5145 1 NUT, Flg, USR, 5/16″-18

04-25 POTENTIOMETER, FEEDER POSITION – MOUNTING

Pos Part no. Qty Description
2 238458A1 2 COVER, Potentiometer Support
3 280001A1 2 GASKET, Potentiometer Support, Not Illustrated
4 261-5428 8 SCREW, SELF TAPPING, Cross Pan Hd, #4 x 1/2″, No. 4 x 1/2
5 143225A3 1 LEVER, Position, Inc. 6
6 878-1046 1 SET SCREW, Hex Soc, M4 x 6, Cup Pt
7 238-5012 1 O-RING, -012, 70 Duro, .364″ ID x .070″ Thk, Not Illustrated
8 A164914 1 BUSHING, Sensor
9 103-3350 1 RING, LOCKING, #50, .392″ Dia, E-Type
10 122756A3 1 POTENTIOMETER, Position
11 413-48 1 BOLT, Hex, 1/4″-20 x 1/2″, G5, Full Thd, 1/4 x 1/2
12 231-5144 1 NUT, Flg, USR, 1/4″-20
13 127474A1 1 STUD, 1/4 NF x 6-1/2
14 A10329 2 BALL JOINT, 1/4 NF
15 127308A2 1 SUPPORT
16 492-11025 2 WASHER, LOCK, 1/4″
17 425-114 4 NUT, 1/4″-28, G5
18 363660R1 1 CLIP, Rear Harness, Not Illustrated
19 516-23127 1 CLAMP, J, 9/16″ Insul, 3/8″ Bolt, 12.7 mm, Not Illustrated
20 253421A1 1 HARNESS, WIRE, Feeder Position

04-26 POTENTIOMETER, FEEDER POSITION – MOUNTING – YIELD MONITOR

Pos Part no. Qty Description
1 239136A1 1 POTENTIOMETER, Yield Monitor, Right Hand, See Figure 04-25
2 413-48 1 BOLT, Hex, 1/4″-20 x 1/2″, G5, Full Thd, 1/4 x 1/2
3 231-5144 1 NUT, Flg, USR, 1/4″-20
4 425-114 2 NUT, 1/4″-28, G5
5 492-11025 2 WASHER, LOCK, 1/4″
6 301522A1 1 TIE-ROD, THREADED, Inc. 7
7 425-114 2 NUT, 1/4″-28, G5
8 A10329 2 BALL JOINT, 1/4 NF
9 127308A2 1 SUPPORT

04-27 POTENTIOMETER, FEEDER POSITION – MOUNTING – RETURN TO CUT

Pos Part no. Qty Description
1 238459A1 1 POTENTIOMETER, Return To Cut, Left Hand, See Figure 04-25
2 413-48 1 BOLT, Hex, 1/4″-20 x 1/2″, G5, Full Thd, 1/4 x 1/2
3 231-5144 1 NUT, Flg, USR, 1/4″-20
4 425-114 2 NUT, 1/4″-28, G5
5 492-11025 2 WASHER, LOCK, 1/4″
6 301522A1 1 TIE-ROD, THREADED, Inc. 7
7 425-114 2 NUT, 1/4″-28, G5
8 A10329 2 BALL JOINT, 1/4 NF
9 127308A2 1 SUPPORT

04-28 HARNESS – CHAFFER AND ROTOR

Pos Part no. Qty Description
1 127831A2 1 HARNESS, WIRE, Rotor Sensor
2 245362C1 2 TRANSMITTER, Inc. 21
3 477-73112 4 BOLT, Slotted Tr Hd, 5/16″-18 x 3/4″
4 231-5145 4 NUT, Flg, USR, 5/16″-18
5 516-23127 2 CLAMP, J, 9/16″ Insul, 3/8″ Bolt
5 515-2395 5 CLAMP, 3/8″, Insul, 3/8″ Bolt
6 440-10610 4 SCREW, Cross Pan Hd, #6-32 x 5/8″, Rotor Pad Mounting Hardware, No. 6 x 5/8
7 493-11014 4 WASHER, LOCK, Ext-Int Tooth, #6, Rotor Pad Mounting Hardware, 1/8
8 225-14106 4 NUT, #6-32, Rotor pad mounting hardware
9 195806C1 1 GROMMET, 3/4 ID
10 92047C1 1 HARNESS, Chaffer Sensor, Standard (Short) Chaffer
11 245361C2 2 TRANSMITTER, Includes: Ref. 11A & 11B
12 413-536 4 BOLT, Hex, 5/16″-18 x 2 1/4″, G5
13 231-5145 8 NUT, Flg, USR, 5/16″-18
14 22-824 1 STRAP, CABLE, 3/16″ x 7 1/4″
15 515-23127 1 CLAMP, 1/2″, Insul, 3/8″ Bolt
15 515-2163 2 CLAMP, 1/8″, Insul, 1/4″ Bolt, 1/4 ID
15 515-23175 1 CLAMP, 11/16″, Insul, 3/8″ Bolt, 7/8 ID
18 1301242C1 1 BRACKET
19 477-73112 1 BOLT, Slotted Tr Hd, 5/16″-18 x 3/4″
20 231-5145 1 NUT, Flg, USR, 5/16″-18
21 245884C1 1 TRANSMITTER, Grain Scan Sensor Block
22 260-1356 4 SCREW, SELF TAPPING, Cross Pan Hd, #10 x 3/8″, No. 10 x 3/8

04-29 HARNESS – FIELD TRACKER

Pos Part no. Qty Description
1 125838A2 1 HARNESS, WIRE, Console, Field Tracker
2 109814A1 1 SWITCH, Auto/Manual, Inc. 109915A1, 109826A1, 3141107R1, 134608A1
4 114551A1 1 POTENTIOMETER, 2.5K, Balance, BSN JJC0252949
5 114553A1 1 POTENTIOMETER, 10K, Sensitivity
6 133498A2 1 POTENTIOMETER, 50K, Response
7 118780A1 3 KNOB
8 276484A1 1 HARNESS, WIRE, Cab, Field Tracker, Inc. 9, 10
9 126011A1 1 DIODE
10 A187874 1 DIODE
11 100275A2 1 ELECTRONIC UNIT, CONTROL
12 191216A1 2 SCREW, SELF TAPPING, Hex Wash Hd, #10-24 x 5/8″
13 495-31022 2 WASHER, #10
14 105849A1 5 RELAY, Continuous Duty, 20 amp
18 276479A1 1 HARNESS, Front, Field Tracker, BSN JJC0253999
18 276479A2 1 HARNESS, WIRE, Front, Field Tracker, ASN JJC0254000
19 141729A1 1 HARNESS, WIRE, Hose, Field Tracker
23 1988724C1 1 SUPPORT, Monitor
24 363-31016 3 SCREW, Hex Wash Hd, #10-24 x 1″, No. 10 x 1
25 231-51409 3 NUT, Flg, USR, #10-24
26 297976A1 1 SWITCH, Inc. 27, 28
27 182068A1 1 CONNECTOR
28 182070A1 1 RETAINER
29 296852A1 1 SUPPORT
30 440-10828 2 SCREW, Cross Pan Hd, #8-32 x 1 3/4″, No. 8 x 1-3/4, If Used
30 440-11028 2 SCREW, Cross Pan Hd, #10-24 x 1 3/4″, No. 10 x 1-3/4, If Used
31 231-14408 2 NUT, LOCK, #8-32, GB, No. 8, If Used
31 231-51409 2 NUT, Flg, USR, #10-24, If used
32 302292A1 1 PLASTIC PLUG
33 L18337 1 STRAP, CABLE, 9.95″-12.1″ lg, 15 in
33 435437A1 1 STRAP, CABLE, 3/16″ x 7 1/4″

04-30 FIELD TRACKER® – MOUNTING, POTENTIOMETER

Pos Part no. Qty Description
1 126771A1 1 POTENTIOMETER, Sensor, 4K
2 463-31020 2 SCREW, Hex Wash Hd, #10-24 x 1 1/4″, No. 10 x 1-1/4
3 253108A1 1 SUPPORT
4 281-14812 2 SCREW, SELF TAPPING, Hex Wash Hd, 5/16″ x 3/4″, 5/16 x 3/4
5 495-11022 2 WASHER, #10, (7/32″ x 7/16″ x 3/64″)
6 189728A1 1 LEVER, Activator
7 492-11010 2 WASHER, LOCK, #10
8 253071A1 1 HARNESS, WIRE, Sensor Wire
13 253109A1 1 SUPPORT
14 413-516 1 BOLT, Hex, 5/16″-18 x 1″, G5, Full Thd, 5/16 x 1
15 492-11031 1 WASHER, LOCK, 5/16″
16 425-105 1 NUT, 5/16″-18, G5
17 100282A1 2 BALL JOINT, 1/4 NF
18 492-11025 2 WASHER, LOCK, 1/4″
19 425-114 4 NUT, 1/4″-28, G5
20 100281A1 1 STEM
21 253076A1 1 SUPPORT
22 413-516 2 BOLT, Hex, 5/16″-18 x 1″, G5, Full Thd, 5/16 x 1
23 492-11031 4 WASHER, LOCK, 5/16″
24 425-105 4 NUT, 5/16″-18, G5

04-31 LAMP ASSY – DRIVE AND FLOOD

Pos Part no. Qty Description
1 137821A1 1 BEZEL, Lamps, RH
2 137819A1 1 BEZEL, Lamps, LH, Not Illustrated
3 137829A1 18 SCREW, No. 10 x 3
4 86632551 18 NUT, LOCK, #10-24, GB
5 137831A1 18 RETAINER
6 138224A1 1 LAMP, WORK, Drive, Right Hand
7 137823A1 2 BULB, 45W, 65W
8 137825A1 2 COLLAR, RETAINER
9 138225A1 2 LAMP, WORK, Flood, Right Hand
10 137827A1 4 SOCKET, LAMP
11 137828A1 4 BULB, 65W
12 260-16512 16 SCREW, SELF TAPPING, Cross Pan Hd, #10 x 3/4″
13 131-648 16 NUT, Tinn, U, #10-24, No. 10

04-32 LAMP ASSY – DRIVE AND FLOOD

Pos Part no. Qty Description
1 339704A1 1 BEZEL, Lamps, Right Hand, Fixed
2 339705A1 1 BEZEL, Lamps, Left Hand, Fixed, Not Illustrated
3 1327506C1 24 SCREW, SELF TAPPING, Cross Pan Hd, M4.8 x 19, Coated
4 353656A1 2 HEADLIGHT, Trapezoidal
5 353657A1 4 HEADLIGHT, Flood
7 137823A1 2 BULB, 45W & 65W
8 137825A1 2 COLLAR, RETAINER
10 137827A1 4 SOCKET, LAMP
11 137828A1 4 BULB, 65W
12 260-16512 16 SCREW, SELF TAPPING, Cross Pan Hd, #10 x 3/4″

04-33 LAMP ASSYS – WARNING – CONSOLE LAMP ASSY

Pos Part no. Qty Description
1 130882C91 4 LIGHT, INTERIOR, WARNING ASSEMBLY, Inc. 2 – 4
2 130883C1 1 LENS, Amber
3 A41264 1 BULB, #1156, 12V
5 231-51409 4 NUT, Flg, USR, #10-24
6 261-54536 4 SCREW, SELF TAPPING, Cross Pan Hd, #10 x 2 1/4″, No. 10 x 2-1/4
7 440-11036 4 SCREW, Cross Pan Hd, #10-24 x 2 1/4″, No. 10 x 2-1/4
8 92260C1 2 LAMP, Stop and Tail Assembly, Inc. 9 – 11
9 216045C1 1 LENS, Red
10 T34857 1 BULB, C6, #1157, 12.8V
12 261-54536 4 SCREW, SELF TAPPING, Cross Pan Hd, #10 x 2 1/4″, No. 10 x 2-1/4
13 429726A1 2 DOME LIGHT, ASSEMBLY, Inc. 14
14 E35556 1 BULB, 12V, 10w
16 107329C1 1 HARNESS, WIRE
17 D71346 1 LAMP, TAIL, No. 168
18 440-10812 2 SCREW, Cross Pan Hd, #8-32 x 3/4″, No. 8 x 3/4

04-34 MOUNTING, LAMP – GRAIN TANK

Pos Part no. Qty Description
2 A41264 1 BULB, #1156, 12V
3 1317942C1 1 BRACKET
4 231-5146 1 NUT, Flg, USR, 3/8″-16
5 477-73116 1 SCREW, Sltd Serr Truss Hd, 5/16″-18 x 1″, 5/16 x 1
6 409-7616 1 BOLT, Hex Flg, 3/8″-16 x 1″, Serr
7 231-5145 1 NUT, Flg, USR, 5/16″-18

04-35 LAMP ASSY – SIEVE – ASN JJC0254000

Pos Part no. Qty Description
4 323094A1 1 BULB, Halogen, 894-12V
5 403062A1 1 BEZEL

04-36 BATTERY – CABLES

Pos Part no. Qty Description
1 BMF31G 2 BATTERY, DRY, 12V
2 278034A2 1 CABLE, Positive, Inc. 3, BSN JJC0256399
2 87419381 1 CABLE, Positive, Inc. 3, ASN JJC0256400
3 S115407 1 BOOT
4 515-23286 17 CLAMP, 1 1/8″, Insul, 3/8″ Bolt, Replaces 515-23254
4 515-25286 1 CLAMP, 1 1/8″, Insul, 3/8″ Bolt
5 278043A1 1 CABLE, BATTERY (NEG), Ground
7 128742A2 1 CABLE, GROUND, Engine Ground
9 413-632 1 BOLT, Hex, 3/8″-16 x 2″, G5
10 492-11038 1 WASHER, LOCK, 3/8″
11 425-106 1 NUT, 3/8″-16, G5
12 L18337 2 STRAP, CABLE, 9.95″-12.1″ lg, 15 in.
14 128289A1 2 SCREW
15 231-5145 2 NUT, Flg, USR, 5/16″-18
16 515-23127 1 CLAMP, 1/2″, Insul, 3/8″ Bolt
17 231-5146 2 NUT, Flg, USR, 3/8″-16, Not Illustrated
18 409-7616 1 BOLT, Hex Flg, 3/8″-16 x 1″, Serr, Not Illustrated
19 1301387C2 1 CLIP, 2 in ID, Square
20 515-25254 1 CLAMP, 1″, Insul, 1/2″ Bolt
21 190158A1 1 BLOCK, Junction
22 245739C1 1 BUSHING, Jump Start
23 277019A2 1 CABLE, Cab Power
24 399470R1 1 BOOT

04-37 BATTERY – BOX

Pos Part no. Qty Description
1 142490A2 1 SUPPORT, No Longer Used, Order 307071A1
2 142495A2 2 SUPPORT
3 409-7616 5 BOLT, Hex Flg, 3/8″-16 x 1″, Serr
4 231-5146 5 NUT, Flg, USR, 3/8″-16
5 409-7512 4 BOLT, Hex Flg, 5/16″-18 x 3/4″, Serr
6 231-5145 4 NUT, Flg, USR, 5/16″-18
7 A147915 1 BOLT
8 425-104 1 NUT, 1/4″-20, G5
9 A162337 1 CLAMP
10 142496A1 1 COVER
11 480523R1 2 SPLIT PIN/SAFETY PIN
12 131-415 4 NUT, LOCK, Push, Bolt Retainer, 3/8″ x 25/32″
13 135370A1 2 STRIP, PROTECTION, 194 mm (7-5/8 in), Cut From 1330108CX, Not Illustrated
14 A181436 1 BOX, TOOL, , BSN JJC0253999
15 143481A1 1 SUPPORT, , BSN JJC0253999
16 409-7512 2 BOLT, Hex Flg, 5/16″-18 x 3/4″, Serr
17 231-5145 2 NUT, Flg, USR, 5/16″-18
18 397115A2 1 TUBE, , ASN JJC0254000

04-38 ALTERNATOR – MOUNTING

Pos Part no. Qty Description
1 125849A1 1 ALTERNATOR, 135 amp, See Figure 04-40
2 86975356 1 PULLEY, , BSN JJC0255699
2 J926858 1 PULLEY, , ASN JJC0255700
3 854-12065 1 BOLT, Hex Flg, M12 x 65, 10.9, M12 x 65; 10.9, BSN JJC0255699
4 854-12050 1 BOLT, Hex Flg, M12 x 50, 10.9, , BSN JJC0255699
5 829-2312 2 NUT, M12 x 1.75, Flg, Cl 10, M12; 10.9, BSN JJC0255699
6 J911485 1 SUPPORT, , BSN JJC0255699
6 J944312 1 BRACE, , ASN JJC0255700
7 614-8030 1 BOLT, Hex, M8 x 30, 8.8, , BSN JJC0255699
8 360-820 1 BOLT, Hex Flg, 1/2″-13 x 1 1/4″, G8, Full Thd, 1/2 x 1-1/4, BSN JJC0255699
9 892-11008 1 WASHER, LOCK, M8
10 143953A1 1 ELBOW, 90 degree, BSN JJC0255699
11 179418A1 1 TUBE, , BSN JJC0255699
12 1979627C1 1 COVER
13 214-1532 2 CLAMP, HOSE, #32, 1.56/2.50 Type F Worm, W/liner, , BSN JJC0255699
14 1964826C1 1 GROMMET
15 1338890C1 1 COVER
16 825-1405 8 NUT, M5, Cl 8
17 495-31025 4 WASHER, 3/16″, 1/4 x 9/16 x 3/64
18 425-147 1 NUT, Jam, 7/16″-14, G5, 7/16
19 492-11044 1 WASHER, LOCK, 7/16″
20 825-1404 1 NUT, M4, Cl 8
21 892-11004 1 WASHER, LOCK, M4
22 87030021 1 BOLT, Hex Flg, M12 x 150, 10.9, M12 x 150, ASN JJC0255700
23 857-10020 1 BOLT, Hex Flg, M10 x 20, 10.9, , ASN JJC0255700
24 825-2412 1 NUT, M12 x 1.75, Flg, Cl 8, M12; 8, ASN JJC0255700
25 409-7820 1 BOLT, Hex Flg, 1/2″-13 x 1 1/4″, Serr, , ASN JJC0255700

04-39 STARTER – MOUNTING – BSN JJC0256399

Pos Part no. Qty Description
1 193432A2 1 MOTOR, See Figure 04-41
2 868-12035 3 SCREW, 12 Pt Hd, M12 x 35, 12.9, M12 x 35; 12.9
3 892-11012 3 WASHER, LOCK, M12
4 829-1412 1 NUT, M12, Cl 10, Used with 193432A2
4 829-4410 1 NUT, Thin, M10 x 1.5, Cl 05, Used with 87419387
5 892-11012 1 WASHER, LOCK, M12, Used with 193432A2
5 892-11010 1 WASHER, LOCK, M10, Used with 87419387
6 258820A1 1 SCREW, M5 x 8
7 892-11005 1 WASHER, LOCK, M5
8 430382A2 1 SHIELD, Starter
9 614-8020 3 BOLT, Hex, M8 x 20, 8.8
10 496-21034 3 WASHER, 11/32″ x 11/16″ x 0.89″, HDN
Pages: 1 2 3 4 5 6 7 8

Leave a Reply

Your email address will not be published. Required fields are marked *